Professional Documents
Culture Documents
en Original instructions
2|
1 1x
1x
2x 2x 1x 2x
6.6 kg 1x 1x 1x 2x 2x 1x
STOP
!
ICK
CL
4 60 mm
40 mm
20 mm
STOP
|3
2
1
STOP
Motor Protector Fitted
Motor fitted with safety overload
protection. If motor stops working, allow
a few minutes to cool, before restarting
STOP
4 | English
Power supply
Keep supply flexible cord away from f The voltage indicated on the rating plate must
cutting means. correspond to the voltage of the power source.
f We recommend that this equipment is only
connected into a socket which is protected by a
circuit-breaker that would be actuated by a 30 mA
Operation residual current.
f Never allow children or people unfamiliar with f Only use or replace power supply cables for this
these instructions to use the machine. Local unit which correspond to the types indicated by
regulations may restrict the age of the operator. the manufacturer. See the operating instructions
When not in use store the machine out of reach of for the order no. and types.
children.
f Never touch the mains plug with wet hands.
f This tool is not intended for use by persons
f Do not run over, crush or pull the power supply
(including children) with reduced physical,
cable or extension lead, otherwise it may be
sensory or mental capabilities, or lack of
damaged. Protect the cable from heat, oil and
experience and knowledge, unless they have been
sharp edges.
given supervision or instruction concerning use of
the appliance by a person responsible for their f The extension lead must have a cross section in
safety. accordance with the operating instructions and be
Children should be supervised to ensure that they protected against splashed water. The connection
do not play with the appliance. must not be in water.
f Never mow while people, especially children or f Always wear gardening gloves when handling or
pets, are nearby. working near the sharp blades.
f The operator or user is responsible for accidents
or hazards occurring to other people or their Electrical Safety
property.
f Warning! Switch off, remove plug from mains
f Do not operate the machine when barefoot or before adjusting, cleaning or if cable is cut,
wearing open sandals, always wear substantial damaged or entangled.
footwear and long trousers.
f The blades continue to rotate for a few seconds
f Thoroughly inspect the area where the machine is after the machine is switched off.
to be used and remove all stones, sticks, wires,
bones and other foreign objects. f Caution – do not touch the rotating blade.
f Before using, always visually inspect to see that Your machine is double insulated for safety and
the blades, blade bolts and cutter assembly are requires no earth connection. The operating voltage is
not worn or damaged. Replace worn or damaged 230 V AC, 50 Hz (for non-EU countries 220 V, 240 V as
blades and bolts in sets to preserve balance. applicable). Only use approved extension cables.
Contact your Bosch Service Centre for details.
f Mow only in daylight or in good artificial light.
Extension cords/leads should only be used if they
f Avoid operating the machine in wet grass, where comply with H05VV-F, H05RN-F types or IEC type
feasible. design (60227 IEC 53, 60245 IEC 57).
f Walk, never run.
If you want to use an extension cable when operating
f Never operate the appliance with defective guards your product, only the following cable dimensions
or shields, or without safety devices, for example should be used:
deflectors and/or grass catchers in place.
– 1.0 mm2: max. length 40 m
– 1.5 mm2: max. length 60 m
– 2.5 mm2: max. length 100 m
English | 5
Accessories/Spare Parts
6 | English
Troubleshooting
STOP
Ireland Disposal
Origo Ltd. Do not dispose of garden products into household
Unit 23 Magna Drive waste!
Magna Business Park Only for EC countries:
City West According to the European directive
Dublin 24 2002/96/EC for Waste Electrical and
Tel. Service: +353 (01) 4 66 67 00 Electronic Equipment and its
Fax: +353 (01) 4 66 68 88 implementation into national law,
Australia, New Zealand and Pacific Islands electrical and electronic equipment that
are no longer usable must be collected separately and
Robert Bosch Australia Pty. Ltd. disposed of in an environmentally correct manner.
Power Tools
Locked Bag 66
Clayton South VIC 3169 Subject to change without notice.
Customer Contact Center
Inside Australia:
Phone: +61 (01300) 307 044
Fax: +61 (01300) 307 045
Inside New Zealand:
Phone: +64 (0800) 543 353
Fax: +64 (0800) 428 570
Outside AU and NZ:
Phone: +61 (03) 9541 5555
www.bosch.com.au