Professional Documents
Culture Documents
This course has been framed to enable the students to find out the type of plastics,
similarities and dissimilarities based on various observation and testing methodologies
Objective:
The course will help the participants to gain knowledge about various types of plastics
available like commercial plastics, special plastics, biodegradable etc. in addition to that
the students can able to identify its type by various methods like burning test, cutting
test, floatation test, bending test, dropping test, solubility test.
Co-ordinator: G. Manojkumar
Tuesday, 21-10-2021
Tuesday, 22-10-2021
Thursday, 25-10-2021
Friday, 26-10-2021
Coordinator HOD/MECH
ARJUN COLLEGE OF TECHNOLOGY
Approved by AICTE- New Delhi & Affiliated to Anna University, Chennai
Thamaraikulam- Negamam Road, COIMBATORE -642120
ACT/MECH/VAC/Circular/2021-01 09-10-2021
CIRCULAR
students from 21-10-2021 to 26-10-2021. Students are informed to attend the program without fail.
Coordinator HOD
Copy to:
1. Faculty Circulation
3. Notice Board
4. File
ARJUN COLLEGE OF TECHNOLOGY
Approved by AICTE- New Delhi & Affiliated to Anna University, Chennai
Thamaraikulam- Negamam Road, COIMBATORE -642120
SYLLABUS
IDENTIFICATION OF PLASTICS
OBJECTIVE:
UNIT-I 6 Hours
Identification of polymers by simple methods like density, melting point, burning characteristics, solubility and
confirmatory test by chemical analysis – Polyethylene - Polypropylene – Polystyrene
UNIT-II 6 Hours
Identification of polymers by simple methods like density, melting point, burning characteristics, solubility and
confirmatory test by chemical analysis – Polyvinyl Chloride – Polyamide - Polyethylene terephthalate
Polybutylene terephthalate
UNIT-III 6 Hours
Identification of polymers by simple methods like density, melting point, burning characteristics, solubility and
confirmatory test by chemical analysis – Polycarbonate – Polyacetal
UNIT-IV 6 Hours
Identification of polymers by simple methods like density, melting point, burning characteristics, solubility and
confirmatory test by chemical analysis – Polyphenylene oxide - Polyphenylene sulphide
UNIT-V 6 Hours
Identification of polymers by simple methods like density, melting point, burning characteristics, solubility and
confirmatory test by chemical analysis – Phenol Formaldehyde resin - Urea formaldehyde resin - Melamine
formaldehyde resin
REFERENCE:
1. Identification of plastics and rubbers by simple methods, CIPET publications 2002
2. V.R. Gowariker, “Polymer Science” – New Age International (P) Ltd, Publishers
Department of Mechanical Engineering
Attendance Sheet
DATE:
FEEDBACK FORM
STUDENT NAME:
6. Comments
Mobile no:
E-mail: Signature