Professional Documents
Culture Documents
100 mm wood post BC and a 25-mm-diameter supports an automobile of mass 1800 Kg. If
steel eyebar AB as shown below. The hoist member AB is a steel bar 15 mm in diameter,
supports a load W of 30 KN. Determine the axial determine the axial stress in member AB and the
stresses in members AB and BC and the cross- diameter of member EF if the allowable normal
shearing stress in the 25-mm-diameter bolt at A stress in that member is 80 MPa.
which is in double shear.
4m 4m 4m
B A B C D
E
W 1.5 m 9m
F
A C
G
2.1 m 1.5 m
PRO BL EM 3] The round bar shown below has PRO BL EM 5] A brass tube with an outside
steel, brass, and aluminum sections. Axial loads diameter of 50 mm and a wall thickness of 9.5 mm
are applied at cross sections A, B, C, and D. If is connected to a steel tube with an inside diameter
the allowable axial stresses are 125 MPa in the of 50 mm and a wall thickness of 6.35 mm by using
steel, 70 MPa in the brass, and 85 MPa in the a 19 mm diameter pin as shown. The working
aluminum, determine the required diameters for stresses in tension for brass and steel are 75 MPa
each of the sections. Each segment is 500 mm and 130 MPa, respectively. Determine the safe
long. value of P based on tensile strength. Assume hole
diameter is 1 mm larger than pin diameter.
B C D Determine the corresponding cross-shearing
A stress in the pin and maximum bearing stress
270 KN 245 KN 200 KN 225 KN possible.
Steel
Brass Aluminum
P P
B
100
A 200 mm mm