Professional Documents
Culture Documents
(Docs0009) Gl1 Manual v3.02 en GSM
(Docs0009) Gl1 Manual v3.02 en GSM
Installation manual
ENGLISH v3.02
11.2012
SafeLine GL1
Installation manual
TECHNICAL DATA
Power: 12 V DC or 20 - 30 V DC
Current consumption: 12 V DC
50 mA Standby
Size H x W x D: 89 x 138 x 30 mm
safeline.eu
Table of contents
Installation
Components 4 Using the SIM-card 5
Connecting the unit 4
Menu
LED indication 6 Increase RX audio level 6
Service
Troubleshooting 7 Interference/Poor sound quality 7
GL1 v3.02 EN 3 © 2015 SafeLine and all the SafeLine products and accessories are copyrighted by law.
Installation
COMPONENTS
1 Do not use
2 Do not use
7 3 Line out
5 RJ12 4 Line out
5 Do not use
4 6 Do not use
6
0V
12 VDC
20 - 30 VDC
1. LEDs
5. Power
2. Reset button 12 or 20 - 30 VDC
Push the button for 3 sec to see GSM field
intensity. Refer to chapter about LED indication. 6. Phone line out
>> 1,5m
© 2015 SafeLine and all the SafeLine products and accessories are copyrighted by law. 4 GL1 v3.02 EN
Installation
Before you can start using a new SIM card, the card has to be prepared and support 2G network.
Cards that only support 3G will not function.
• If the code is set to “1234” the SIM card can be moved to another SafeLine GL1/GL2/GL4/GL5 unit
if the software version is 3.10 or higher.
• If the PIN code is set to “0000” or if it is deactivated the SIM card can be moved from the SafeLine
GL1 to any of SafeLine GSM products.
• If the PIN code is set to “1111” the SIM card cannot be moved to any other telephone (SafeLine or
otherwise) without the PUK code.
Do not activate the voicemail or if possible ask your provider to deactivate the voicemail.
If the Pin code is set to “1111” the SIM cards code will be randomly changed by the SafeLine GSM unit
and memorised. This way the SIM card can only work with the SafeLine GSM unit unless you use the PUK
code for setting up a new PIN code.
If you want to upload a new SIM card with PIN code “1111” you will need to first upload a SIM card with
PIN code “1234” or “0000” this to clear the old code in memory.
NOTE!
If you enter the wrong PIN code 3 times, the SIM card will be blocked (requires
PUK code to de-block). The GL1 cannot be started and the LED (4) will be red.
If PIN code “1234” is used, make sure the SafeLine GL1 software is 3.10 or
higher.
GL1 v3.02 EN 5 © 2015 SafeLine and all the SafeLine products and accessories are copyrighted by law.
Menu
LED INDICATION
Signal strenght
Increase the GSM receiving audio level by use of the setup mode.
+0%
1. To enter setup mode, first disconnect the power.
2. Then press the button and hold while restarting power and then for a +25%
further 8 seconds without letting go. The setup mode is now active.
3. To setup the GSM receiving audio level press the button to reach +50%
desired output level. The increase is in steps of 25% per push.
4. When the desired level is reached, turn off the power. +75%
5. Then restart the unit. The new GSM receiving audio level is now stored.
+100%
Use this function with caution! The voice switching of the emergency phone
will be affected. +75% or +100% may only be used in uniqe installations
where it’s difficult to get the telephone to switch from the receiving part.
© 2015 SafeLine and all the SafeLine products and accessories are copyrighted by law. 6 GL1 v3.02 EN
Service
TROUBLESHOOTING
The red LED does not start flashing when unit is connected to supply voltage.
• Check the supply voltage polarity.
• Make sure that the supply voltage is: 12 or 20-30 VDC.
• Bear in mind that the wiring between GL1 and the lift telephone/phone is basically a standard
PSTN-line and can therefore not be placed in the lifts travelling cable together with high voltage.
***(Risk of interference)***
• Always place the antenna in an upward position and at least 1,5m from GL1.
• Place the antenna where the highest field intensity is obtained according to the table on the unit.
• When a call is connected try placing the antenna in different places to find where the best
receiving/sending position is.
GL1 v3.02 EN 7 © 2015 SafeLine and all the SafeLine products and accessories are copyrighted by law.
SafeLine Sweden SafeLine Europe
Antennvägen 10 Interleuvenlaan 62
13548 Tyresö 3001 Heverlee
SWEDEN BELGIUM
safeline.eu/support