Professional Documents
Culture Documents
Bookmarks X
*This document is best viewed at a
Options
screen resolution of 1024 X 768.
Features
Cover Page
To set your screen resolution do the following:
Tables RIGHT CLICK on the DESKTOP.
Component Select PROPERTIES.
Connector
CLICK the SETTINGS TAB.
Schematic
Machine Views
MOVE THE SLIDER under SCREEN RESOLUTION
Chassis View until it shows 1024 X 768.
Cab View CLICK OK to apply the resolution.
Engine View
*Due to different monitor sizes and PDF reader preferences
The Bookmarks panel will allow you to there may be some variance in linked schematic locations
quickly navigate to points of interest.
EC-C1
When only one callout is showing on a
machine view, clicking on this button will
Click on any text that is BLUE and make all of the callouts visible. This
underlined. These are hyperlinks button is located in the top right corner
that can be used to navigate the of every machine view page.
schematic and machine views.
CHECK
ACCUMULATORS Unidirectional Bidirectional Control Line Restriction
Valves (Variable)
VARIABLE DISPLACEMENT
Basic Spring Shuttle NON- COMPENSATED
Pilot
Symbol Loaded Line Restriction
Controlled Spring Loaded Gas Charged Restriction
(Fixed)
Unidirectional Bidirectional
MAIN AUX.
PILOT CONTROL
Line Restriction 2-Section
RELEASED PRESSURE ROTATING SHAFTS Variable and Pressure
Compensated
Pump
Unidirectional Bidirectional
External Return Internal Return
Attachment Pump: Variable and
REMOTE SUPPLY PRESSURE Pressure Compensated
COMBINATION CONTROLS
LINES MEASUREMENT
Solenoid Solenoid Solenoid Solenoid and Servo Thermal Detent Crossing Joining
or Manual and Pilot Pilot or Manual Pressure Temperature Flow
Push-pull Lever Manual Shutoff General Manual Push Button Pedal Spring Vented Pressurized Return Above Fluid Level Return Below Fluid Level
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of Harness Connector Serialization Code: The "C" stands for
"Connector" and the number indicates which connector in the
a normally open reed switch; it opens the contacts of a normally closed reed switch.
harness (C1, C2, C3, ...)
L-C12
Sender: A component that is used with a temperature or pressure gauge. 3E-5179
The sender measures the temperature or pressure.
T Its resistance changes to give an indication to the gauge of the temperature or pressure. 5A
Component
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. Fuse (5 Amps) 9X-1123 Part Number
It has a coil that makes an electromagnet when current flows through it.
The electromagnet can open or close the switch part of the relay. 325-AG135 PK-14
Harness identification code:
This example indicates wire group 325, Wire Gauge
Solenoid: A solenoid is an electrical component that is activated by electricity. wire 135 in harness "AG". Wire Color
It has a coil that makes an electromagnet when current flows through it.
The electromagnet can open or close a valve or move a piece of metal that can do work. 1 Deutsch connector: Typical representation
of a Deutsch connector. The plug contains all
2 sockets and the receptacle contains all pins.
Magnetic Latch Solenoid: An electrical component that is activated by electricity and held latched by a
permanent magnet. It has two coils (latch and unlatch) that make electromagnet 1 Sure-Seal connector: Typical representation
when current flows through them. It also has an internal switch that places of a Sure-Seal connector. The plug and receptacle
2 contain both pins and sockets.
the latch coil circuit open at the time the coil latches.
UENR7116-03
May 2019
390F Excavator
Hydraulic System - Attachment
HJD1-UP
TYE1-UP
MGF1-UP
FEH1-UP
HSM1-UP
GAY1-UP
HNG1-UP
YHT1-UP
© 2019 Caterpillar CAT, CATERPILLAR, their respective logos, “Caterpillar Yellow”, and the POWER EDGE trade dress as well as
All Rights Reserved corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.
COMPONENT LOCATION
Tap Schematic
Description
Number Location
AA Boom Pump Output Pressure B-4
BB Stick Pump Output Pressure B-1
CC Power Shift Pressure C-2
DD Stick Pump NFC PRV Pressure C-3
EE Boom Pump NFC PRV Pressure C-3
PG Pilot Pressure A-7
SOS Oil Sampling Port A-7
8 7 6 5 4 3 2 1
48 HYD LOCK SOL
34
47 TRAVEL SPEED CHANGE SOL
PM2-CV3
SINGLE
Pi5 Pi4
46 SWING BREAK SOL
(EXT) PMDr-CV3
(9) MOTOR GP (10) MOTOR GP
Dr4
R7 (RET)
45 PUMP 2 NFC PRV
TRAVEL (LH) TRAVEL (RH) L7 20 19 21 22
209-5895 209-5895 44 PUMP 1 NFC PRV
TRAVEL MOTOR (LEFT) TRAVEL MOTOR (RIGHT) (8) MOTOR GP
SINGLE
F PM2-SW SWING (REAR) 43 PS PRESS EPRV F
295-9446
(15) SENSOR GP (14) SENSOR GP 42 PUMP 2 DISP SENSOR (ANALOG)
AUX1 RIGHT AUX1 LEFT DB SWING MOTOR (FRONT) PG1 PG2 DB SWING MOTOR (REAR)
PRESSURE (EXTEND) PRESSURE (RETRACT)
46
41 PUMP 1 DISP SENSOR (ANALOG)
Pi ATCH 344-7392 PG PR
344-7392
Pi PD 40 TRAVEL RIGHT PILOT PRESS SENSOR
Pi
Pi 39 TRAVEL LEFT PILOT PRESS SENSOR
Dr
Dr
Dr 38 PUMP 2 BYPASS CUT PRV
Dr
37 PUMP 1 BYPASS CUT PRV
PG PG (HEAD) PA PB PA PB
L6a R6 (ROD)
36 STRAIGHT TRAVEL PRV
L6b
14 13 15 16
M M
35 FLOW COMBINER PRV
30
(HEAD)
(7) MOTOR GP A1 B1 TS A B 34 STICK SIDE WARM-UP SOL
AG BG BG AG
SWING (FRONT) 33 BOOM SIDE WARM-UP SOL
A B B A 295-9447 (32) VALVE GP
(21) SENSOR GP
PRESSURE (STICK EXTEND)
SWING CUSHION 32 SWING RIGHT PRV
P STICK (23) SENSOR GP 315-4394
P 344-7392 PRESSURE (STICK RETRACT) 31 SWING LEFT PRV
344-7392
E 30 STICK ANTI DRIFT VALVE E
29 BOOM ANTI DRIFT VALVE
A(LOWER) B(UPPER) A B B(LOWER) A(UPPER) (R) (L)
A B
28 PUMP 2 PRESS SENSOR
(33) VALVE GP (22) SENSOR GP
D C
TRAVEL COUNTERBALANCE (LH) (FWD)
(34) VALVE GP
PRESSURE (STICK PUMP) 27 PUMP 1 PRESS SENSOR
(BKWD) 344-7392
155-9200 (FWD) (BKWD) TRAVEL COUNTERBALANCE (RH)
155-9200
Pi3b 25 SWING PRESS SENSOR
L3 R3 L4 R4 L5 (LEFT)
(27) SWIVEL GP BYPASS PS R5 L5 IDENT MACHINE ECM CONNECTOR
295-9595 TRAVEL (R) 31
pR4f (24) SENSOR GP
TRP1
P-S PRESSURE (SWING)
344-7392 PM2-TRL
2 SPEED DRAIN
TRAVEL FILTER R4 24 AUX1 LEFT PRES SNSR (RETRACT)
SHPi PM2-CV3
CONTROL
L4
STR TRAVEL
PM1-BYP 23 AUX1 RIGHT PRES SNSR (EXTEND)
PM2-CV2
TRP2
pL4b
SWING
22 AUX1 LEFT CT PRV+ (RETRACT)
(28) VALVE GP PM1-FAN PM2-SW
BUCKET CYLINDER STICK CYLINDER BOOM CYLINDER CHECK (FAN) 21 AUX1 LEFT PC PRV+ (RETRACT)
369-8475 K PM2-CV1 (1) ACCUMULATOR & MTG GP
X HYDRAULIC (CHARGED) 20 AUX1 RIGHT CT PRV+ (EXTEND)
PSA3
PSA4
PSA5
PSA2
PSA1
H
335-0546
Pi3
Pi2
Pi1
T1 A TR COMBINER 38 19 AUX1 RIGHT PC PRV+ (EXTEND)
D B TL
Pi3a
PM1-BYP D
48 18 STICK RE PRES SNSR (RETRACT)
T2 J
DR1
DR5
35 36
DR3
DR2
DR4
DR-OUT
P-IN
T-OUT
32
TLP1
pR3f 37 P-BT PMDr-CV2 12 BUCKET RE PRES SNSR (RETRACT)
(30) VALVE GP TRAVEL (L) BYPASS PBT
PM2-TRL TRL-T R5 (RIGHT)
PILOT (TRAVEL, SHUTTLE) TS PM-T PMDr-T PMDr-CV3 11 BUCKET HE PRES SNSR (EXTEND)
TP 369-8502 PMDr-CV2
(ROD) L2
Dr2
PMDr-BYP 10 BUCKET RE CT PRV+ (RETRACT)
TT Pi2 PM2-CV2
10 9 7 8
PMDr-CV1 9 BUCKET RE PC PRV+ (RETRACT)
TRAVEL (L) TRAVEL (R) R2
(HEAD) 8 BUCKET HE CT PRV+ (EXTEND)
(20) SENSOR GP 54 47 44 45 43
PRESSURE (BUCKET RETRACT)
T 7 BUCKET HE PC PRV+ (EXTEND)
344-7392 5SOL-T
(19) SENSOR GP
BUCKET PRESSURE (BUCKET EXTEND)
6 BOOM RE PRES SNSR (RETRACT)
C 344-7392 5 BOOM HE PRES SNSR (EXTEND) C
(35) VALVE GP (31) VALVE GP
B5 P
MAIN CONTROL BHPi
SOLENOID (MANIFOLD) 4 BOOM RE CT PRV+ (RETRACT)
459-9915 447-1041
(FWD) (BKWD) (BKWD) (FWD)
SHPi A5 3 BOOM RE PC PRV+ (RETRACT)
T2 T5 T1 T3 T6 T4
TLP1 TLP2 TRP2 TRP1 B4 A4 B3 A3 B2 A2 B1 A1
2 BOOM HE CT PRV+ (EXTEND)
2 SPEED
(ROD) L1 R1 (HEAD) TRAVEL CC 1 BOOM HE PC PRV+ (EXTEND)
(26) SENSOR GP
(25) SENSOR GP
PRESSURE (TRAVEL RH)
4 3 1 2
29
CONTROL EE DD IDENT VALVE ECM CONNECTOR
PRESSURE (TRAVEL LH)
344-7390
344-7390
(18) SENSOR GP
(29) VALVE GP
PRESSURE (BOOM RETRACT)
TLP1: TRAVEL LEFT PILOT 1
FAN REVERSING TLP2: TRAVEL LEFT PILOT 2
344-7392
360-4604 (16) SENSOR GP
BOOM
PRESSURE (BOOM EXTEND)
TRP1: TRAVEL RIGHT PILOT 1
A A1 P
344-7392 TRP2: TRAVEL RIGHT PILOT 2
L2
BB
L3 H3(A) CR(A) L5(A) L5(B) CR(B) H3(B)
DR B B1 T
33 LINE PATTERNS
MA A PA PB B MB Component LocationsTable)
138-1234
DRAIN (13) PUMP GP
Part Number
FILTER PILOT
PG P.P.O 369-9658
HYDRAULIC CIRCUIT COLOR DESCRIPTIONS
PILOT PUMP OUTPUT
(3) FILTER GP
(11) PUMP GP BOOM & BUCKET PUMP OUTPUT
OIL (HYDRAULIC) (CASE DRAIN) COOLING FAN PUMP CONTROL CIRCUIT
FAN
6E-5534 448-9705
SUPPLY LINE
STICK CONTROL CIRCUIT
LEFT TRAVEL MOTOR CIRCUIT
PM-T MB1 P.P.I SWING MOTOR CIRCUIT
(2) FILTER GP B
DRAIN / RETURN LINE
29
33
34
10
MACHINE VIEW - FRONT RIGHT
32
27
30
25 26
MAIN CONTROL VALVE - REAR VIEW
14 35 24 22 15 23 17
21
28
20
18
5 19 1 16
PUMP - TOP RIGHT VIEW
PG
2
11
SOS
13
AA
BB
12
CC
DD
31 EE