Professional Documents
Culture Documents
Power Distribution Rack PDR Material: Supply includes: Power Distribution Module
◾ To accommodate a maximum – Sheet steel – Enclosure frame with door PDM
of 8 PDM (without tubular door frame) ◾ Mechanically latchable in the
Surface finish:
◾ Height 1.20 m for 4 PDM and – Rear panel PDR
– Enclosure frame: Dipcoat-
2 m height for 8 PDM – Side panels and roof plate ◾ Scalable
primed
◾ PDM may be retrofitted whilst – Levelling feet incl. base/plinth ◾ RC circuit-breaker, optional
– Doors, roof and base/plinth:
operational adaptor
Dipcoat-primed, powder- Supply includes:
◾ A maximum of 32 racks may – Earthing of all enclosure panels
coated – 482.6 mm/19˝ module, 3 U
be fitted to the sub-distributor – Busbars shock-hazard-
– Gland plates, punched sec- – Master switch
◾ Fully shock hazard-protected protected
tions with mounting flanges and – 4 fused 3-phase outlets to the
◾ Master switch in various con- – Integral master switch
mounting angles: Zinc-plated, rack
figurations:
clear chromated Note: – 3 x 230 V/16 A per outlet
– Isolator switch
– Observe the standards of the – Connected load 400 V, 3 AC,
– Fuse-switch disconnector Colour:
local electricity supply compa- max. 63 A
– Air circuit-breaker – RAL 7035
nies
– RC circuit-breaker Photo shows a configuration
◾ Low-voltage distribution up to Approvals: example with equipment not
250 A – VDE included in the scope of supply
Technical details:
Available on the Internet