Professional Documents
Culture Documents
Ftherm ® X SSHEs
Application
Ftherm X series scraped surface heat exchanger is particularly suited for
continuous heating and cooling of viscous, sticky,heat-sensitive and
particulate food products. It can operate with a wide range of media
products. It is used in continuous processes such as heating, aseptic
cooling, cryogenic cooling,crystallization, disinfection, pasteurization,
and gelation. Standard Design
Ftherm ® X SSHEs
Connections
Product side 52 mm (2 inch) or 76 mm (3 inch), SMS, DIN,or Clamp
Media side 52 mm (2 inch), NPT or flange
Optional equipment
• Drive motors of different types and different power configurations,
Material also in explosion - proof design
The heating surface is normally made of stainless steel, (SUS 316L), honed to • The standard heat transfer tube material is carbon steel chrome-plated,316L
a very high finish on the inner surface.For special applications different types stainless steel, 2205 duplex stainless steel, pure nickel are optional
of chrome coatings are available for the heating surface. The scraping blades • Optional Shaft diameters(mm):160, 150, 140, 130, 120, 110, 100
are available in stainless steel and different types of plastic materials including • Optional the products flow from the center of the shaft
• Optional high torque SUS630 stainless steel transmission spline shaft
a metal detectable type. The blade material and configuration is selected based
• Optional High Pressure mechanical seal up to 8MPa (1160psi)
on the application. Gaskets and O-rings are made of Viton, nitrile or
• Optional Water tempered shaft
Teflon.Suitable material will be selected for each application. Single seals, • The standard type is horizontal installation, and vertical installation is
flushed (aseptic) seals are available, with material selection depending on the optional
application • Optional Eccentric shaft
Ftherm ® X18×180
1700
1290
Ftherm ® X16×180
Technical information
Maximum pressure
LxWxH dimension
surface length mm
Ftherm® Model
Maximum Shaft
surface area m2
Recommended
Heat exchange
Heat exchange
Blade quantity
speed RPM
power kW
space mm
mm
X18×220 . m2
1.24 10 to 40 2200 16 3350×680×1325 18.5 or 22 3 or 6 0~340
X18×200 1.13 m2 10 to 40 2000 16 3150×680×1325 18.5 or 22 3 or 6 0~340
X18×180 1.0 m2 10 to 40 1800 16 2950×680×1325 15 or 18.5 3 or 6 0~340