Professional Documents
Culture Documents
ADD PLATES: for slabs, walls( Sturctural), Industrial structures, Silos, and
anything nga naay area plates ang gamit.
ADD Supports
Objectives:
*Adding Supports
*Specifications
*Loading
Spec. ----
*Simply Supported Floor Beams - Use the Release Command - Support Page - Beam
-
*Offsets: Mmax and Mdesign
Objective:
*LOADINGS
DEAD LOAD:
1. SELF WEIGHT ( SA PLATE NAA NAY SELF WT.)
2. MEMBER LOAD - WALLS (CHB: 21.2 kN/ CU.M + PLASTER: 0.24KPA with 8mm each
face)
W =
3. FLUID LOAD W = (Wt of tank + (Unit wt.)(volume))/area of the floor
4. If wala pa na offset. Ibalik lang update ang self wt.
2.13kN/m(Roof Deck)
5.74kN/m(Roof Deck Stair Walls)
4.25 kN/m (1st Landing)
3.72 kN
6. ADD FLUID LOAD IN THE FORM OF PLATE LOAD DAPAT NAKA KPA ANG UNIT (GY)
* Parameters
* Click Seismic Definitions - UBC 1997 - Include Acciental Load - Leave CT
blank
*RWX and RWZ R Values Refer to NSCP 2015
*Soil Profie Type Sa Davao Type 5
*Add Self weight, Member Weight, and Element weights (using staad Editor)
* For Staad Editor Copy (Member load to element load) from the Dead Loads
* MEMBER LOAD TO MEMBER WEIGHT ELEMENT LOAD TO ELEMENT WEIGHT
* Erase GY -
*Add SL + X : Seismic Load - Factor 1 - Check Multiplying Factor for
Accidental Torsion Moment - Factor 0.005
*Edit at Staad Editor Copy UBC... Edit X to Z negative 1 to positive and etc.
*Add PERFORM ANALYSIS
CHANGE
*In every after the SL
*P-Delta - 5 Iterations
*RUN ANALYSIS check if no errors
LOAD COMBINATIONS:
1.) 1.4DL
2.) 1.2DL + 1.6LL
3.) 1.2DL + 0.5LL + 1.0SL
4.) 0.9DL + 1.0SL
SERVICE LOADS:
1.) DL
2.) DL+LL
3.) DL+0.75LL (Pwede na dili apilon)
4.) DL+0.714SL