Professional Documents
Culture Documents
NEMA23 570 oz/in 3.5A 1/4” Dual Shaft Stepper Motor (KL23H2100-35-4BM)
Or 3/8 shaft NEMA23 570oz/in 5A 3/8” Dual Shaft Stepper Motor (KL23H2100-50-4B)
And a 16 mm ballscrew
Precision (TRUE C7) 16mm Ball Screw 1605 w/ BF/BK12300 mm long off
Torch mount robot 3 t with proxy senc mod made aul ange for the mount
Thc is a robot 3 t up down unit also used a proma 150 . like to try the price unit next
The units were custom made all parts were from mcmaster carr
2 24 volt Mean Well 1 amp 1 5 volt mean well 3 amp Din rail mounts
24 and 5 volt for the controller the other 24 volt for the torch height controller
On off switch universal switch 600V 20A 8 Terminals 2 Positions 2Pole Selector Cam Changeover Switch
LW28-20/2.C04
120 v fan GDSTIME AXIAL Fan 12038, 110V 120V AC 120mm Fan, Ventilation Exhaust Projects Cooling
Fan
Fan filters ELUTENG 120mm Fan Filter 2 Pack IP40 Dustproof Blower Guard ABS Computer Ventilator
Grill 12cm Fan Mesh Cover Tool-Free Fan Strainer Compatible for 120x120 Case Fan USB Cooling Fan
Estop switch Baomain Emergency Stop Switch Push Button Switch AC 600V 10A Red Mushroom 22mm
NO NC
All Neg wires connect to a ground buss that does not connect to the frame gnd
Even 1 end of the shielded wire only frame gnd is the Neg ac plug
Motor power to drivers separate run 12 ga to each driver do not daisy chain
Ethernet Feed threw the case ASI ASICPICRJ45S RJ45 Panel Mount, Waterproof Connector (When Used
with Cap), Shielded, Front Mount, Female, IP67, NEMA 6P, Cap Sold Separately
Use all shielded Ethernet wire Buhbo 2 ft CAT7 Shielded RJ45 Ethernet Network Snagless Cable 10Gbps
600 MHz, White
Buhbo 10 ft CAT7 Shielded RJ45 Ethernet Network Snagless Cable 10Gbps 600 MHz, White
Ethernet Xover plug CableCreation (Crossover) Adapter, Cat6/Cat5e Ethernet RJ45 Male/Female Adapter
to Connect 2 Computers with a Standard LAN Cable, Red Color
Controller uccnc software AXBB-E ethernet motion controller and breakout board combined controller
The table frame has a water pan 10 ga 4 inch 52 x 52 2 inch 1/8 slats with cut angle holding them
The main frame is made of 3/16 2 x 4 tubing same for legs leg support 2x2 3/16
Adjustable ¾ feet adjust side rails 2x4 with ½ x4 cold rolled I sugest linear slides instead but cold rolled
works well
Side trucks were drawn and custom cut bearings are ½ id 1/1/8 od bearings same for reduction unit
I designed adjustable side rails using 24 thred ¾ rod about 4 years ago on a first build it made is easyet
to adjust the cold rail dead on side to side up and down