Professional Documents
Culture Documents
4
APPENDIX
Page: 1 Issue: 4
Date: 1 September 1994
COMPLIANCE
The directives listed in this Appendix are mandatory for Malaysian registered aircraft. The reference number in
the left hand column of the tables should be quoted in aircraft records when certifying compliance with the
associated directive.
Page 1 Issue 4
Page 2 Issue 1
Page 3 Issue 2
Page 4 Issue 3
Page 5 Issue 1
Page 6 Issue 1
Page 7 Issue 3
Page 8 Issue 2
Page 9 Issue 2
NOTICE NO. 4
APPENDIX
Page: 2
Issue: 1
MACD 84/07 Allison 250-B17, C20, C28 N/A Inspection power turbine inner Inspection
series engines and outer shaft and associated requirements
components for corrosion at 900 apply to all
hours interval since last shafts
inspection. regardless of
CEB
compliance
standard
MCAD 84/08 Allison 250-C28 and – C30 CEB 72-2063 Introduction of roller bearing at the Operators
series engines CEB 72-3059 No 2 ½ location in lieu of the should note
existing ball bearing. that pre and
post
Compliance required at the next modification
overhaul of all compressor and compressor/
gearbox modules gearbox
modules are
not inter-
changeable
MCAD 86/11 Seats (except seats located Airworthiness Encapsulation of seat cushions
within the flight deck) in Notice No. 39 with a fire blocking layer.
aeroplanes and rotorcraft over
5700 kg. MTWA for which a FAR 25, Refer to Airworthiness Notice No.
Type Certificate was issued by Appendix F, 39 for compliance details.
any Contracting state on or after Part II at
st
1 January, 1958 and Amendment
certificated in the Transport 25-59
Category.
NOTICE NO. 4
APPENDIX
Page: 4
Issue: 3
MCAD 86/14 Type III and IV emergency exits Airworthiness Improvements to effectivity of
Rev.2 fitted to aeroplane over 5700 kg Notice No. 50 Type III and Type IV emergency
MWTA, certificated in the Issue 3 exits. Refer to Airworthiness
Transport Category to carry 20 Notice No. 50 for details and
or more passengers. compliance.
MCAD 86/15 Aircraft over 57000 kg MWTA Airworthiness Introduction of improved fire Previous
certificated in the Transport Notice No. 32 containment, detection and compliance
Category protection in aircraft cabins and with CAA
toilets. Airworthiness
Refer to Airworthiness Notice No. Notice No. 60
32 for requirements and and 83
compliance details satisfies this
requirement.
MCAD 86/16 Electric toilet flush motor Airworthiness Requirement for protection on Previous
systems installed in aircraft over Notice No.31 electric toilet flush motor systems. compliance
5700 kg MWTA Compliance required before issue with CAA
of a Certificate of Airworthiness. Airworthiness
Notice No. 57
satisfies this
requirement.
MCAD 86/17 Electrical Power supplies for Airworthiness Requirements to ensure that no Previous
aircraft radio system. Notice No. 25 likely single failure of a component compliance
will result in the loss of all radio with CAA
systems or both systems in the Airworthiness
case of duplicate installations. Notice No. 76
Compliance required before issue satisfies this
of a Certificate of Airworthiness. requirement.
MCAD 86/18 Emergency electrical power Airworthiness Requirements to ensure that bank Previous
supplies for artificial horizons. Notice No. 20 and pitch information are available compliance
Aircraft certified in the Transport following total failure of main with CAA
Category for the carriage of electrical system, for a minimum Airworthiness
more than 19 passengers and period of 30 minutes. Compliance Notice No.
aircraft over 15000 kg MWTA required before issue of a 81satisfies this
Certificate of Airworthiness. requirement.
NOTICE NO. 4
APPENDIX
Page: 5 Issue: 1
MACD 86/19 Electrical generation systems on Airworthiness Requirements for provision of Previous
aircraft below 5700 kg MTWA Notice No. 19 unmistakeable warning of loss of compliance
generated power and of sufficient with CAA
electrical energy to operate Airworthiness
essential services for a minimum Notice No. 82
period of 30 minutes following the satisfies this
power loss. Compliance required requirement.
before issue of a Certificate of
Airworthiness.
MCAD 86/20 Mainwheel tyres fitted to Boeing Airworthiness Aircraft types listed must be
747 and McDonnell Douglas DC Notice No. 15 equipped with high speed main
10 aircraft. wheels tyres (rated over 160 mph)
complying with the requirements
of TSO C26C or an equivalent
standard which is approved by the
DCA and which will preserve a
specified load reserve factor.
MCAD 86/21 Vertical speed indicators Airworthiness a) Aircraft which are subject of
Notice No. 32 an application for issue of a
Certificate of Airworthiness in
the Transport Category:
Vertical speed indicators must
be fitted with limit stops.
MCAD 86/22 Galley equipment including Airworthiness Refer to Airworthiness Notice No, Previous
catering trolleys Notice No.47 47 for details. Compliance compliance
required before issue of a with CAA
Certificate of Airworthiness Airworthiness
Notice No. 99
satisfies this
requirement.
MCAD 86/23 ADF equipment installed in Airworthiness Installation of digitally tuned ADF Previous
turbine engine aeroplanes and Notice No. 16 equipment issue of a Certificate of compliance
rotorcraft Airworthiness. Refer to with CAA
Airworthiness Notice No. 16 for Airworthiness
details. Notice No. 85
satisfies this
requirement.
NOTICE NO. 4
APPENDIX
Page 6 Issue: 1
MACD 86/24 Internal emergency lighting Airworthiness Provision of emergency lighting Previous
systems in aircraft certified for Notice No. 21 systems, to facilitate aircraft compliance
night flying, with seat capacity evacuation, which are with CAA
for more 19 passengers. independent of any acceleration Airworthiness
sensitive, battery master and Notice No.42
normal lighting switches. satisfies this
Required as a condition for the requirement.
issue of a Certificate of
Airworthiness.
MCAD 86/25 Containers used in aircraft for Airworthiness Refer to Airworthiness Notice No. Previous
the transportation of cargo, Notice No. 34 34 for details. Compliance compliance
including livestock. required with effect from issue with CAA
date of Notice Airworthiness
Notice No.92
satisfies this
requirement.
MCAD 86/26 Starter motor circuits – aircraft Airworthiness Introduction of modification to Previous
below 5700 kg MWTA. Notice No. 33 prevent the risk of fire associated compliance
with jammed starter relay with CAA
contacts. Refer to Notice for Airworthiness
details. Notice No.33
satisfies this
requirement.
MCAD 86/27 Variable pitch propellers – all Airworthiness Detailed requirements for Previous
aircraft. Notice No.37 inspection and overhaul of compliance
variable pitch propellers. Refer to with CAA
Notice for details. Airworthiness
Notice No. 75
satisfies this
requirement.
MCAD 86/28 Combustion heaters and their Airworthiness Detailed requirements for Previous
associated exhaust systems – Notice No. 41 inspection and test of combustion compliance
all aircraft. heaters. Refer to Notice for with CAA
details. Airworthiness
Notice No. 41
satisfies this
requirement.
MCAD 86/29 Ground Proximity Warning CAA Compliance required before issue System will be
System. Aircraft certificated in specification of a Certificate of Airworthiness assessed by
the Transport Category for the No. 14 DCA before
carriage of more than 30 acceptance
passengers an aircraft over
15000 kg MTWA
NOTICE NO. 4
APPENDIX
Page 7 Issue: 3
MCAD 88/30 Aeroplanes over 5700 kg MTWA Airworthiness Improved flammability test Previous
Rev. 1 and certificated in the Transport Notice No. 59 standards for cabin interior compliance
Category (Passenger) to carry 20 materials. Refer to with CAA
or more passengers. Airworthiness Notice no. 59 Airworthiness
for details and compliance Notice No. 61
satisfies this
requirement
MCAD 88/31 Aeroplanes over 5700 kg MTWA Airworthiness Inflation media for aircraft Previous
Notice No. 30 tyres. Refer to Airworthiness compliance
Notice no. 30 for details and with CAA
compliance Airworthiness
Notice No. 70
satisfies this
requirement
MCAD 88/33 Aeroplanes over 5700 kg MTWA Airworthiness Fire containment capability Previous
Rev. 1 and certificated in the Transport Notice No. 60 for class C and D cargo or compliance
Category baggage compartment. Refer with CAA
to Airworthiness Notice no. Airworthiness
60 for details and compliance Notice No. 80
satisfies this
requirement
MCAD 88/34 Beech 200 series aircraft LTO 001 Erroneous engine fire
indication
MCAD 88/35 All instrument and Flight Research LTO 002 Removal from service until
Inc altimeters Part No. IFR45-20M further notice
MCAD 88/36 British Aerospace 125 aircraft with LTO 003 Modification i.a.w. British
Garrett TFE 731-3 engines Aerospace SB 72-1-2844A
MCAD 88/37 Bell 206B and 206L helicopters LTO 004 Modification of Hydraulic
system switch
MCAD 88/38 Airbus A300 aircraft LTO 005 Fuel Crossfeed Valve – to Compliance
prevent failure of valve during with FAA AD
a single engine diversion on 80-21-03
ETOPS flight satisfies this
requirement
NOTICE NO. 4
APPENDIX
Page: 8 Issue: 2
MCAD 88/39 Twin engined aircraft with engine LTO 007 To preclude possibility of
over heat and fire detector system erroneous engine failure
information
MCAD 89/40 Sikorsky S61N Helicopters LTO 009 Removal from service –
Helical gears
MCAD 89/42 Piper PA-28 series aircraft fitted LTO 012 Placarding of the Curtiss fuel
with Curtiss fuel strainer drain strainer drain valve
valve
MCAD 90/43 Piper PA-38-112 aircraft LTO 013 Inspection of main landing
gear stub axle for cracks
MCAD 90/44 Pilatus PC-6 aircraft LTO 014 Inspection of lift strut
assembly
MCAD 90/46 Beech 200 aircraft LTO 016 Inspection of fuselage skin
under the wing fillet for
corrosion
MCAD 90/47 Sikorsky S61 Helicopters LTO 017 Tightening Torque Check of
nuts of T-bolts connecting
input drive shaft to main
gearbox flange
MCAD 90/48 Sikorsky S61 Helicopters LTO 018 Inspection of Main Rotor
Head Sleeve and Spindle
Assembly
MCAD 91/49 Aircraft below 5700 kg MTWA LTO 019 Electrical test on the stall
fitted with electrically operated warning horns
stall warning
MCAD 91/50 Boeing 737 aircraft fitted with Type LTO 020 Modification to clarify Compliance
III exit handles with integral operating procedures with UK CAA
moulded cover clamped to the Additional AD
operating handle 021-07-901
satisfies this
requirement
NOTICE NO. 4
APPENDIX
Page : 9 Issue: 2
MCAD 91/51 Aeroplanes over 5700 kg MTWA Airworthiness Minimum space for seated
certificated in Transport category Notice No. 61 passengers. Refer to
and configured to carry 20 or more Airworthiness Notice No. 61
passengers for details and compliance
MCAD 94/53 All F50 aircraft LTO 021. Burning at back of windshield
FOKKER SBF wiper switch panel.
50-30-012. Inspect/Modify
MCAD 94/54 PA18-150 SUPER CUB LTO 022 Failures of the lower
Piper SB 706B horizontal stabilizer brace
wire fuselage attachment tab.
Inspect/Modify.
MCAD 94/55 Bell 206 Helicopter/Allison 250 LTO 023. Loose or damaged
engines CAA UK AD connections on plumbing to
010-12-92 or from the Compressor, Gas
Producer, fuel Combustion
Unit or Power Turbine
Governor causing flame out.
Maintenance Instructions.
MCAD 94/56 Aerospatiale AS 355 Helicopters LTO 026 Tail rotor blade and pitch
DGAC AD change link failure.
CN84-045-022 Inspect/Report.