Professional Documents
Culture Documents
R230 Screener
Engine Alarm & Inspection Lamp
Function LED On/Off
indicators
Engine Speed
(see next section for Ramp
details)
Ignition Switch
Control panel is equipped with display screen which is used to report hours run, engine
rpm, as well as plugged connectors for main harness.
Familiarisation 9
Panel Warning Indicators
The following table gives an overview of the most common fault indicators located on the
front of JMG Systems Control Panels. Some of these are optional depending on the
application.
Description of
Image Fault indicator Effect
operation
If it fails to illuminate when the key is
Lights as soon as key switch
turned on or if it illuminates when the
is turned to the "on"
engine is running, it indicates that there
Battery Charge position. As soon as the
is a fault in the charging circuit.
Engine starts it should go
Stop the engine and have the circuit
out.
Checked.
Hydraulic Oil Lights only if the hydraulic The Engine will shut down 5 seconds
Level Warning oil level is low. after the fault has been detected.
Coolant Level Lights if the coolant drops The Engine will shut down 5 seconds
Warning to a low level. after the fault has been detected.
Engine Lights only if overheating The Engine will shut down 5 seconds
Temperature occurs in the coolant after the fault has been detected.
Warning system. (Function not available on R230)