Professional Documents
Culture Documents
axis, find the angle B. x
60
2. If B = 600, what is the value of the
force T such that the resultant of
the forces is along x-axis? 45 N
3. For the forces to be in equilibrium,
what is the magnitude of the force T?
Ans. 22.850; 45N; 40.9N
Problem 02.
The 100N resultant of four forces together with three of the four
forces, determine
1. The fourth force
2. Horizontal component of 4th Force
3. Vertical component of 4th force
Y-axis
70N
R=100N
°
45°
60
X-axis
°
60
50
°
50N
120N
Problem 03.
The cylinders in the figure shown are piled
in a rectangular ditch as shown. Neglecting
friction. Radius of cylinders A, B and C are 4, 6
and 5 m.
1. What gives the reaction between A and B?
2. What gives the reaction between the wall
and B?
3. What gives the reaction between floor
and A?
Problem 04.
The force system shown consists
of the couple C and the four forces.
The resultant of this system is 500kN-
m counter clockwise couple.
1. What gives the value of P?
2. What gives the value of Q?
3. What gives the value of C?
Problem 05.
A rod is connected to a pin at A and a chord
at B as shown. It holds a cylindrical drum which
weighs 176 N. The drum has a diameter of 2 m.
1. What gives the force between the drum and
the rod?
2. What gives the force in the chord BC?
3. What gives the reaction at the pin at A?
Problem 06.
Consider a coplanar force system shown, compute
1. the resultant of the system,
2. the location of the resultant from left support, and
3. the angle the resultant with the horizontal
75kn 100kn
50kn-m
0.4
A B
Problem 07.
A 135N force is applied at B,
1. Compute the moment about x-axis at A,
2. Compute the moment about y-axis at A, and
3. Compute the moment about z-axis at A
Y-axis
A 8m X-axis
4.6m
Z-axis
3.8m
8
4
5
135kn
Ans. 7.87kN-m, -21.08kN-m, -42.12k/n-m
Problem 08.
A flat circular plate lies in the
horizontal (xz) plane and is supported
at the three circumferential points
shown. The weight of the plate is
1,000kN.
1. Which of the following gives the
reaction at A.
2. Which of the following gives the
reaction at B.
3. Which of the following gives the
reaction at C.
STATICS OF RIGID BODIES
Problem 10.
A crane is supporting a
2000 N crate through three
cables, AB, AC and AD. Note that
C is at the center of the outer
edge of the crate, D is 1.60 m.
from the corner of this edge and
A is directly above the center of
the crate.
1. Compute the force
transmitted by cable AB.
2. Compute the force
transmitted by cable AC.
3. Compute the force
transmitted by cable AD.
STATICS OF RIGID BODIES
Problem 11.
For the figure shown below,
1. Determine the tension in
cable AD
2. Determine the tension in
cable BD
3. Determine the tension in ca
le CD
Problem 13.
For the figure shown, determine
1. The reaction at C so that the reaction A and B are equal
2. Find the reaction at B
3. Find the value X
Problem 14.
STATICS OF RIGID BODIES
Problem 15.
Figure (1) shows a cable that carries the uniformly distributed load w0 =
80 N/m, where the distance is measured along the horizontal. If the cable
tension does not exceed 10 000 N
1. Determine the
shortest length of
the cable,
2. Determine the
tension in the cable
at support A,
3. Determine the
minimum tension in
the cable,
4. Determine the
corresponding
vertical distance H.
Ans. H=109.2 m, S=sA + sB = 117.0 + 163.1 = 280.1 m, Ta=8421.3N,
To=4542.4N
STATICS OF RIGID BODIES
Problem 17.
The three hinged arched is 20kn
subjected to the two 7.6m B
Problem 18.
A 120 kg man walks on a 4 m. plank resting on rough surfaces at A and B.
Given:
Coefficient of friction at A = 0.40
Coefficient of friction at B = 0.20
STATICS OF RIGID BODIES
Problem 20.
Figure shows two blocks subjected to a
force P that tends to raise block A. Friction
exists only as indicated in the figure.
1. Determine the force P,
2. Determine the reaction between the
floor and block B
3. Determine the reaction between the
blocks
Ans. P=109.28N, 203.96N, 138.56N