Professional Documents
Culture Documents
PA66-G30 AHBK003
Glass Fiber Reinforced Polyamide 66
FEATURES APPLICATIONS
z High strength z Injection molding
Thermal
0.45MPa ℃ 260
Temperature of Deflection Under Load ISO 75-2
1.80MPa ℃ 250
Electrical
Volume Resistivity IEC 60093 -- Ω·cm 1015
Dielectric Strength IEC 60243-1 2mm, in oil kV/mm --
Others
Density ISO 1183-1 -- g/cm3 1.36
Equilibrium
Water Absorption ISO 62 % 1.6
23℃/50%r.h.
Ash Content ISO 3451/1 -- % 30
Flow % 0.3
Molding Shrinkage ISO 2577
Transverse % 0.9
Flammability UL 94 -- / HB
[1] These are typical values of the product’s properties, and these values alone do not represent a sufficient basis for any part
design and are not intended for use in establishing maximum, minimum, or ranges of values for specification purposes.
[2] The listed values are maybe different for pigmented material.
NOTICE: The data contained in this publication are based on our current knowledge and experience. This information may be
subject to revision without informing in advance as new knowledge and experience become available. Because use conditions and
applicable laws may differ from one location to another and may change with time, Customer is responsible for determining
whether products and the information in this document are appropriate for Customer’s use and for ensuring that Customer’s
workplace and disposal practices are in compliance with applicable laws and other governmental enactments. Seller assumes no
obligation or liability for the information in this document. NO WARRANTIES ARE GIVEN; ALL IMPLIED WARRANTIES OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR USE ARE EXPRESSLY EXCLUDED.
Product Information
PA66-G30 AHBK003
Typical Processing Conditions
Optimum Range
Melt Temp. 285℃ 280~300℃
Rear 270℃ 260~275℃
Barrel Zone Temp. Center 280℃ 270~290℃
Front 285℃ 280~300℃
Mold Temp. 70℃ 50-120℃
Processing Temp. Upper Limit 310℃
Injection Speed Moderate to high
Pre-dry Requirements Dehumidifying dryer, 90~110℃, 4~6hr
The parameter is just for referential purpose only. In actual processing, the parameter should be adjusted by
construction of mold, shape and size of product, and so on.
NOTICE: The data contained in this publication are based on our current knowledge and experience. This information may be
subject to revision without informing in advance as new knowledge and experience become available. Because use conditions and
applicable laws may differ from one location to another and may change with time, Customer is responsible for determining
whether products and the information in this document are appropriate for Customer’s use and for ensuring that Customer’s
workplace and disposal practices are in compliance with applicable laws and other governmental enactments. Seller assumes no
obligation or liability for the information in this document. NO WARRANTIES ARE GIVEN; ALL IMPLIED WARRANTIES OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR USE ARE EXPRESSLY EXCLUDED.