Professional Documents
Culture Documents
17
AN OVERVIEW INDICATORS & GAUGES
18
STEERING LOCK CUM IGNITION SWITCH AN OVERVIEW
Steering Lock cum Ignition ACC :
Switch: By turning key to ACC (key in)
position, all accessories function
like music system will be ‘ON’.
ON:
Engine running and all electrical
gadgets and accessories ON.
START:
Turn the key further clockwise to the
START position (spring loaded) to
start the engine. As soon as the
engine starts release the ignition key
to ON position. While cranking, all
Key of ignition switch is common for accessories will be momentarily
door lock & steering lock. ‘OFF’.
The ignition switch is on the right NOTICE
side of the steering column. The
switch has four positions. Do not crank the engine more
than 10 seconds continuously. If
LOCK - Steering Locked
the engine does not start wait for
ACC - All accessories 30 seconds before cranking it
function ‘ON’. again. Release the key
ON - Vehicle ON and all immediately after starting the
electricals ‘ON’ engine.
START - Engine crank By turning the ignition key from ‘ON’
position to ‘ACC’ position, engine
LOCK: can be stopped.
You can insert or remove the key
only in this position. The steering
column is locked when the key is
removed.
WARNING
Do not remove the key while
driving. It will lock the steering
and can cause loss of control.
Remove the key only when the
vehicle is parked.
19
AN OVERVIEW COMBINATION SWITCH
20
LIGHT CONTROL SWITCH
NGE
3) Lane change for Left or Right
RIGHT LANE CHA
RIGHT TURN Turn (Self cancellation / Manual
return type)
Push the stalk upwards for changing
lane or turning to Left and downwards
for changing lane or turning to Right
according to requirement. It has three
positions.
21
AN OVERVIEW COMBINATION SWITCH
22
COMBINATION SWITCH AN OVERVIEW
3) Side Indicator : Music System (if applicable) :
2) Lane change for Left or Right For operation and further information
Turn (Spring Return) of music system please refer
manufacturer’s manual.
3) Lane change for Left or Right
Turn (Self cancellation / Manual
return type)
B) LEFT HAND STALK
1) Front Windshield - Wipe and
wash :
23
AN OVERVIEW HVAC & AIR CONDITIONING
HVAC
AC
A - Air direction mode selection knob
B - Blower speed selection knob
C. Temperature-Control Knob :
C - Temperature control knob The air temperature in the vehicle
D - AC ON/OFF switch can be controlled by operating the
E - Air recirculation / Fresh air lever
temperature control knob (C) on the
A. Air direction mode selection control panel. The temperature can
knob : be increased by rotating the knob
The air flow can be changed by towards the red dot and decreased
turning the knob (A) to the desired by rotating it towards the blue dot.
direction.
24
HVAC & AIR CONDITIONING AN OVERVIEW
E. Recirculation / Fresh Air knob: Whenever discomfort is felt switch
to fresh air circulation mode.
Recirculation Fresh Air
mode mode NOTICE
• We strongly recommend AC to
be used in recirculation mode
for better cooling.
• Use fresh Air mode only when
HVAC
discomfort is felt.
Fresh • The AC can be switched `ON'
only if the blower is 'ON' and
engine is running. When AC is
switched 'ON' engine idling
RPM increases marginally, to
adjust to the AC compressor
Recirculation
load. When desired
temperature is achieved AC
AC trips 'OFF' automatically.
• To put air circulation mode in • The AC compressor is switched
recirculation, slide the knob 'E' 'OFF' automatically when
towards recirculation mode engine gets overheated. The
(HVAC version) / rotate the knob AC is automatically switched
‘E’ towards recirculation mode 'ON' when the engine cools
(AC version) and vice-versa. down.
• In recirculation mode, air inside
the vehicle is circulated again
and again. In Fresh Air mode,
air is taken from atmosphere
and circulated in the vehicle.
Recirculation mode can be used
• While driving in dusty condition
• To avoid traffic pollution
• To get quick cooling/heating as
required.
25