b) b) Cross section of a member c) Cross section of Area d) d) Cross section of perimeter 2. Section factor principle is a) Hp/V factor b) b) Hp/A c) Cross section of Area d) d) Hp weight 3. In the case of scaffolding, if there is no guard rail for safety, it is impractical then we have to arrange. a) Safety net b) Radio man c) Ladder d) Watchman 4. Scaffolding will inspect a) Every seven days b) After inclement weather c) Done by certified inspector d) All of the above 5. According to BS1710 colour of fresh water line is. a) Violet b) Orange c) Light blue d) Auxiliary blue 6. All painting shall be carried out in accordance with a ----------------- which must be prepared by contractor agreed by the engineer. a) Specification b) Procedure c) Programme of work d) Manufacture 7. The reflective stripe or coating which for secondary escape route in offshore is. a) 10 mm b) 50 mm c) 100 mm d) 75 mm 8. Based on CP-C-155 the Tank surface preparation is a) SA1 b) SA2 c) SA2 ½ d) SA3 9. In CP-C-155 coating system for used in galvanized steel is a) Epoxy coal tar b) Chlorinated rubber c) Acrylic modified d) Silicone and alkyd 10. The ambient conditions of temperature and humidity shall be within the rage and combination prescribed by the a) Painter b) Fabricator c) Safety Engineer d) Manufacturer 11. Substantial growth of foulant in a ship hull or an offshore structure is termed as a) Anti-foulant b) Hard growth c) Anti-corrosion d) Polymerisation 12. Which of the is not a toxic material formed from anti foulants a) Tin lead b) Arsenic mercury. c) Copper zinc d) Sodium carbonate 13. If the jacket is stainless steel the banding tripe is a) Same material b) Only aluminium c) Use only rubber d) Mild steel 14. Heavy metal salts (Octet or naphthenate of cobalt, manganese or zirconium rich oxygen) is an example of which additive. a) Anti settling agents b) Non driers c) Oxidants / driers d) Plasticisers 15. When viewed with out magnification the surface shall be free from visible oil, grease, dirt, midscale, paint and foreign materials. Any remaining traces of contaminations shall show only as slight stain. a) Sa1 b) Sa2 c) Sa2 ½ d) Sa3 16. Which of the following is not a rust. a) Iron hydroxide b) Hydrous iron oxide c) Fe(OH)2 d) Iron Carbonate 17. In case of millscale the oxides of iron is formed very quickly at the temperature in excess of a) 120 degree C b) 580 degree F c) 580 Degree C d) 480 degree C 18. The Polarity is referred as a) Passivation b) Polarisation c) Isolation d) Corrosion 19. Which of the following have higher potential deference. a) Graphite and Aluminium b) Carbon and magnesium c) Titanium and Zinc d) Mil scale and Mild steel 20. When we need more adhesion strength we need to … a) Increase the surface area b) Surface area increase with in the substrate. c) Smooth surface d) Increase viscosity 21. Which abrasive is angular chilled iron. a) Grit b) Shot c) Copper slag d) Garnet 22. Which method is used for the surface preparation of weathered galvanizing. a) Sweep abrasive blasting b) Stiff bristle brushing c) Water blasting d) Air blasting 23. Which anti-foulants having biocidal properties for the removal of foulants and give longer service life. a) Self polishing or ablative b) Soluble matrix type c) Contact leaching type or insoluble. d) Foulant release coating 24. Surface preparation of austenitic stainless steel (51 degree to 120 degree) in a new offshore construction a) Sa1 b) Sa2 c) Sa 2 ½ d) Sa3 25. Which one is more noble material. a) Aluminium b) Zinc c) Steel d) Silver 26. Intumescent means a) Shallow b) Swell c) Showing d) Smell 27. Application method for cementitious coating a) Spray b) Towel c) Hauk d) All of the above 28. Which of the PFP coating is added with powder portable tank with water. a) Cementitious b) Intumescent epoxy c) Vermiculate 29. Class of division H-120 is related to which area a) Deck and bulk head b) Bulk head and deck c) Deck and ceiling d) Cellulosic fire. 30. Which paint is not used in atmospheric zone (CS) a) Epoxy aluminium b) Acrylic modified 2 pack polyurethane c) Alkyd epoxy 31. First deck on the platform above the spider deck a) Helideck b) Spider deck c) Cell deck d) Cellar deck 32. What is the volume of the paint applied in a circular roof when DFT is 120 microns and radius of roof is 25 m. a) 50 Ltr b) 20 Ltr c) 235.5 ltr d) 23.55 ltr 33. Which of the following is not correct related to air hoses in wire and pistol system. a) Fuel gas -Orange/Red b) Oxygen -Blue c) Air-Black d) Air-Blue 34. Formula of density a) WFT/Volume b) Volume /Area c) 100/VS x Area d) Weight /Volume 35. Which one is closed cup tester a) Density cup b) Psykrometer c) Ford flow cup d) Abel cup 36. In ---------------------CPVC a film with lower gloss properties but greater cohesive strength and just enough resin to encapsulate each particle giving good resistance to water permeation. a) Above CPVC b) Near CPVC c) Below CPVC d) All of above 37. How much area should be done in submerged zone. a) +12 meter till -2.5 meter of LAT b) -2.5 meter till -12 meter of LAT c) +2.5 meter till +12 meter of LAT d) All of above 38. Which of the following category personnel need helicopter safety class. a) Category A b) Category B c) Category C d) All of the above 39. Which if the following is a non toxic pigments. a) Red lead b) Zinc Chromate c) Titanium dioxide d) Calcium plumbate 40. When the work permit should be signed off a) Second day after got the permit b) Start of each day c) Lunch time d) End of the day. 41. SI 1019 explains a) Health of the personnel in offshore b) Health and welfare of the personnel in offshore c) Rule of safety, health and welfare of the personnel. d) Safety of personnel working in offshore 42. Offshore main In-charge is a) Supervisor b) Engineer c) OIM d) Radioman 43. Full form of CUI a) Cathodic under instrument b) Corrosion under insulation c) Corrosion upper insulation d) Corrosion under instrument 44. Code of practice for safety during blast cleaning is a) IGE GR 21 b) BS1710 c) SI1019 d) BS4800 45. Impressed current system positive is connected to a) Ground bed b) Pipe c) Substrate d) Cathode 46. Which of the material is not used when contact with zinc. a) Aluminium b) Stainless steel c) Copper d) Both a and c 47. Which of the following is not a saturated oil. a) Caster b) Coconut oil c) Palm oil d) Copal 48. Linear polymerisation (solution polymer ) is a) Non reversible, thermoplastic b) Convertible, thermosetting c) Non-convertible, thermosetting d) Non-convertible, Thermoplastic 49. In solution polymerisation the main back bone of the structure is a) Nitrogen b) Carbon c) Oxygen d) Hydrogen 50. Area above spider deck is a) Atmospheric zone b) Helideck c) Spud deck d) Cellar deck 51. Product identification by pipe colour coding is related to a) BS 1710 b) BS 410 c) BS 4800 d) BS 3900 52. Personnel under the age of 40 must be passed medical fit every a) 1 Year b) 2 Years c) 3 Years d) 4 Years 53. Which of the following system is used in damp surface a) Inorganic zinc silicate system b) Moisture curing polyurethane system c) Poly siloxane inorganic coating d) Thermally sprayed aluminium system 54. Which of the primer is used in top sides. a) Epoxy aluminium b) Zinc rich 2 pack epoxy c) 2 pack epoxy d) All of above 55. Intumescent coating related to a) 100 percent volume solid b) PFP material c) High viscosity coating d) All of above 56. With the use of an inorganic zinc silicate the mud cracking will results a) Flexibility increases b) Reduce brittleness of paint c) Mud cracking will not occur d) If the manufacturer recommended film thickness is exceeded. 57. Which gases are used in wire and pistol system. a) Butane b) Propane c) Pure oxygen d) All of the above 58. Which coating gives aesthetic appearance, shedding of water and reflect rays. a) Initial coat b) Mid coat c) Primer d) Final coat 59. Causing chemical reaction between two surfaces a) Passivation b) Pickling c) Barrier d) Cathodic protection 60. Pigments used in paint must remain as solid particle with in the vehicle and not dissolve, If it is dissolve it is known as a) Pigment b) Solution c) Emulsion d) Dye
ChatGPT Money Machine 2024 - The Ultimate Chatbot Cheat Sheet to Go From Clueless Noob to Prompt Prodigy Fast! Complete AI Beginner’s Course to Catch the GPT Gold Rush Before It Leaves You Behind