Professional Documents
Culture Documents
Com
www.SteamPoweredRadio.Com
Data Sheet JE-16-A
MICROPHONE
INPUT
TRANSFORMER
The JE-16-A is a 1 :2 turns ratio (150/ 600 ohm) microphone input
transformer for use with European type input circuits or the 990
operational amplifier. It handles levels to +8d8v Re: 0. 775v@ 20Hz
( 1% THO). Below saturation, the 20Hz TH D is less than 0.1 %. The
bandwidth is 170kHz with no overshoot independent of the amplifier
bandwidth. The JE-16-A has a multiple interleaved layer winding,
similar to the JE-115K-E, for low leakage inductance. This yields wide
bandwidth quite insensitive to load, low losses which affect noise in the
upper spectrum, and very high frequency low Q resonance. A series RC
network of 3600 ohms and 820pf should be connected across the
6200 ohm secondary load resistor for minimum transient distortion.
The series loss ratio referred to the secondary for 20kHz bandwidth
is 1.45 ohm / ohm. This results in the transformer related noise figure of
only 1.9dB. T he 1Ok Hz secondary source impedance is only 5% higher
than that at 1kH z, so the noise spectrum is very close to a pure resis-
tance. The 20kHz equivalent input noise is - 128.SdBv Re: O. 775v when
used with the 990 operational ampl ifier (0.8 nv/ rt Hz per xstr &
1.0 pa/rt Hz).
The input impedance is higher and f latter than the higher ratio types,
yielding good regulation of frequency response characteristics with
various source impedances.
JE- 16- A
2 uS AMPLIF IER
~:·
1!",0/600 VEL I
I I I
ORN
L - _I CN 820pl
BLK
WHT
R3 • R 1 fo, AVCL min • 2 !6d81
www.SteamPoweredRadio.Com
REGARD ING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A {certified calibration).
Left column is transformer with secondary termination network and right column includes a
2 microsecond ampli tier.
50µ S/ division
5µS/ division
1 µ$/ division
www.SteamPoweredRadio.Com
All curves were generated by a Hewlett-Packard
9815A/ 9862A programmable calculator/ p lotter.
All calcu lations were either derived from or verified
by actual measurements. Verified accuracies are on
the order of one pen-line width.
DISTORTION
.-
-I
□
-I
]I
r
.-
L
r
]I
lJ
::r
z□
fl
Q
-U1
-I
□
lJ
-I
z□
A
1J
l'1
lJ
.mt
• fl
l'1
z
-I
V
, BBiL--.L.--L--.L.-___.L-----11.---11.----1_---1_---1_ -1,..1....:..,_J,_.....L.;__"""""....:..... .u
-'-IIZI -3a -2IZI -ta B +ta +2B +3B
INPUT LEVEL <DBV RE . 77SV>
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
N
:Ill:
W
,t
•
:Ill:
(II Cit"' ca .o
:111::111:Jt:lll:Jt:111:
26111111
A - --++<
I:
J: ~ ...-:-f-1---t-r-i--t-'-'.+-t-+-+-'+rt-+-t-+---'-f--+-+-t-Hl-:+-t-:t-:+-'+-H--!-+-~----+-~~-+-,-+""-l...;+-~
□
V
21111!
azlZI 2K 221K
FREGIUENCY <HZ>
SECONDARYSOURCEIMPEDANCE
.." .." ."
A ..........~.:..... l-.......+t;-+
I:
a
V
t-,---H--::f:==¼:::#:!!4!:!;t-+1-rlrt'.'7±7;-r.:tii.tf.:tti7i:""17..i:17::ti:lirt;-;--~;-:t:;~;t;:;ttt:tii;:1r.;--t;"r-t1 121111
l lllllllZI
+:2
/\ l-r'-t---t-'Hr++-+::-H-H+i-i+-~+--i+.+-H--l-9++++-...+:-4.:.;.4:.::+:+++-lml4!++-l~~q..-1-11--H- :+ 44+1-1 +I
to j
Cl
V
~ =i=::l=:i:=i=...;.o+,~m~~b+H--H+t-+----:,~-+-H~ l-l=:!::±-l+---4;....:.±l RI
-I
-2
-3
1-
:J ,.__..........., - Lf
n.
1-
:J H-,-,-1-'-i-'-1-+--l-++--+-,!h+-H+.....-+-,+--1-"'-1-..+++..+-1-++.--------!-.:.:..+--l--i-,,..µ....i.;:..,j.:;..-j...j..,..._;~~4-:.i1--4-1~\I-I.-I-I-I -~
□
-6
w
> t+----+-:-~'l-'+++--t-+-+t+t~+i-+--t-+-H--'·+-l--+-+-++..,.....:.;-'-'-'-1.;..+:-+-i-+-1"-'1--,-1--Hi-+.;-:..,.+.~~~~~ -\l+l -7
l-
a: -a
.J
w
II ..._._.-1--"-_.....+--+--+'-+-l-+-++........~-i--1-'-l--l-l---l-l--++-----l......4-'--l-!;.i....;.~~,1----1--li-j....!......;,....i..;~.;.J..;.ci;:;J....l...._j.....,I...JJIJJ.I -9
- 11!1
PHASE RESPONSE
w
> h---l-brlF.:~++~1-HH+-"r-t-+-H-+-+-+-H-t+:-~~,-F+++t-t-+--!-H+-'--i-+-:.+'~-+l-+~++-1 :22'1!1
l-
a:
.J
w
ll'. t---,--+-,-n-i--+++-H-~f++-+-+++-+-,--+++-+++++--+-'-l--+-+-,-+-.-4-'-l--l-+-++-"-.c+-~-H-+l-'-F++-++'l :2~
TYPICAL PERFORMANCE
Voltage Gai n
5.6d8
Input Impedance
1500 ohms@ 1 kHz
1340 ohms@ 1OkHz
Secondary Source Impedance
830 ohms@ 1kHz
872 ohms@ 10kHz
Total H armonic Distortion (Below Sat uration)
0 . 10% maximum@ 20Hz
0 .06% maximum@ 30Hz
0.028% maximum@ 50Hz
0.003%@ 1 kHz
Input L evel @ 1% Saturation (dBv Re: 0 .775v) Mounti ng Holes
+8dB11 @ 20Hz Clearance for = 4 screw
+12dBv@30Hz Lead Holes
+ 17dBv@ 50Hz Use 0.35" hole 10 clea, 9romme1
Common-Mode Voltage (maximum)
> 200v peak
Common-Mode Rejection Ratio
> 85dB@ 1k Hz
> 65d8@ 10Khz,
Transformer Noise Figure•
1.9d8 Re; 13 4.9 o hms··
www.SteamPoweredRadio.Com
Data Sheet JE-13K7-A
MICROPHONE
INPUT
TRANSFORMER
The JE-13K7-A is a 1: 5 turns ratio ( 150/3750 ohm) microphone
input transformer for use with European type input circui ts. It handles
levels to +8dBv Re: 0. 775v @ 20Hz ( 1% T H O}. Below saturation, the
20Hz THO is less than 0.1 %. The bandwidth is 1OOkHz with no over·
shoot independent of the amplifier bandwidth. The JE-13K7-A has a
multiple in terleaved layer winding, similar to the JE-11 5K-E, for low
leakage inductance. This yields wide bandwidth quite insensitive to
load, low losses which affect noise in the upper spectrum, and very
high frequency low O resonance. A series RC network of 15K ohms and
180pf should be connected across the 39K ohm secondary load resistor
for minimum transient distortion.
The series loss ratio referred to the secondary for 20kHz bandwidth
is 1.55 ohm/ohm. This results in the transformer related noise figure
of only 2.3dB. The 1OkHz secondary source impedance is only 4.9%
higher than that at 1kHz, so the noise spectrum is very close to a pure
resistance. The 20kHz equivalent input noise is - 128.0dBv Re : 0. 775v
when used with the NE5534A or the 918 operational ampl ifier
(3.0 nv/rt Hz per xstr & 0.3 pa/rt Hz).
JE - 13K7 A
2uS AMPLIFIER
15013750 YEL I
ORN I
- _I
BLK
WHT
R3 • R I for AVCL mrn 2 l6d8)
www.SteamPoweredRadio.Com
REGARDING THE OSC ILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration).
Left column is transformer with secondary termination network and right column includes a
2 microsecond amplifier.
SOµS/division
SµS/division
1 µ$/division
www.SteamPoweredRadio.Com
A ll curves were generated by a Hewlett-Packard
9815A/ 9862A programmable calculator/ plotter.
All calculations were either derived from or verified
by actual measurements. Verified accuracies are on
the order of one pen-line width.
DISTORTION
i------:.-t=-t-i--r---t---------r---t~-::-t:::-:-t":-rt=:-rcc-t:t---.1-:i:r-l----t::::---:t----t ci
_ .......,,_--,~___,....,_........,~.......- +--+---h-c~t--,~t---f-h-+-I-Tl -1----il+--+t -i
. lJ
r
._,_--,,.......,.--,+o----i-...---i-<---+.......,..!-H--....;-~----++-----+~1--+'-f--+-+--+~-rl-~---1 I
Fl-~-;-"-a...,.+-'-'-i-'-+-i--e-+t--,--'-'-+'---'-,+----+-t-±-i~rt+-ii'+#-- t-f-....,.+-r--+:-,-++,-+'-i-1 lJ
.....,.......,_-,.+1_..,..,..,,.,.,.._..,..........,.,....._ __,,....,.__,...,.+_ _-1--+-t--+-t---+-r-+t-----i :u
:I
□
1-"-,--,...,,.......,.--,i-,-;--rl-+-1-;-----1--,+'--t-=....+-,-:cc-i-+-,,=t--rl- +--r-Hl'- r,-,-+_,...-;-_+1 z
l---=il--::::i-'-ii-:-'-::::d::-,-----:,l-~-..:::,-f--,J:=.,.cf=--,-l--±~'::::::!'=f::7-::::f:+--fa~ ::;,j A
11
~ - ~ -_,__........__._. (Tl
:u
~:::=~i::::t:1~~!::1::r:::t::::::J::;::t::d::r:~q:::t::::::::t=:::=+=::::+::::::::::t:::::::;:::;::::::;f:::::::~;::::;1 A
(Tl
......,.___,....,..,.+-l,.......,._,...___.,........_-,-+_-,-+_----+_----+_----+_-+,_-+--+-~---1 z
h-;--;--i-l-;+,..;-++-:-;,-;,:r~-;-r,-t-,--H--'-!-:,t;--,fi'c~t-'-'""!"'.""'.!-+-'--;-H-,-;-"H''---'-;-+!-H--+-H--t-.'H -i
V
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
i g,igg ii g 8 8 § § 8 §§;; " .., • • 0
Jlt Jlt ,t 11: i
r----...--,-.,.....,.-,--,--,-..--,-.,.......----,---,--.,..--,--....--r--,--,,~-----r-.....---r---,---r--r-r-r-,~2BRJIZI
~
..
~
. .. ..
~ ~ ~
t
-
A
l:
I i - -~ -l-l-'--1--+---+-H--+-+
D
V
18111111
l-
:J i--~-'-'--+--t-+-t-l-H--l-f-+-+-+---+---i-r---+-r-+---+-r'-+-+-iH-- --+---t--+--+-~--i--1-+-l<-1 BIZIIII
n.
z 6111111
21!1111
A .. ,- I
I '
I I
I-< I• . .. I ·~i- , .. ,-
I:
I
D
V -. - UE- 3J7+E .....
I l
,_
. ,_
"
--
-. 1112SIII
~S'"r'"-r··~·
w ~ ' ·~· _, ,-
V
z
ct
0
w
n.
~
L • 391<
I S:1:1
1::; . .~ - __ _j_.
....
.
'
-.l-.
--- ·,,
,,
1-
t
.... ·- -
, ..
7~
l:
.-- - ·-
C 1-JE'f > R
:c 'l
~ I ISK
181?;1
9HM
FjF -
I I
'
I
- Ei7S:IZI
~
i
w - ·- - ', ... .
I .,
-
L
" +
V
ll'.
:J
I I I
,_ I
'
I
i,,
.,
I i .,,,,,
/
~
D tI I i-- v
lfl 1,,-1/ ~R~NC :iF□ ~~E R □ NL y •· :--,-~
,, •·
>- - I t. I
I
I
1
.,..v
S::ZS:111
ll'.
ct
0
z
·~
I
~) I
~EF M N Rrr- 1, :IN NEl
1
· ·•· i..-- ~
1---'
,, I 1a:. ..
□
V "· •· I
w I•
h
Ii !' '
I• t· I I I""
1- "
♦I
__ ,_._.
lfl 1-:-- I•
,,
1
:1-i
,.
- , ..,. .. ~
I
1•
71'. PH ~/ )JV
I 375:lll
2li!I 2li!lla 2K 2 IZIK
FREGIUENCY < HZ>
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
+2
A l---f-+-4---H4-l--+-+-H~-H4--.+"--!--+++.-J--!--4.:..J...-1..~;__;+.~..ll-l_.;....i...:,...i...;~~ .._:..;..i~---i_;;+4-j......j.-1-l-~ + I
111
0 ~ ~ ~~-t-H-tt11--t--t--+-t--H+tt+---t--:-:+-+-,~-+=:!=i=c::::t:t---l-.j......._- t li?I
V
w
> l-----+--+-'-i-;...+-+-++-HH--l----+-i--+-+-4-4-HH---+----4-+-l-+4-:+-1---l-l---l,,4---l---l--~-!-+-1--1--~i-+"l-7
I--
er
_J -a
w
er t----+--+--r--t--,--+--+-+
-lli?I
•
2IZI 2li?IIZI 2K :i!IZIK 2IZIIZIK
FREGJUENCY < HZ >
PHASE RESPONSE
21
A
tn
w
w -s:ra
er
l!l
w
0
V
I li!llZI
w
lil
er
I I 5:1Z1
Q.
w
> 21!1l!J
I-
a:_J
w
er 2S:IZI
PHYSICAL CHARACTERISTICS
Package
Mu•metal can
Termi nati on
Wire leads
r - - - 1-5 / 16'' 7
Dimensions
r
1-5/16" cliarneter, 1-9/16" high
Mounti ng
2 holes, 0.7" center-to-center, sell-tappi ng screws or clamp
TYPICAL PERFORMANCE
Voltage Gain 1-9 / 16"
l_
13.6d8
I nput I mpedance
1580 ohms@ 1k H z
1160 ohms@ l0kH z
Secondary Source Impedance
5550 ohms@ 1 k H z
5820 ohms@ l 0kHz
T otal Harmonic Distortion (Below Saturation)
0.10% maximum@ 20H z
0 .06 % m aximum@ 30H z
0.028% maximum@ 50Hz Mounting Holes
0.006%@ lkHz Clearance fo, ;;,4 screw
Input Level @ 1% Saturation (dBv Re: 0 .775v) Lead Holes
+8d8 v@20H z Use 0.35" hole to clear grommel
+12dBv@30Hz
+1 7dBv@ 50Hz
Common-Mode Voltage (maxi mum)
> 200v peak
Common,Mode Rejection Ratio
> 85d8@ lkHz
> 65d8@ l0kH z
Transformer Noise F igure'
2.3d8 Re: 132.8 ohms ..
( INCLUDING 2 µ S AMPLIFIER)
F requency Respon.se (Re: lkHz)
0.1d8@ 20H z
- 0.25dB @ 20kHz.
(No resonance peak)
Bandwi dth
68kHz@ 3d8
Phase Response
- 32° @20kHz
Rise T ime
BµS (10%-90%) 1617 NORTH FUL LER AVENUE
Overshoot
HOLLYWOOD, CAL IFORNI A 90046
< 1%
PHONE (213) 876,0059
www.SteamPoweredRadio.Com
Data Sheet JE-115K-E
MICROPHONE
INPUT
The JE-115K-E is a microphone input transformer with extremely TRANSFORMER
low leakage inductance. The step response exhibi ts less than 1 % over-
shoot with the secondary loaded in 10 times its characteristic
impedance requiring no RC resonance damping network when used
with an amplifier which incorporates 2µS phase lead compensation in
its feedback circuit.
2µS AMPLIFIER
The response characteristic of the JE-115K-E is a specific under-
damped 2 pole low pass which, when combined with a 2µS single pole
low pass amplifier, results very close to a critically damped 3 pole. This
response shape defines zero transient distortion. The 2µ S figure is
determined from the Bode plot of an amplifier with a gain bandwidth
product of 10MHz operated at a closed loop gain of 100 (40d8). The
10MHz figure is determined from popular amplifier types used in audio
microphone preamplifiers. The closed loop gain is derived from the
usual application of a variable feedback gain control over a range ot
6-36d8. The 2µS figure determines a - 3d8 point at 80kHz to main-
tain a finite amount of feedback at all frequencies extending to the
frequency of unity gain (open l oop) for stability. The high frequency
bandwidth of the t ransformer is 140kHz and with the 80kHz amplifier,
the result is a 76kHz bandwidth without overshoot.
LOW FREQUENCY SATURATION
The rate of increase in distortion versus input level is specifically low;
it could be stated as 10d8 per decade THO. This results in a noticeably
more gradual overload characteristic. The maximum input level
capability at 20Hz is - ldBv (Re: 0. 775v) for 4 % THO (visable satura-
tion) and - 7dBv (Re: 0.775v) for 1% THO.
INPUT IMPEDANCE
The input impedance, with the secondary terminated in 150K ohms,
is 1400 ohms at mid-band frequencies, maintaining above 1000 ohms in
the range of 26Hz to 14kHz.
LOSSES AFFECTING NOISE
The series loss ratio referred to the secondary for 20kHz bandwidth
is 1.33 ohm / ohm. This results in the transformer related noise figure of
only 1.5dB. The 1Ok Hz secondary source impedance is only 2.1 %
higher than that at 1kHz, so the noise spectrum is very close to a pure
resistance. The 20kHz equivalent input noise is - 129. 1dBv Re: 0. 775v
when used with the NE5534A or the 918 operational amplifier
(3.0 nv/rt Hz per xstr & 0.3 pa/rt Hz).
PHASE SHIFT
The phase response at 20kHz is typically on the order of - 5° (the
2µS ampl ifier exhibits -1 4° @20kHz).
JE- 115K - E
2 uS AMPLIFIER
1501151( VEL I
----+-- ------------ ----- -;
I
- BLK
WHT
www.SteamPoweredRadio.Com
REGARDING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektroni x Model 4 53A (certified calibration).
Left column is transformer with secondary termination network and right column includes a
2 microsecond ampl ifier.
50µS/division
5µ $ / division
-
n n
,o:r.- -
I .. .. .. . . . ..
90·
I
.. ~--· ..
~
I IIJiil
,_ Ji
I
0.
-. . I. . . .. .
,,
. . .. ..
·.:
·.
I
a Ill
~
J I - -- - - -
...
.i
1 µ S/division
www.SteamPoweredRadio.Com
Al l curves were generated by a Hewlett-Packard
9815A/ 9862A programmab le calculator/ plotter.
All calculations were either derived from or verified
by actual measurements. Verified accuracies are on
the order of one pen-line width .
DISTORTION
J -·
-;
D
-;
ll
,I . r
••
I
ll
Al
~
D
z
-f'l
0
in
-;
D
Al
-;
D
z
A
1J
fT1
Al
. 1211
t'l
fT1
z
-;
V
;-t
r ........________.
• 121121,1~ -------'-'------_.__ _ __.__......__..___.____.______._____
-~121 -Y121 -3121 -2121 - 1121 121 +1121
I NP UT LEVEL <06V RE . 77~V>
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
l'l
A
I:
I
□
V 1--o-,;,..;...;..-'-+o~-1---l....+;;+,-,j,,+-,-f---J•-+-+--+--'-'-
w
zV .................-r+1-i-,..,++1"-+--+-t,,t-+--.+-t--t-,
a:
0 i--,.~~.-1-1++ 1211111
~ -r-...!..
I: l-,,-,!;..l.~-h--+.c,..1.q.+++-,,H+.-:+.:+:+-:--~+;+.;~~,~:i:El-:-r.,n---'l ii+:H-~,-'~~:-'t:±-t-+-l''"-+Ti,-f-11 -
._ -l~ •~ l '-..+i...--1•~
SECONDARYSOURCEIMPEDANCE
l'l
A H-++-4~~+-'--l'-'-l'-++-t-l--lc-+4-,+-;,.-',..,.-+,i--;.;-+-;-.+r-,+.-,-4,-,,t:-r+--+-"r.-+•+-+-:---"-~~--+.~c+.:-t.,+;,+-i-'r--Hc-,-H
I:
I i---+~ - .--1
□
V
w
V
z
II
0
w 1--,..,.+,---,+1 ~ - t---+--1--1--+
Q.
I: t-=-'-!-+~-l-'+'-'+--i~++-l...l.,,.fl'',+,-4!-1-,--,-,....~-i+.-,-~+-l;.,.i.-M""-,+-r,+,+"-!-;--,;.;o+-!-'-:+!+'',-"+-,.F;+,-J,8,-4~-+-,,IIH---t
w
V
[l'. 1--i-+-++;--;-+-f-1-;....i.f.;..+4'-f--'F-l++',-i-,-J,'"-f'-+--l---+--<~~+-l--;.+-.--- --H--~'-'++--+------+i--l"
~
□
111 t-i-:-±:-++±-:-:+:=~-::::r;-:+::1-,tm-H-+-+::-t<~-=-+-::+r.-!-!-!t-~:t-'-i~H-'-t--l!"t±+~-±+.:-~~-:::t,--::+.;tt-:,:!H-,+-+--11-H
2111
F"REGILJENCY <HZ >
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
:2
A 1---++y...c.+:4:++~ttH+~+-H-+~+4::+-+++.:-~----+-++++:-i..:++-H+--..:.+--+--4-,1-H....!+,-:+-t+H+
1-
:::J ...,..,..,..........."'f-t-+-....-t-1-+-
ll.
1-
:::J ~ 4-+.....+++-4--,1,..,,J.+.l.....-.r-¾--+-l..::..i--,.;+;+:-+-++-H--...;~~+--+--r-'"1f-++-H~...:..:+.:.!!f.-+-l-+IH-~-itti- S:
□
-6
w
> l---+-..µ:iG!--!::\---l--l!...f:~.!:....!L-.:~::::µJ~~:..j!.j...J..+,.:...:..:..:.j.!..:4~+,+.-1-'-1.+-1-+++:-:..:.:.µ.-+-..!;;.,j,-J-4-+++ ~
I-
[[ ......_.--+'->---t'-lll-"\-,-t-H HI
_j
w
[t i---.:.:+-.+.!:::...--!,--+!+~H-µ+.:.!..'.!.µ::.-i:--:..... ..:i-=~+--F=+-+~_..--1-=+++-4-+-i-:-H~-+:-.++-l.:..i...+-++t-++t
-lli!I
2li!I 21i!1121 2K
FREGIUENCY <HZ>
PHASE RESPONSE
Ill
w
> t---+----t--t--++-++-+-+-+-H-t---'+-4-H-+---+-'+-t-+-+-++"......-i.,.....,+-,-+-+4--+--,f,"+'t,--H+----+t=+-<-'-tt-'lt-H-f-'4;,f-rl-'\t,-H
I-
[[
_j
w
[t f---+--+J.,:-c!--!--+±:-+-I-I-H+-+-+-+-+-4+++-+++.--~~'-l--~+-4-'-+"-l--l-l+--+---t--l-l-H-++''-l'+-I--H2GI
TY PICAL PERFORMANCE
V oltage Gai n
19.7d8
Input Impedance
1350 ohms@ lkHz
1150 ohms @ 1Ok Hz
Secondary Source Impedance
19.6K ohms@ 1 kHz
19.9K o hms @ 10kHz
Total Harmonic D istorti on (Below Saturation)
0.31 % maximum @20H.z
0. 17% ma><lmum@ 3 0H z
0.082% ma><imum @ 50Hz Mounti ng Holes
0.01%@ l k Hz Clearance for 4 4 screw
I nput L evel @ 1% Saturat i on (dBv Re: 0. 775v) Lead Holes
- 7dBv@ 20Hz Use 0.35" ho le t o clear grommet
- 1.SdBv@ 30Hz
+5dBv@ 50Hz
Common-Mode Voltage (maximum)
> 200v peak
Common-Mode Rejection Rati o
> 85dB@ 1kHz
> 65dB @ 1Ok Hz
Transformer No ise F igure•
1.5dB Re: 133 ohms• •
(T RANSFORME R WITH SECONDARY TE RMINATION
ONLY)
Frequency Response (Re: 1kHz)
- 0.SdB @ 20Hz
+0.1 dB @ 20kHz
+0 .2d8 @ 55kHz (peak)
Bandwidth
140kHz@ - 3d8
Phase Response
- 5" @ 20kHz
Rise Time
2.5µS (10%-90%1
Overshoot
6.6%
www.SteamPoweredRadio.Com
Data Sheet JE-110K-C
MICROPHONE
INPUT
TRANSFORMER
The JE-11 OK-C is a wire lead type 150/ 1OK of earlier design
than the JE-115K-E. The winding is a less complex configura-
tion of interleaved layers exhibiting higher leakage inductance,
so a series RC network of 56K ohms and 62pf should be con-
nected across the 1OOK ohm secondar y load resistor for
minimum transient distortion. The resulting high frequency
performance of this t ype is close to the more complex wind-
ing but at lower cost. The total turns and core size are
similar to the JE -11 5K-E yielding similar low frequency
maximum level capability and distortion. The higher series
leakage inductance yields a 2.0dB noise figure compared t o
the 1.5d8 noise figure of the JE -115K-E.
JE- 1 lOK - C
2 uS AMPLIFIER
o---+¾
o• ____
I . . ,.___________________
150/l0K ORN
~ RL • 100K RN • 56K
I VEL I
L _ - _I
BLK
WHT
R 3 ~ R 1 lot AVCL rmn • 216dBI
www.SteamPoweredRadio.Com
REGARDING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration}.
Left column is transformer with secondary termination network and right column includes a
2 microsecond amplifier.
50µ$/ division
-~-- fj■■■
II ■■
••,••••••••
■■II■■■■■■■
II
~
IJ
10· • • • • • .. •••• •· · • · ••• •••• • · •· · · · · · •· · ••• ·
I
5µ $ / division
,a-
I ~
90· • .. . ... . . . . . . . . .. ~-- . ... . ..
~
~
~
.....
,:.;
10 • • • ~--·· ~--·· .. . . . . .. .. . ...
I
lj
1 µ $/ division
www.SteamPoweredRadio.Com
All curves were generated by a Hewlett-Packard
9815A/ 9862A programmable calculator/ plotter.
All calculations were either derived from or verified
by actual measurements. Verified accu racies are on
the order of one pen-line width.
DISTORTION
t ---!--,-!-.....++---++--t---H--,---,-,---i,--,--'-+-----r-- 1-----,----j'+--...,......,,_,......,.........,--+-~ I
I----H-'-r---t--:-e-t"-+,........,.,c+-=-c-+-----ir---'-'--c+--------'--+--'lc-.,....,.+--;-1~-,-+-'--7-i-..-'--i :n
:ti
1- - - t - - t - - t - - - . . . . . + - - - ~ - -........- . . _ ,_ ______, ----,..,-,c+-~ H""-t-H+t--1 :I
D
H--'-!--,+-.-,--!--,-'-'-H----,-+'-i---i--,-H+-,---..-+-o-,....,....;J ---,-+--- l -t-o--++-+'--+-...-+"-1 z
t:-:j!:~!=:r:::t-~-rf4----rr f~ r tt"nstm--,--1""
Q
~~t~§~§~~~i~=3==~§~t~~~3_,::1:=fJt;:-s~~~
t----t___,--t---.-H--...__,-t--+---...: :-t--+--/ '-+-----<-+1--+--;-j-:.t-----t---i--:--.-1 D
~
1----=:=---;i-;'='""-+-'--'-----'+-''--t---...a,,;--===-~ -+--/ -~-t--=----'---1ci--'--'+-:-+-+-..,........f :ti
"'--'t•~~~~~....;...-t---'~...;.a-+"'7-~➔~-f-h;-+,~--/-1 -;
D
z
A
t-----:,t--,,:=i-o::-=~--:-t=c--:---:-t-::----:-:--:::--+--s--+--t-:-~~~--1--- 1 1)
111
::r,
1:==ct===:t:::::::::::;::::=:::t:;::;:::::::t::::;r::t=+:1;::::t?:::::::1.t---tt-,,:-_....-....,_Jr.7.::: ~~-y- -..........-1 f"i
::==::t==:::t~=r1:=:~::::=t::::::i=t:::=w::::::::=:t::::::::::t:::=j=:=:r:==::;:::==i:==:r:=--1 ~
t-=-+t-;---t-'--+"'f-+~'--1-,--t----,-,+---:.+,...__.-'-1--i..,...-."'-l-'-'-,--+-...;.....;--,----t--,----+-'=-'-I -;
V
, 111111,1~__.---:-":=-........-~:------:::=---~=---~=--'--~=--------:-~
-S0 - Y0 -30 - 20 -10 0 +10 +20
I NPUT LEVEL <D~V RE.77SV>
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
N
i'
j_ .!!: I I
--,
I
...
I
r-c''
"
-j-,.-
- ~,,,
.,.,,,, -:• r
I ~
-
!
J:~ r.m
'I'
-i
., ..
:::. : ~
L
I c::
...
. .L U l 1
f ... ::.1
.n: :::
... ,. . ~
,... ,..r.,· J:
I
.""",...
- 1
.. ' . ••• l~••
:, ~- i . f+ --t
;;.
-~
~~~/- I 'l'~1
•:
;~n l
L'.: '
~
.... u·1- I ...
.,......a,- ~,::;· :..~
1
r a .. -·
""'· I i. ·- t·J'. .., .. -♦-· c-· ..,tr.'.":"".'"
,,,.,. .,
- r·~ rn
- !"
R,_
I
11.11 0 K ~ : IL~ r U:1
n -;: - -;·1
t l I
-
t
---:-
;
.4 ..,.... !'
-"'~ ~-
., ;:T- > rF I
,.
\idt,;:.,~f
r,,.
'" ;>,CJ ':
/\
N""'r 1f ;; I"-
ii: I-":•
;
/: "!
. f • '1: ·• -- 'f
,,. !
I=•' -;
l: ·•
..
,('
,,, l:;-;;J ,iJr:;- I
.~
'*
I l:t ~-
i!t ..
□ . Ir· - -}
j-~~ •ft :
l,l'
.. ..... -t HF
·:
IIB
t l
-· r+l
" In
~ ..
I •r.
.;. ...df\ '
jifj : .±..
~
~-
··~
.. .,
V
-~. '"
-:. .it il-- 1!-
w
V
"" L. ,.
~ tf ,;
:
"·. .:
..
" . l-#1~
., :
' j - ·• ~
. !· :;.:: ~.
o.l.t ,:
+
I ~
it :l
'I
p~ .
, . f' .
, .
T· ITT
::~:r-. ffii-"' 'i~
I EilZllll
·-
.
z '
a:
::r
,., J-_F
$~. ft- tl!a ~-1:.- if r "
1+
: ... _~•
ll!J :,4. ;:"'."' .. . .
: 'j•
.!± ..... .... ' if. s n ITT.. 't -~1,¥
0 1C ' ~ +-- ,1.,:,..t +· 1:1'
4--.-.
;· . :1 'i:· 1 c!---, ;-
.., .,..,
:;..i---::;..·· 1:-!. c;:• ;.;i . .!,.,,,
""
.,;j_ .. "ii:]
w ~~ ..;.-".T l i. p~ ttt- l 1d .t. ;· ~ .. :.~ .. - ~ :;;.
'l"j: t:. '\,. ... t·
l: -
a.. .J"'..,. l
~
.
1-C
.
- · .. ,,-
'
1
.. ,...
.
: ·r. ·- I .t!·
: :
·•··
...
..
,.
l
.·•
u.
•·
',
llill!llil
4
p: ~- ·• I --+ r .'
w
: '-'- "
" ,-,.,. :-1 r- '-:--·: " ••'
:.. + ·i I I-
: 'I (J-'H ""'
It l.t r-rt "" :
~n: 11:1 - .. :
·-r
smra
j-i': ,...,. -,~ :;.r-,f-'- :171.::-
C
1- . I: .; :!•.·
:J ct~ : r--,--,-, F .
.
-
. ..
T
..
: j:-,
,,· i: '-t ,~ i:"': ':i
l ,"
- .~
.: .:,i.. :'
a.. -~
;: :l t,· ,_ ., D'C: l\l ,~ ,,; • -it .. -r. ,I
.. - ,.~
Eil1lla
.. 1fn ~ ., -
,..;t"'Dli
;,
z ;
.,. ~ ~1:::1 iV I<' kll
: '-t .. -=-
.' 1
' F
T F"f; ft
' " : re
. •.;.
'
.. ,.
"
r
~
..1.
? ,,•-;7k'.J VF. Ir
I:
;
..
:
..
- · 1 , ~ , 1 Ul
rl r ,t
.. , ;
f
"',,,.· r-
I
'1li!lla
'I
I i f
2121 21210 2K 2121K
FREGJUENCY <HZ>
SECONDARYSOURCEIMPEDANCE
i 8 N
. w ..
/\
__,_
. ...-
+- -
r , I
ili:'i.=
,, ,_
I--• r- 1-·t:---
,,
I ·:-,
.. j-!·
1r
.
.. ,. i--: ~:
H'I;
IP
, . ,,
11',
·:,,
.] r:.,
·+
,.,.,, +M . +:::i ..
"
r! :,
'C: .,_
,J
' ...
..
! :
.
,:r,jfj
:
·f"'i:,I
I:
I 17 ~ L t .j;-1.I~ I' _ I\.. , ..
~.-: ~: i::r y -1:fl.f t.
HP ; l.
j
I-
□ r
.~I rr~
.. I 1::. :
V
w
-f
f....-
·1S:~I I 121 lc:: 1
I µ..:: ,_ ·--rr -~ , - --
J
'
·-,
'
.,
,... ,--
.~:1. ,...
.:r
. ~t-
l tn
, ...
1- .
!:..-lJ .,
,., r~ ·_1 ~11 I~: It!.:
.. - -- r
1·:1· ·l
a
,...
- -
.
11
~~
I
-1fr-:f-C J,...
-'•·
i..;... ~ r · -~ c . :
I
:
' • i -1"'-
I: 'i. I . . . ..... ~r
l"'IIUI
.:, ~ -IT j' ➔
. \
T I,..· !Ji, T"'i .,
- T
::l.
IBK
T
"
l:,1: ·•
.. .. .'1" ..,. •·
_ :r:·· ....
K I ;..•,:1
:r,:.. ..:
I. w :i "'."'., l~
/l R I: I ii:111
- 1,' .:f i. :"y \!~
..... -.
--, ·f
w ff_· .: t' . ·'ll:
_,.. t ,. : .
J•;ilf::~ ;;r. Ht ~ ,:J: l,•·· I;~.
_:r .. ..
. .:---
V -·-·
-· --.
' -ti· - .c;.;: - !L (.., ,i:1
er 1 ... ,, l:t1
· j ·;
I ' I', 1c: , 1
,iil J:: 1·~·:
. . fl' l"I 1,.- L:♦r
:
t . r.
"' ft :,
.. ,. ISK
TT u:J :· : .. ..
; j ..
:J
hB f·'
~
~
::. 1· ' 1:'. /
I'' . -
;1: -j-t-l:f
•· :
.,..,
'" ..
,;: 1
□ i_ 1r· ff ' :r, I~ t-:;;
,.
I
c-t F ~~ '.
I I
□
V I . ,.
~· 12K
w
Ln
--,-'-
Llf J1
.. :
-
:
:'
- ,·. I --t
;;; I I
1.
!
. .
:,_
'
C
-.·,-~- ., wl
l l it
'" ..,. I
1
' !'
-~
::,
'"'
+- ---r- J
I: "r'
'
i'
I"- ,..
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
~
/\
11]
Cl 0
V
_J
w
>
w
_J
2
I-
:J
a..
I-
:J
□
6
w
>
I-
rr
_J
w
ct
121
/\
lJl
w
w
[t
I.!]
w
Cl
V
w
lJl
rr
I
a..
w
>
I-
rr
_J
w
I [t
www.SteamPoweredRadio.Com
GENERAL CHARACT ERISTICS
Turns Ratio
1:8.16
Impedance Ratio
150/ 10K
Primary Source Impedance
150 ohms
Secondary L oad Resistor
l00K ohms
Seco ndary RC Network
RN = 56K o hms CN 2
6 2pr 0
Faraday Shield
Separate lead
Magnetic Sh1eld
30dB, separate case lead
Maximum Input l evel at 20Hz
- 1d Bv (Re: 0 .775v)
0
PHYSICAL CHARACTERISTICS
Package
Mu-metal ca11 ~ 0.7"
Term ination
Wire leads
D imensions
1· 1/ 8 " diameter , 1-1 / 16" high
M ounting r l -1/ 8"
2 ho les, 0 . 7" cente1 •to•centeI , se lf -tappi ng screws suppl,ed
T
TYPICAL PERFORMANCE
Voltage Gain
17.9dB
Input Impedance
1400 o hms @ 1 k Hz
1250 ohms @l 1Ok Hz
Secondary Source Impedance
13.SK o hms @ 1kHz ' ·[ _ _ _ _ _ _""1(111~
14 7K ohms @ 1Ok Hz
Total H armonic D istonion (Bel ow Saturation)
0 . 19% m axi mun, @ 20Hz
0 . 11% maximum @ 30Hz
0.048% maximum @ 50Hz
0 .008%@ l kHz
I nput level @ 1% Saturation (dBv Re: O. 775vl
4dBv @ 20Hz
0dBv @ 30H z
t6dBv @ S0Hz
Common-Mode Volt age \maxi mum)
> 200v peak
Common-Mode Rejection Ratio
> 85dB @ 1kHz
> 65dB @l 10kHz
Transformer Noise Figure •
2 .0dB Re: 134.9 ohms· ·
www.SteamPoweredRadio.Com
Data Sheet JE-110K-HPC
MICROPHONE
INPUT
TRANSFORMER
The JE-11 OK-HPC is a printed circuit type 150/ 1OK with a
winding similar to t he JE-115K-E. The multiple interleaved
layer winding exhibits very low leakage induct ance requiring
no series RC network across the 1OOK ohm secondary load
resistor when used with an amplifier incorporating 2µ S phase
lead compensation in the feedback circui t . Since the PC
bobbin contains a smaller stack of laminations than the wire
lead JE-115K-E. the JE -11 OK-HPC uses more total turns of
smaller wire. The result is higher maximum level capability at
low frequencies and the distortion is the lowest of all types
in this size (0.11 %@ 20Hz), but the higher series losses
increase the noise by 0.9dB, compared to the wire lead
version JE-115K-E.
The pin pattern is compatible with the JE -611 0 K-APC.
I
s I
_I
6
www.SteamPoweredRadio.Com
REGARD ING T H E OSCI LLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration).
Left column is transformer with secondary termination network and right column includes a
2 microsecond amplifier.
••••
.■■■■■■
■■■■■■ 50µ S/ division
5µ S/ division
1 µS/ division
www.SteamPoweredRadio.Com
All curves were generated by a Hewlett-Packard
9815A/ 9862A programmable calculator/ plotter.
A ll calculations were either derived from or verified
by actual measurements. Verified accuracies are on
the order of one pen-line width.
DISTORTION
. -
-f
□
-I
lJ
r
I
J]
ll
:I
□
z
f'I
l;;1
121 • I
Ill
-I
D
:u
-I
-
□
z
A
11
f'l
ll
.131
•• f'I
f'l
z
-I
V
. .., .,,.
--, I 1:
-' -,
-~ -·
I• 1...- Ic l I I·•
, ..
I:±=- H-,-L
·:
E-- I 101
I,
T HF (
' ,-- ·-=+- r
j •••
'
r:; ~
I
·--I -
I I,
.
Ii :; 7f t 1+£, -t "':": ~tr If
''ii
1·::1.
1,
-~ .1-:-1--
1·
j,r
..
i
;
....
L' '=" l il mi K .
1'!1,.
~-Ii
,,,.
1.l g
. fj •"-' '---- ,..
.,,t H
~
__
f ~t ,_
A :!. :I ,_ ,.;:I- 't _, .. ,__._! T" ,-1= :t 1.:-.: I:
!:
f
·t '; fi .,..t,;f iti~I·;f"
~ ~
L..t :
♦
I .. _..._ i '
.i
rr I
I
:f
-. _.._ 1,, I..!: Ir 1
□
V ·nn l
I"
~
•
·, +ff• , ,_!.
~
C
'=
..,,, Hr'-
~i-
=+· ;...
-, r.;;.
·-1-~ L,;-1-
j=¼
V
z
er -"'-.4.:. .i..i { iL 1:i. ·..
1-:; 7"11 '. ct_. 7 i.,..-
:,
.. ,... '
"
1'-
I ,1
-+
. '' -1-tt- h
,. ..
I
. . . •···
!I:
--. j. -·
::t
er
~;-
'
h-
: -l
,....
~ -
r-.::.... '
"
•ii'
l'-1111111
a :
w ~ F- w. .n'
n. :~.x
!:
'l
., u.: I hi 1-~ ,- ,_
=R1 fHi t•i
m,I+;;
-~n
,.
_.._leil c,
l°"l
I~
..m ':":~"'"I 'lf:l: F
1--,-Cf fi t "
+
.t! I'-, -
'
12111111
1111111111
- i
"} . 1:-itt
l.~ t'
'' ::Im ,~
.!:.!l:
j mJ ~rn IW~, i.....
1:,. 1:·• - -~ ,,,,,,,...:·. f
I•: f
cc
f ;..;.-h
t f- -
~
'C ,.;.
: 1,, '
1- H+ {H-l lk
.1 ,.. ' -I'll• .. tt t ,S I :
,:.-
..., •· I, I
l . 1 1 L: 7_,,P.' -·
80111
,;-r, '~-
,., '"
-·- •1 ~
I
.2 ,..,.
I
•·1~-1 Co
.'D p .. I;,,
, "
··'*
,- ·,, ' '-1111111
, - ,__J· ,i ,,;i'
~-
i: - ' I\,~ L.l~V ~ 1':J
·H T ij;"'" '"" I':
·- - .,
:
fflr
;.
.........
,. 1,,c., l.;.,i-,-
m 'l !: n
.ir
"
Id 'Ti"
..,, ''
1, . 1,1. 11'~. ·, ll:..
ii
:i!li!l111
~ ;- I
Ifi!!IF' . - 1~ !1' 11
~I
IL
' -I: '-· . i--
i ".
'-t llmlttt w :I
20 211l0 2K
' 211lK
FREGIUEN<:Y <HZ>
A
--,~-
. ~ t
I
'
"'" ' kt· 1
'T
I
,,., -
T
.
1 ..
µ.
I
l~ -,,.- i I
- ,T- 4-~ d- .. , ;i ~-
i",E! , ,.., . ..,~ i,,-1,..,
.,.., : ' ·I-
U
~i=i t~ f!i. ·H:: ·1 - 1r · · ,, ,_ 12
I ! J'.
! I ~ I~
I: ...,..
;r
I
- ,r- I ; . ) ,
1 l I ;,-7
·:: rt, :;·;;~,
- .41 1-,- I~',
· LI[._ 1 I ·t-0
I 11 , ·" ,.
'
□ l !• I· ;
:~ --~~l. " ,
4
I:
' ~-v- ,-1.-t - ,_I;_
I "
l II '
V - . r --·- i1"" '" 1- " · 1---
!if
t + '" ! 0
,,
I
...
w ··;:
. .S:'f/ ... 1,.: [.
I_
J I
V --I' I~
la ~ H
~ ,~ -~
! -- I.;:_1-:. ,_
r- L IC-i...t~rr 1::-
z . I ,.
f-11,_ 21111<
-, I ,- I i :,·
,_ ....
I
[[ S I ,_
a
w ,-
+::B >EV ~"" E.77S' ~ > t t 1:
,_ ...
n. I Ii
e-: . ..1 - -r- J f-"-1~
I: "1i r-,--:
j . .! 1-- f--,., "
I '
1....
I It ·'- ~ 1....
l t. I
'1-
~
.. ~'--- -·- li::--1 n, ;,.,,, ·1b dl'-J.Lt:f .. '
c·
1
~1x '"'- ,_ ,._ .... It
It 1:, t :i+rlt; lil
. .·1:
/
1,1, .
w ·-1~~ ,, .,.
I.le+ i!c-'- ~ K
''-~...-,tii:
-;: Ib '
' ,
V
It ,~ .
tklL j'. ' ' : j
~
. ''
~ ,:;i I, . ""
'
I !!!°
..
1/1
L:f-'
' '
16K
::I 1-k d · : :: ili' ,,,1_... t . + ·- i:.. L,,
.......:
,,
" -~ ,._
h:Ttt I--'-- -I--'- I"- 1-- ..... ··-'-
□ "'
~
- rt -
l l
U1 ..
-
t' J,
IT ,: .
" ' ;_
Iii
..; l:--,_,._
lei ,,,.
~;.l".
t"•r ·1: Ir';,
..... i ·I- ,_ ,._ . _..:;~ ~
ff! ·1: I;~ r r IL Hill
__
I
Ire
'-'
,__ -~ ....
c'
4.
....
,
Ci r: -t .- I
z '
rr .. f~ - .J ,... c...T ; .~ L.;;i~ ,._ 1-, r-
□ "" : (
t,-, ,-.i-,
,. I
'
~;.l w I" 1~ !:; lib
12K
V
'+ .4.. rf-r H ·1; ij;, ii~ :1 1"j: ..:I ':t Ti , •t i 1h1 1 li:!1, fill
~
U1
.t 1 '1 '
I" ' '
T l. In
FREGlUEN<:Y <HZ>
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
A r---t-r-t-'rT-H-"Ti'H-H+-:-:--:-;+.-:'-:trl-::-1-:ri:+-f'++-t+t-'-~---..-f-t-++:+-i~H-!+..-:-f---flJH!--,Jd::,Y---l++r-l,-l-l+I
1£1
e~=t=::;::::!==;;l:=t++t+Ht- t-H+m+::+++tt-7--t-,--i-M--i-R=l~:3-..-Jttif.f -- -,V--H
-:a
-1121
PHASE RESPONSE
121
A
Ln
w
w -~
a:
l!]
w+
0
V
10111
w
Ln
er
I I~
a.
w
>
~
er
.J
w I.
er :as:121
www.SteamPoweredRadio.Com
GENERAL CH ARACT ERISTICS
Tulns Ratio
1 :8.16
I mpedance Ratio Part No. Printed On Case
150/ l0K Bet ween Pins 4 & 5
Primary Source Impedance
150 o hms
Secondary Load Resistor
100K ohms
Secondary RC Network
None required . 4 se
Faraday Shield __L_ eJ 6 •
Separate p in 0 ,15..
Magnetic Shield
-r • 2 1e
30dB, separate case pin
Maximum I nput Level at 20H z
- l dBv (Re: 0 .775vl
(Hole Req'd 0 .040")
• 1 s•
PHYSICAL CHARACTER ISTICS
Package
Mu•metal can
T ermination
PC p,ns r - - 1· 1/ 8 "
Dimensions
1-1/ 8" diameter, 1-1/ 16'' high
TYPICAL PERFORMANCE
Vol tage Gain
17 .8dB
T
1 · 1116"
l ....._____.
Input Impedance
1400 o hms@ lkHz
1300 o hms @ 10kHz
Secondary Source I mpedance
15.2K ohms @ l kHz
16. 1 K ohms@ 10k H z
T otal Harmonic Distortion (Below Saturation)
0 . 11 % maximum@ 20Hz
0.06% maximum@ 30Hz
0 .025% maximum @ 50Hz
0.0042%@ 1 k Hz
I nput Level@ 1% Saturation (dBv Re: 0 .775v)
- 4 dB v @20Hz
1-0.5dBv @ 30Hz
+6dBv @ 50Hz
Common-Mode Voltage (maximum)
> 200v peak
Common-Mode R ejection R at io
> 85dB @ 1 kHz
> 65dB @ 10kHz
T ransformer Noise Figure•
2 .4dB Re: 134.5 o hms··
www.SteamPoweredRadio.Com
Data Sheet JE-61101<-APC
MICROPHONE
INPUT
TRANSFORMER
The JE -611 OK -APC is a printed circuit type 600/ 150- 1OK
of earlier design than the JE -11 OK -HPC. The winding is a less
complex configuration of interleaved layers exhibiting higher
leakage inductance, so a series RC network of 27 K ohms and
110pf shou ld be connected across the 100K ohm secondary
load resistor for minimum transient dist ortion . The resulting
high frequency performance of this type is close to the more
complex winding but at lower cost. Also the total turns is
lower than the JE -110K-HPC. This means t he low frequency
maximum level capability is less and the distortion is higher,
but the lower series losses yield the same 1.5dB noise figure
as the wire lead version JE -115K-E.
The pin pattern is compatible with the JE -110K-HPC.
JE 61 10K - APC
2 uS AMPLI FIER
600/150- 10K 5
I
s I
_J
6
www.SteamPoweredRadio.Com
REGARDING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration).
l eft column is transformer with secondary termination network and right column includes a
2 microsecond amplifier.
50µS/ division
5µS/ division
1 µ S/ division
www.SteamPoweredRadio.Com
All curves were generated by a Hewlett-Packard
981 5A/ 9862A programmable calculator/ plotter.
A ll calcu lations were either derived from or verified
by act ual measu rements. Verified accuracies are on
the order of one pen-line width.
DISTORTION
-I
□
-I
:n
r
:r
:n
:ti
:t
z□
l"t
0
Ill. I
lll
-I
□
ll
-i
-
z□
A
11
l"'1
ll
- l"i
111
z
-i
V
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
N
"
!;I . ;: ." "".. .""
"
~ .; ~
"
I .I
- . - 4
-~,·· 7
.,.._; i - , . ·::-t-
;
:,1
.. ;f ... :mm
'
..,I ,..
,1 ···f
2121 2121121 2K 2IZIK
FREulUENCY <HZ >
+ ~-- -- -·....-----' .
1, t
Jit ., ,.,,.. -I :!
A r --,, "r,-,f f-r., - :-r,
I t
'
J. .:.. C"
.. ~.
~
l ·,,!,
l:
I ,. -t,._ 1 L Ei 6 r- t~ =-j: IFr:.-
I
\; ti1' Lh ,r
:. ....; ,:l ~
-;i
1:fE 1m riFi l:li' E
'i
,~
~
w l f l i .~
·- □ H"II
!·
i-"
I•'
r~ i'! ..
-·1~ ;:,'
...- p; ~l'.i ,!l:. ,...
V
z s = __.I S:121 ,- f 1 ...
'"" .. I: - t 1,. -:1: r; I
2121K
I!
Cl
w
n. ~
r _El. =
I
-:;; I >B v' < ~E. 77SV> t
I ~H L: I
IL
i, !r " :J
."L
T
f ;I
' ._,.,. .,...t: ~--
;,f - J-f1&,
,..
• I
;•
-r h
• I
•·.P.:·
,j;,;
1 1,! ·-
.. t'l: ..-~ ·"'
l: + ,,~
.. J..
,.... c-r-
,-
,.., -- C
!
i!: .. IC
rt·· ~- . ,.
f .. : .f I" - i, ,,.
.It T :c,1,:,1
- " ,/ .
-·
~ 1: .n
j '"
.. ,. . .,.It,
~
. ! ~i
H-,- •
.... . H / i:-· r t== ...... I i;•p1 K " -'-\:;
r:+
..
' 1I
. -+ .;: '1, '.!.
.;.t·: -. I- i'' :it
'
- ""'
1-
.
w l !7:. :Jr :i ..'r 1fi'·-·
;.i[l
u
f l, .:I -~
... I"" '- I'•·,~E. . ' 27 -Ki i""i;.: ·•
V -1-'~
ct -l ,;-~, N i-,:- ' . :!t c,.. ..f +h:i: fii . ti . .. •·'+ ,, ·n· :-:r'
:J :l-J.c1.;~w '
LL~LJ~ .. ~
.. . -P ....
, "· :.c 16K
..... b.. ·'"- ......,_
lc'."1 :::;. ~
: 'i ft' .
□
U1 'i 4:t "Ji; l1ii r~Bf: ·It
· ;:
N
,.
___ I
'H•~.
..
• f ·,.:.
; ..
l!:'i:!, h' ! ,.,. t
·~
i ;-, ::-•! tr~ .lt ;
. ' I
.. j
:,·
>-
n 1-n~ ·:. ,,. r.t ::: -~ ,;i• l'~t. 11 l 11:: I ~
"
: -,. ~-n rr. 1,,, . ; I/
ct
I!
Jhi:ii .;'
,,.J 1:H Ji+l!L -!:..
. t-l [...:-:;: H, j,' '1f!:11 J" lt
:...
11;
0
,. ; _
~ t- 4.~1
.• !
,4: . ,,·.·;;r f• . '"'" .,:;;;:c ~4it .!ll:!. t:.J ::;!
.;_.
~ ...,
IU \· • • 1· .,
Cl • 1. . , '". ;If ,1·:1' A "
z I
- '"'-· ·1 i----
. t
I•. ,;;;
,,.
□
V
w
I
j IL -
'
~ . .
I•
-· - ..... . ;
:
;,e
- ,_ - - - C
'-' ,, :.; _;_ ~":::,_ -
12K
U1
C.
I --- :.;.. ......... - ' -:.;..~ --t-· I
.. I l:TI
J -:.;..
+2
A l----f-+-+-i~t4-!+44..J-+f-L!..!..+~-l-~l-i-4~::.J.:++Hf..-!--;+-.:.;.+-,..:+-,+.++4-+-!+-..:.+--+;;+:;~~_._,;;-1+i-;+-1-l + I
111
eL::t:+=ttt=t=mn==r=t-rtmiHtt1t-rrmmtrrm:::i- Ill
_J
w
>
w
_J
- 2
-6
w
>
1-
----+-1--.
rr .,._,_,
. . . . --1-
-7
_J -B
w I
II t---+-~t-+-rl-+t---H·-H--~-+·±-t~-+-t:__t++l -~4-µL;.1...,1..+..-+-4--1-i-~~;.:..:+:~~>-+l,- l-l--lM - 9
-1111
PHASE RESPONSE
A
lfl
w
w
It
l!I
w
0
v
w
lfl
a:
:r
a..
w
>
I-
rr ....
...I
w
II 2~
www.SteamPoweredRadio.Com
GENERAL CHARACTERISTICS
Turns Rati o
2/1:8.16
Impedance Rat io Part No. Printed On Case
600/ 150: l0K Between Pins 4 & 5
Pri mary Source Impedance
150 ohms (paral lel pr,ma, 1es)
Secondary Load Resistor
I00K ohms
Secondary RC Network
RN ~ 27K ohms CN = 110pf
Faraday Shield
Separate pin
M agnetic Shield
......L
0 . 15"
.3
.
•2
4 se
se
1e
30dB, separate case pin
Maximum Input Level at 20Hz
-r • 1 s•
(Hole Req' d 0 .040")
- 6dBv (Re: 0 .775v)
PHYSICAL CHARACTERISTICS
Package
Mu-metal can
Term i nation
PC pins
Dime nsions r - - 1-1/8 " - - j
r
1-1/8" diameter, 1-1 / 16 " h igh
L~
1240 ohms@ 1kHz
920 ohms@ 1Ok Hz
Secondary Source I mpedance
12.3K ohms@ 1 kHz
13K ohms@ l0kHz I I
T o tal H armonic Dis1ortion (Bel ow Saturation)
0.26% maximum @ 20Hz
0.14% maximum @ 30Hz
0 .0 6 5% maxi mum@ 50Hz
0.G13% @1kHz
Input Level @ 1% Saturati on (dBv Re: 0 .775v)
l0dBv@ 20Hz
-4.SdBv@ 30Hz
+ ldBv @ S0Hz
Common-Mode Vol tage (mai<imuml
> 200v peak
Common-Mode Rejecti on Rat i o
> 85dB@ I k H z
> 65dB @ 1OkHz
Transformer Noise F igure•
1.SdB Re: 129.5 ohms ' •
www.SteamPoweredRadio.Com
Data Sheet JE-110K-F
MICROPHONE
INPUT
TRANSFORMER
The JE-110K-F is a very miniature printed circuit board
type 150/ 1OK. The size is 0. 73" square by 1.1" high with
8 PC pins and a mu-metal case. The package is a unique
Reichenbach design which maximizes core area for package
volume. This yields very good performance including high
level capability for its size. However, the additional hand
craftsmanship required for the small size, increases the cost
of the JE -110K-F above his bigger brothers. ......
The pin pattern is unique, necessitated by the space
occupied by the core.
..,~
I
[J
JE- 110K- F
2 uS AMPLIFIER
5
I
I RL 1001(
s I
_I
7
www.SteamPoweredRadio.Com
REGARD ING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 4 53A (certified cal ibration).
Left column is t ransformer w ith secondary terminati on network and right column includes a
2 microsecond amplifier.
SOµS /division
1 µ$/division
www.SteamPoweredRadio.Com
All curves were generated by a Hewlett-Packard
9815A/ 9862A programmable calcu lator/ plotter.
All calculations were either derived from or verified
by actual measurements. Verified accuracies are on
the order of one pen-line width.
DISTORTION
•-
,-
-i
□
-i
:n
r
:r
:n
;I]
3:
z□
T
('i
0
Lfl
-i
□
;I]
-i
D
z
A
11
fTl
;I]
('i
fTl
z
-i
V
- . 111111,1
-S:121
t--
-Y121
t
-3121 -1121 121 +1121 +:.:1121
INPUT <oe;v RE. 77'5.V >
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
,/'\
I:
I 1---;---l----4----'l-+--l-<.l
□
v l---:-f--+-+±:+.::'l-::+-i-:,-H::-'f-'-H-.::...;:--i'-!-'~-i--;.;.1.r-H-+++-+-+-H+-i-.:...._;___,.+::---=t=~::::.+-+-H+.-H:-+-,~ 1sam
W 1.-•....,;..=-;..1
V 1'-IIIIIZI
z ·~...;.,...;~-,
a: ~~:)!;j
O t -.........;.:r-=''-'-+'-9-,--+-,-"-l-:.l,,,-F-t-+-+-++-::c-+~~+-+-'l'-+-++-+-+-'f++--'-+--'--+.:..+~ :;;F±-,++-c+--lc-,:!!-,,l-ll2'IIIZI
w
[l
I:1---...---l-~ -4"..!-µ...,!-1-+-l-+'-l-~-=-+---=-~+-".J.-.:.l..!:J.!:::c...J.-.:......l--'+"-I-I-.J-!.-_:....:+-".!e!.I--J..:....l;~-4-.p.J..-1--+-l...lj;.;4--I IRIBRI
2111K
FREGJUENCY <HZ>
SECONDARYSOURCEIMPEDANCE
8 .." w
"
I ,__
- l ·- l . I .·'-' .__~ r'
1 ii < ·~ 1/, ~ .I 1:r
,_, r ·•· . .• i" ; A I
~H -~tr
,· ,:.
- t. f i
; .:, 'I
I:
I
t -
1
l E 11-0~r F
I
-~11
T
.~~
1 :1 ;;I
H
j:
l,!i
I :¥}
~ '
4>--
' f£'"i . ·•:i .. " --:~i--
!- ...,.
~I
+
'
..
□
. ~S:~/ 10 .J '
·•I,:
·- .. .....J U;c. ;t ,;; r;,·
r-:'- .
- ·;
't'' .. .. '- le. ~Ii' -
.. 1.
--, ~C- "'-•··
V
I ; ' [, ,, .,,···:r· ~t T:
' ._:_h 1-r- ,:J
w
V
z isl~ I '!o.121 t at- M
~· t
t» LJ_~
I j I •I
,_IJJ_ I, , 1." 1c.
..
t
•I ·-• .
ti-
i l
2121K
1 -,_ •...
r--- .-..; I
a: Efr; = '--+ ll 9E. 77SY > I It
·~'--
'
~-: ..1,
0 I! n.
1
: <
w
[l
I:
I
.,._ rt I---,-
-r
"'abl5 F-' h ~ ,~ i t"Tl b
-
,- t,11 v . t: ii;, ht
H i..-.!. I!:. •'
I: 1 i-;c n:r ~ Ii
.-· .
Ir .IC;
I
I I ·b . - IBK
t j;
·1,. 7 ~... L; l-Jc : 1 112 ~----- K-+ ~,..,.
r :! lrrt . .. ·' t;:t· [ '-"C·
r:;
,.,
·H ,,,._
I,
'--1 .... -''Li '- ~
1
1
,a-
"' l(fl. :r: ;rt! : .
'
; I
w - . ::.1 -
fl. - ~
.. _ I
i.. I :'i1- .I ;
:i+l: ;lo
. .. .. - .,_
r: " 7' I:-:.>-
V
ll'. f .fi j;
i- :,; 'IE Cf-- " I
:::I::,- 1"-
...
.~
··•·
. •"" HI - ·:, ... •, : _l I•·
16K
:::J 11
~ HI=: L 111 .. .. '(
- 11211 ~~eF_ ... ':r .. ·t :
::: V· ,,
-, li-· ti,,r,, ,,. ~-~ IT I"""
·~-
-- : _!;,
□ - ~
" II
..;
m . ,~
~:=-:- .... ,
I
Ii
-,-. ~ i'- :I
'
-.:k-
;
"
>-
ll'. ~
-r- 8
""·;r' :··; =" 71- -·- -,- I
~
...!
-
u. - ~ t• f, i.:. I...: ~fr ~.,,.
i..- "'
It ~ .: •: !•~Ir!"
. I,
-
1]:I.
-
: . . ..
Cl _,,. l I '"
Tl !
z . ~
~
p-- , _·r i'A + ··'':-t
□ 12 - i--,--
.,
I: -- •. ' 12K
.....-
IJ·.~'., 1-11 ~ "•
V ·: it! le a Ir::'>·- ,, ;: !'= ;f'ti
h- rrr liHJ IWo !,J: •!!. ••f1. .r:, ·:- .. I-,.: .. i:;,1- ,,.
w ilr: . ....
!, II
J ....
,p t!JI, . . -l
i .,
m
·~ H~ ,ff•-•
Fe- ·; L
:c. ·" ,_.... ~I:,_ t rrI: IJ IJ,'I:" I~ .I.
..,,
lh'1 ... "'" "T
~ 11 l ~,
i I I
2111 2121121 2K 2l1lK
FREGJUENCY <HZ>
www.SteamPoweredRadio.Com
N - ISi - N f'1 r L1 ui r-- mm~ }/_ I 1~ ISi ~I ~ ~ ISi 111 }I_
: tt '.kitiJ--#tt?GfCJr6
• + + I I I I I I I I I I ISi + - - N N ISi
~l:-- L<~♦! ➔ / i i !2
200
200KI I ! l / l rt l, ·: ,~
...
""'" I r-- f_,_ ~ l =t= ~ ~
j
I . -..
90K
70K
&OK
:: -t=--
~;~. .-t
lOK ~ +
~f '
t- ., ,
t ·- : J-" .: ---- i . ; I
;rrr.-•- I ...30K
r .. I' --
t
f
t
.......... •-• !
1 .I,_ ,....
.__ .... t 1" l
.......
..
• t-
I t • , i -• ~
· .' • - ' • ·•• h ) ; • }I_
20K _ , _ · • . . + - _......
-_-_
...
..._-- " ISi I I 20K
' • . • N
w
~
=~ ·:!::·· ,..,., __ .
!OK ·H • l i· '.' •
...
• ! ; ' ·, . . ' 10K
~W •••• ·t
1-•1-t-H -- t'"+t,1 •t·-t-~ ,i H:.1 enw :~
~ tf;
en
7K
SK
r--rr~-t.
•.
a_· 1
-·-1-·
...;
• ; i
·1-----•4:~--l--'-- .l~~-r~~
l....,;,..;.!--=-ft--"""':: '"' ~!.:-'!'f-7"""...
. ~ +- .... ·• 1
. . . . .· . ~ . ;_ ~
¼ f-.z
'i •
1"
.
~~ t~-. . ~ • A
N
z
O
7K
SK -
t--,--,.-+IH1-
6" !----'--;-f.
. ~-
. .,..;!4---.'-~--4-...:;_....µ~~
,H,-;-
'. .. t. !. .
_,+-'-'
, ..., ' ·c.....:..-i---:-~
~ :.Li.r,
.
.. µ ...... ,~
, - l _- ' - .- , '--e.--i-;l:_.~....:.. , __:
• ..;_..:..
· :_lt _~--~-4-~--:-
, .L...!.--'-'-
_I A
N
· . , !· , - =ri . I~ .. _ 1 I C:. •• .L -, L . _ i: _ L . . 1 ' · . ,_ Hr= ~ .. t.~ 1~- ,. I
-,1, Lf ·t •. lHi<'i 1' ·::: '/'Hi[;
, • : - T.
a: " ,.,, ., ~ "·T .. ;.• ,!.' t.·. ! ,1,1" : ··t ' V (/) - :1 Httt' . V
,- . ·! ·
... '•
·,., A
~f--, ...
. ,L.
I
- :.•-•
N
W
:J
! : . I
•.
t .
-
It! }-
_
, B en _1
I
' I·
!, . •
;T
a' .
i' ··. : -.... .
1,1 r
. []
,,
'·
! -
_
B
.Jj\ l ---~,
1K I 1K h 1.
t°" t"'° t~ -· ' _-t~t . n. , "f'- W <t :+~ __ f ~t >T 7" d ~- ~ _· · ~ .,~
~ '. n_ r--- -z
:J -+ft
. -~-~;..
t W
~r~ +r-- ~
+ ,...r...,
:::, 900 l • -:- + 900 J
:r:
P
Z [r- -- ' £r 800
ll - • lJ'.
-□ w □ iw
800 • , ' I I ,
..__ · l :
+-' . .
0
W : -t • ~ · · • I':] u. ::C 100
:-1 i L r f- fr~ 1e1 T, - ' , L.
a: -1--;-- bl -~.: ~ If lii: ~ ..,. CL
~=-~x rH·· ;,-
500 -'-'--r'- ·. - · :- ~;
U. •oo ~I l - 11 11 v ~
w ...
~l . ..... ;· : i-.!-
r-___:, , -
1
300 ..... .,._ . - • ·- . ........ 300
> l n. .
. . ; • .c ~ • I _!- . !- l:il ~ ~ . ISi
200
www.SteamPoweredRadio.Com
'El •4t~~ti. I\ -J ", ]♦-'=!?- ~-] - !ti I I'~ !ft: g-=! I I ':
70
20
••
-
-~ · ~
=1· :_ IH;. - --tt
1-
I\\ '
r -~-If:. ~_,_ I -- -- .s~--.- .
I
. - . - r..1~~
11 - if.
. . • •
..
.
w_ l!I. . : :~
. ··i.
• .
·1N .PT · I
-t~-- s
..
] ;- ,JT J If I t l 1t 1t ti IISI
TYPICAL PERFORMANCE
Voltage Gain
17.9dB
T
1. 1"
Input Impedance
1450 ohms @ lkHz
910 ohms@ 1 OkHz
Secondary Source Impedance
I4.5K ohms @ 1 kHz
15.3K ohms@ 1OkHz
Total Harmonic Distortion (Below Saturation!
l~
0 .2% maKimum@ 20Hz
0.11 % maximum @ 30Hz
0 .05% max imum @ 50Hz
0 .007% @1 kHz
Input L evel@ 1% Saturation (dBv Re: 0.775vl
- 11dBv @ 20Hz
- 4.5dBv @ 30Hz
+3.0dBv@ SOHz
Common -Mode Voltage (maximum)
> 200v peak
Common -Mode. Rejection Ratio
> 7 5dB @ 1kHz
> 55dB @ l OkHz
Transformer Noise Figure•
2.3dB Re : 128.6 ohms..
www.SteamPoweredRadio.Com
www.SteamPoweredRadio.Com
Data Sheet JE-11P-9
LINE INPUT
TRANSFORMER
•
network of 5600 ohms and 1500pF
is required. For other loads such as
input circuits with shunt capacitance,
our computer can derive optimum
RC networ k values to minimize
transient distortion and maximize
bandwidth and generate revised
response and impedance resul ts.
The standard package has wire
leads. Octal plug versions are
available for all popular pin con·
nections with or without the RC
net work built-in.
,- - - - - - - - - - -1n- - -
I
JE-11P-9
- -----
I RED _ _ _ _ _Y
_L'-
W- - - ~ - - - - - - - TO AMPLIFIER
I INPUT
I
I
I
I BRN ORG
I BLK
I
I
---------
WHT
www.SteamPoweredRadio.Com
REGARDING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration).
50µS/division
5µS/divisi on
1µS/division
www.SteamPoweredRadio.Com
The response and impedance curves were generated by a Hewlett/ Packard System 45
Desktop Computer and a 9872A Plotter. The curves are the calculated results from an
equivalent circuit model using the H/ P AC Circuit Analysis program. T his method has made
it possible to display the impedance curves up to 200k Hz showing the secondary resonance
and RC network damping effect. Measured data from many prototypes were used to derive
the model to represent the average performance.
T he distortion cu rves were generated by a Hewlett/ Packard 9815A/ 9862A programmable
calculator/ plotter with a polynominal curve fit program. The distortion measurements
employed a Sound T echnology 171 OA Analyzer. Verif ied accuracies are on the order of one
pen line width.
DISTORTION
, _. Ill r=:::::p:::z:p=::::::::::;:::i::=:::;::::::::,'.+::=~:::::,::=::::::i===+;:::::------:::r;::-;:ii==:=t
,• • l-.-..-+--+----+--t----'-;:---+-~-;-:---,t-----;-----------1-----
··-
_ .......,._ _ _ _ _ _.,.....,__-+-~-+---~~-+-------.----1t--f+-'-4H
:0
:I
1~-4..,...,....-'+----'----r--t---:--,-+--,--4--+,---'--i-,-,----+.,-:--t-"--,"--'+-----i,-,-, , f + ~
□
Z
h--=+~..::+:~~~r---=--,--,---,'-=:--:,-~...,..;...-1-:--_..;.;:f----4.;..;....-f-----''E--'-l._f-+--+-1 (',
~=~t==±==3~~jt::=2==t==l~::E::::::e::::tS:~±E:::Li-=-::L:iJ:r_=+I~ ~
l-----+---+'~-+-....::....+-,-.;..;..+--+.,---'+---'--f--'-+--'--1-----"--+--'-lrr---+lf - l □
t --------+"""""',--+-'--'---,f--------'------+'---~---------"---+----'---+-----"--tf- ---tf---'--l :0
1----.;;..;;....;.--1-_,.......;---'-,-,f--"---r--+--:-r-~....-l'-,--....:C,---,-,+:,......,............- J- -l--...,......,..j -i
1-----------+------+-t-f-------------t-'---'-,-~--,---------,-.._,- - -t--;+-f □ z
. IBK
A
I:
:t I S::lc:
□
V
w 121c:
V
z
er
0
w
Q. 9K
I:
Eilc:
3K
21!11!1K
<HZ>
A
I:
I
□
V
w
V
z
a:
0
w
Q.
I: QIC
w
V
a: 6K
:J
□
111 •
'-lie:
2K
21211!1 2K 2111K
F"REGIUENCY <HZ>
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
,.._ 1........_:---!--1,-1-+--1,...1...:~--1-+-l-l---4-+f-4--+-+-~.::.+1-1---1-+-,...;.....;~-1,-J-+--+-,,+---+--J...+-l-l--t-+-+-+++-+-+-++H-1 + I
tD
0 i--.--t-r rr r n-H-tt-7T1-t-r-H-i-t-i-tt---.-t-H-""i"'9"=!::!::±::H-- 111
v
-s
w
> 1 --t---±-t---+t..J4 - ~ ( - - ~rt--.:=,--'9--.Cl11 -i-.il:l1Cll--l+-l--l-+-____..--'+'-+-+'+---!--'--1•"4-'4--l-l+'~ ~_..,.-1-4--1-41+-4-1f-+H - 7
l-
a: -a
...J
w
II µ....:+;-+-l-1--4---4-4-+-J.++-.:.....+-.fl~--h-~-1-t++-l-,--P+-H-++-+-+-++++-.:..;.;+~g.;_++f-t-l\l+++H ~
-1 111
PHASE RESPONSE
111
"lJ1
w
w - gt
II
l!J
w
0
V
lli!lli!I
w -+
lJ1
a:
I I S:li!I
n.
w
>
-I- 2ZIZI
II
-
...J
w
II 2gf
www.SteamPoweredRadio.Com
JE-11P·9 GENERAL CHARACTERISTICS
Turns Ratio
1; 1
Impedance Ratio
( 15K/ 15K)
Primary Source Impedance
600 ohms or less
Secondary Load Resistor 15K ohms 2.2Meg ohms
Secondary RC Network 7500 ohms, 1000pF 5600 ohms,1500pF
(most plug-in types have RC net bu11t-in)
Faraday Shield
Separate Lead
M agnetic Shield
30dB, separate case lead
Maximum Input Level at 20H z
+27d8v (Re: O. 775v)
PHYSICAL CHARACTERISTICS
Package
Mu-metal can (standard) or octal plug
Termination
Wire Leads (standardl
Octal plug types also available
Dimensions
1-5/ 16" draminer. 1-9 /16" high (Slandard)
1•511 6" diameter. 2" high (octal plug)
Mounting (standardl
2 holes, 0.7'' center-to-center/ self-trapping screws or clamp
T7
0.015%@ 30Hz
0.008%@ 50Hz
Input Level @ 1% Saturation (dB11 Re: 0.775v)
+26dBv@ 20Hz
+29d8v@ 30Hz
+35d8v @ 50Hz 1 15/16"
Common-Mode Vol tage (maximum)
> 200v peak
Common-Mode Rejecti on Ratio
> 75d8@ 1kHZ
> 55dB @ 10kHz
~ -
2"
\ I
1617 NORTH FULLER AVENUE
HOLL YWOOO, CALIFORN IA 90046
PHONE (213) 876-0059
(Visirors by Appoincmen t 011/y) ----
www.SteamPoweredRadio.Com
Data Sheet JE-11SSP-8M
LINE INPUT
TRANSFORMER
JE- 11SSP-8M
,-- --- ----- -------- --
' 600/1 50 - 600/ 150
I -----------'---0-------,._-➔ TO AMPLIFIER
INPUT
I
I
'- - - - - - - ---- --- ---------'
www.SteamPoweredRadio.Com
REGARDING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration).
50µS/division
5µS/division
1µS/division
www.SteamPoweredRadio.Com
All curves were generated by a Hewlett-Packard 9815A/9862A programmable calculator/
plotter.
A l l calculations were either derived from or verified by actual measurements. The distortion
curves were generated by a polynominal curve fit program using measurements by a Sound
Technology 171OA analyzer. Verified accuracies are on t he order of one pen line width.
DISTORTION
2
't E;.~;t:.:.:.1-:.:.~~:.:.:.~~:.:.~~:.:.:.~:.:.;i:.:.:.f:.~:.t:.:.~1:.:.;'~:.:.:.~S;i~~:~.~
7 ___
:
t- -h • I t I A ~
L
Li
•-- - ~-+-f- l - j . - ~ t--. -~ : i ·- ! i "..1 r r ~ • -4- l 1.
•- __ ~ i ~ · ,c=;c,i-'-' F &c,p= r -~~·E-,-''F"=~rµ' r- :-, ...
-+4 t - t. · rr-- · · f. !-r++tl+etl- .... - - 't- t +t +H H 1..
. '
I
-'- ,·1
.. r
- - i~
- -f
□
,- I
-f
1 j lJ
' I
r
i-:,- ..,...
-
-
-""
-
,;,
--
:i-m' ~ 7'
,_ (\
, "'lfF
1
.! · 1 ...; - ' ....
......... ' -
r /
/ IT1
z
: ~ - a- +
~ Ft + -f
.. r-H· •- t ➔- t Jrtt It ~ , '- ....... V
.
mm,,._
- ___
~: .._____
t~ ......___ ll ....,___
_'1 _.____ ~: ....,________
-'-!RI -321 - 2Z -1 21 21 + 121 +221 +321
I NPUT LEVEL <CBV RE. 77S V>
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
121!11!1
A
I:
I IB5'11!1
D
V
w
V
z
It
0
w
a. 6111111
I:
I-
:J 'illllll
a.
z
22llil 2K 21i!K
FREQUENCY <HZ>
~ 1
.ID 1-+__:.+-.;.;.+....,+-+-+-11-t-+-+-+-!!-++............!~-+-,,;.~--;+::-1-H-1-++-i-+-:;..._;_+;-.+:---:-+-1-+:-H-l~++-H 12111111
V
w
V
l-..L~~WUili!-__._:~~WJ.+.+.+--W--+- -h--=-1--'--hi-::-t-rTT
It .,__-i--+,--,-+--'-+--l+-l'-thl-+-+,..+-+++-----4---'-+--,--T"l--+-il-l--+-+-++-+-~---'+-+--+~l--+-'--+-++++,ggfllll
:J
a
lJ1 l~-i-+t......+~rl-..l+Ht"'l--1-i-'"'f!Hl-++.t+---;...;.+-,..H H"'"!-t--i-+=t--,t-+--t++ttt....-t+-t-t--+----rl--'---t+--+4+" 1.,;.tt,++-it++< l f#
>- H-r-H--t---tt-+.-J~--1-t'--t-::±±±-'.-"'"'."-t:'""!'"'""--t.,.,.+-Hf-hr-+-'-+-'4-'++t--,---i+-+t-+~t-+-!-+-+-+++-l'-tlll
!z ~ gg;td11~~1~t~ft,±±~b::bh!:l:btdd:H_t_l:....=-3J:...:r:hrl± hi-rTD
D
V ~ ---+~-+---+-1-+--H--b.++H-~-+~---+-.Jet-H-t-r.+-+-+++--t+~~~+"+-H-+-+-++~ a
w
lI1 t-i-+-..-++l...-. P~f¥H:8'-I-
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
I
li!I
A
-I
ti]
Ci -2
V
..J
w
>
w
_J
-7
-a
w
>
l-
a:_J
-------+, -s
- lli!I
w
D'. - ---t-,-+-H•-+, ,+,1- + - - 1 - - -.... ~ - 11
.. I -12
PHASE RESPONSE
A
Ln
w
w
D'.
L!l
w
Ci
V
- S:li!I
- 7S:
w
> IIZIIZI
I-
I!
..J
w
D'.
www.SteamPoweredRadio.Com
JE•11SSP-8M GENERAL CHARACTERISTICS
Turns Ratio
1: 1
Impedance Ratio
600/ 150 - 600/ 150
Primary Source Impedance
600 ohms or less
T
1, 1/ 2"
PHYSICAL CHARACTERISTICS
Package
Mu-metal can (standard) or octal type plug
Term ination
Terminals or 11 pin plug (octal type)
Dimensrons
1.5" >< 1. 75" x 2.5" high
Mounting
Threaded inserrs
TYPICAL PERFORMANCE
Insertion Loss
- 0.7d8
Input Impedance 2· 112"
@ 1 kHz 701 oh ms
@ 10kHz 732 ohms
Secondary Source Impedance
@ 1kHz 701 ohms
@ 101cHz 732 ohms
Frequency Response ( Re: 1k Hz)
@ 20Hz - 0.03dB
@ 20kHz OdB (reU
Bandwidth
@ - 3dB 1201cHz
Phase R esponse
@20kHz - 9 deg
Rise T ime
(10%-90%) 2.SµS
r
Overshoot
< 3%
T otal Harmonic Distortion (Below Saturation)
0.035% @ 20Hz
0.018%@ 30Hz
0.008% @ S0Hz
Input Level@ 1% Saturation (dBv Re : 0.775vl 1· 1/ 2"
+22dBv @ 20Hz
l
+26dBv@ 30Hz
+31dBv@50Hz
Common-Mode Voltage (maximum)
> 200v peak
Common-Mode Rejection Ratio
> 85dB@ 1 kHz -
~ -- - - - - - - - 1
> 65d8 @ 1Ok Hz
------
f~ 1·3 /4" - - - - ~
2-1 / 2"
www.SteamPoweredRadio.Com
Data Sheet JE-11SSP-6M
LINE INPUT
TRANSFORMER
- --,
JE-11SSP-6M
I
600/1 50 - 600/ 160
BRN _ _ _ _ __ _ __ _
1
G_R_N_....;.1_ _,v.--------~ TO AMPLIFIER
INPUT
RED BLU
RL • 600 OHM
ORG VIOL
VLW GRV
I
BLK
I
,_ - - - -- ________ I
WHT
www.SteamPoweredRadio.Com
REGARD ING THE OSC I LLOSCOPE PHOTOS
Actual oscilloscope photos were made with a Tektronix Model 453A (certified calibration).
50µS/ division
5µS/division
lµS/ division
www.SteamPoweredRadio.Com
All curves were generated by a Hewlett-Packard 9815A/9862A programmable calculator/
plotter.
All calculations were either derived from or ver ified by actual measurements. The distortion
curves were generated by a polynominal curve fit program using measurements by a Sound
Technology 1710A analyzer. Verified accuracies are on the order of one pen line width.
DISTORTION
.J~ _
•-- . L
I t +~
- - .. . '-=
:1
' '.;.
I I I
= C ; ; H ;:::I~ -¾ +-
- . ~ t ,;.., ± ·,,_
"·· .i--.: t ~-~ . i' ~- ' - , ,~
l --
+:
•- .ti,. -~
~, l
.+I
-1--4
' '
\ 1
~
j • .
+:± ; ; f - 1
. .
t ; !" ·-i
L..i '
~
,
-
I LI.
I
'
f •
• -+
: t
.
,
+-
t I
I
t-EEI ba - - i-t • t
'-· F . - .d r. i.
- "'
L
...:
~
1. L' - '
,____ l$t:i:. l=r;_j__:f- ··-~ ;.:-11". -
•l~
,~7"
·±
..:.i
- 'r·u
:c. -_:r~~
-- -1- --
:!ili Ftl..J .-=-
--~--=\JF-- I i_c I..Jr II I f-----:-1..t-
1-
I I
f [a1w ."~.,.,.,
-,+
J - f-, -4-
I-- , .,
i,;.
,.,,. r::, )'
j
.
I t L 1
" -·- - ·~··· '1-------l . J. •
. I. ' I
..,.....-:t;:..- . '-±4 ~ j: ·i;;; . l h -➔
.. ..:n r '..
-~• . :a
~
=- ..,. ,,
~,1_ .....,__r-
- ~ - ... -·
J ·F ±1-
. .
. T ...... ~ i _ -
:- ""Fl ~
.• -1 ➔ - Fl" CI ll
:r
-~
--
T
·----'"'· t- --1-_ I
I
• J"
..I I
,
z□
, L::. H ,.+-i . - r--.-< ;+'
i,~.,' ' I~
clP >-9 ! .1 •-t• :i '7.
-· -1~
~
, - - . r ' .- 4-f,=;
L
FJ-.ai:£ " 'i l-;;
:;,.'J:t=! ft j-'?. L 1 :t !.1
-~
.,··t
. i=P -I
. /tc
H.i:j
~ ~., f
Lt
.; f'I
...,.., +"# rri J.:h: :. t~ ~~ 1- .. +~ ➔ l1 11
- I
t.....: :~
• f -i..; - '.;,
'j ;
'
~-a nl§ :µ_._-;
1ffi p..
1- ' - E
-,:!:
,§g :!~ lffll :1 - I v' I Q
.. .-
111 - I
.
-t Ht-
.- I
II I
I Ln
~·
L
~
-,
..
)..
I -
~ ~ L L. I I I
c 1-4=--t, t -' :_1 ~ "i I □
--
J
~,
..
l,F,ct ~gc, t -- .... r I . I, . I ll
--- - ......... ,.........:...!-; / ........ f-1- -r I-' + ·~t- '
.
.-r+-i 1,1 -· ~
..
' -r.llffl 't' ltJ"7 1-
f ~, t f ,-;
~
0 ..
.-r-· 7 . ~.
-~ .l ' ... ~ '-'T ff - z□
I~ Fl= :-_t ' '-" --:, IT
l-'.f"W :-t·
-
-r7 :, ~ ~ :~ - ,/ f
1
1l
::n--- .--:.
-- . - :r\r ... - . _, ~
' l'l
8.:f
• II 1. h 1 - ft$
•
- L~
...
,,._.,.
~
~
±::"I J
,
A~j f t'
ll
f'I
i- 'H
,...,~ < - " -i- ' '; '; z
l'l
. -... ·-·.
1= -. ; I.
' ~ ;..
'1 ~ ~ _;_:_Ft= - ,... -it"!
j1,,;c,,.i,
' t
~
4 t· -~ ~
rt~ .. ""
·~ cj='±
-
i-.-,..,..
4 :_ '
; . ,; .. ',,. H I ·1
'f:lr ..F-El !. ,J 'j 1-e
•_=ri.i.
,4... + tt" ja . .~ . ~ I t H •~
.FF. . i"l
I':'½. t'i~~ : : : EP. .
F.'!: 'fa -- ~-
i :
•, ,i-11
~
l''E.~:-~l'Tl
- ...:t.
n !
.. ;:¥::,
--
I~-
f -1 I I•
n:.-,
~
4T' "
•a• . . , .- IV I-: frF.I lffETI-....;
·- Lt+•-~
:
1'-8
-
~1=:H
,,
" . .:.
~l ·: 7
....... t
& . ;. "".-i ~
:I,...
11111!,1 't r. I- t
~
I
-'1111 -3111 -21!1 -1111 Ill +1111 +21Z1 +3111
INPUT LEVEL <CBV RE,77~V>
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
A
I:
I: l----+-++l---,--+-'-+--H-l-+-l--+-+l-----+~i--:------:-i-'--lif-4!-~1-4c...i!'-H-l---.......;.-~.i-+-+-I
D
V
w 1---.....,...___:_J.--.1-----+~1--,-~...µ...-1-1--1--------4--'-'-t--!-;.;...:.i---4---l----l--l-:...i..---~
V _ __,__
i0 1----i.--i_i_+J.:-4:-+H--HH-t- ---:-±±:-h::±-HH-tttt~tt--t~1ttm
w
a..
I:
i---,---;--t--t-+-t'-f'-+-t-+--t---+--+--t----+-t--1--+--+-!--t-+--+--+--+--l-----"+-I--H-+....;;..,.-1--+-l-1-1--+--ls:
221!1 211lK
FRE:tilUE:NCY <HZ>
A ,__.____,._._
I:
: r 1--.-;:
a I - ;-rt~t-f-:!:l!.!::;:::~l=#:t!j;::~;:t--t~r'-tt:.;t.;t;;:::-ra7t-:ttt-;-;T;tiT71THt7."t~H.:"1~ii.tr'm 12111111
V
~ H-++l--l'P-1~-+--~~½j,,:.f--!-Hr--+-r--1~r-it~lt+Hht---lr-H-Hr--r:-t-'----71~~-41',H'-i-+t---t:1rH~111
!z LL--l~~w~~~~ ~l=~~jj~bjb:jjj:Jt:JIJJ::l::1;:;b:ot:=tl±~:Jttj!ttJ:lllj~j:Jlijt:j~
0 1---1---1-~~-+---h'-1-+"1r.--l:~b-Hr-~~Pt1~-fb.:l:'--HH-,..._t--H~~~r.7!-+--'Hr-H-+--HH-12111111
V
w t •
m -.-1 ~~~n fw,t•,-+"11-+>t:.,.,.
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
li!I
-6
w
> j....-.4,-'-~l-+--1--1---1-4--l-l-4-l---1-~-l--l-,-+J..+~-+-4-i-;....;....~+:-~-l-l--+--l---1-1--l-.-.;...i....l..-:..i......;;.µ_1-:-+.-i..:.i...1-1-1 -7
I-
II -a
..I
w
It 1-r-'. .:++'-!=r"-l-'+.+-.:-l-1---l-l-++-~~.........j......~...j....j.-+-4-i--.;.....:..;....;.;.;.i.:,;_~.:...µ4-.::J.-1-l--l--l-,;..:........--l ........i-1-1-----1--1--1-1- -9
- I la
PHASE RESPONSE
ra
/\
U\
w -2s:
w
It
l!]
w
0
V - s:m
w
U\
II
J: -7S:
a.
w
> I li!lli!I
I-
II
..I
- w
a:
'•
22
j
2221
F"REGIUENCY <HZ>
2K 22K
l2S:
2li'Jli!IK
www.SteamPoweredRadio.Com
JE-1 1SSP-6M GENERAL CHARACTERISTICS
Turns Ratio
1: 1
Impedance Ratio
600/150 - 600/ 150
Primary Source I mpedance
600 ohms or less 1, S/8"
Secondary Load Resistor
600 ohms
Faraday Shield
Separate Lead
Magnetic Shield
30dB, separate case lead
r-
Maximum Input Level at 20Hz
+18dBv (Re: 0.775v)
PHYSICAL CHARACTERISTICS
o.7" -1
Package
Mu-metal can (standard) or octal Iype plug
T ermination
Wire leads or 11 pin plug (octal type)
Dimensions
1-5/8" diameter , 1-3/ 4" high (standard)
1·5/ 8" diameter, 2,5" high (octal p lug)
Mounting (standard)
Capacitor clamp supplied
TYPICAL PERFORMANCE
Insertion Loss
- 1.0dB
Input I mpedance
@ 1 kHz 734 ohms
@ 1OkHz 745 ohms
Secondary Source I mpedance
@ 1kHz 734 ohms
@ 1 OkHz 745 ohms
Frequency Response lRe: 1kHz)
@ 20Hz - 0.25dB Lead Holes
@ 20kHz 0dB (ref.) Use 0.35" hole to clear grommet
Bandwidth
@ - 3d8 160kHz
Phase Response
@ 20kHz - 5 deg
Rise Ti me
( 10%·90%) 1.7µ S
Overshoot
< 3.5%
Total Harmonic Distortion (Below Saturation)
0.035%@ 20Hz
0.018%@ 30Hz
0.008% @ 50Hz 1•5 / 8"
Input Level @ 1% Saturat ion (dBv Re: 0.775v)
+17dBv @ 20Hz
+21dBv@ 30Hz
+26dBv@ 50Hz
Common-Mode Voltage (maximum)
> 200v peak
Common-Mode Rejection Ratio
> 90dB@ 1kHz
> 70dB@ l0kHz
2· 1/2''
1 I
1617 NORTH FULLER AVENUE
HOLLYWOOD, CALIFORNI A 90046
PHONE (2131 876-0059
.. .. .. .. ..
(Vfsirors by Appointment Only}
-
www.SteamPoweredRadio.Com
Data Sheet JE-11P-1
LINE INPUT
TRANSFORMER
I BLK
I
I
- ----- ---
WHT
www.SteamPoweredRadio.Com
REGARDING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration).
50µS/di vision
5µS/division
1µS/division
www.SteamPoweredRadio.Com
The response and impedance curves were generated by a Hewlett/ Packard System 45
Desktop Computer and a 9872A Plotter. The curves are the calculated results from an
equivalent circuit model using the H/ P AC Circuit Analysis program. This method has made
it possible to display the impedance curves up to 200kHz showing the secondary resonance
and RC network damping effect. Measured data from many prototypes were used to derive
the model to represent the average performance.
The distortion curves were generated by a Hewlett / Packard 9815A/ 9862A programmable
calculator/ plotter with a polynominal curve fit program. The distortion measurements
employed a Sound T echnology 171 OA Analyzer. Verified accuracies are on the order of one
pen line width.
DISTORTION
-;
□
-;
:n
r
.-
I
ll
;n
:I
□
z
(\
-U1Q
-;
□
;n
-;
-
z□
"'
11
l"'1
;n
(\
l"'1
z
-;
V
0~ 1L---l-----L---..&.------''------,L,-- ----,----=----:--==----:~
-Y0 -30 -20 - 10 0 +10 +20 +30
INPUT LEVEL <DBV RE . 77~V >
www.SteamPoweredRadio.Com
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
w
V
z
ct
0
w
n.
I:
1-
::l
n.
z
2111111 2K
FREu!UENCY < HZ >
>- t----t--h-t-hr+-t--t-+-+t-t--t--+--t-~--+-f-l-t"+++t---+-+--+--i!-t-+....-+--b-1"-H+-l--l-,...'4-+t---'--+!!'l!r4-,H-l
~ ~-l-+---4--l--l~-1-+--l,..;...l-l=c-l--+-J...-1---l---l-4-++-l-l-'-~-t--+1rn
0 -
z
□ ,__-+--+-t-+--+++-+-+-H--+--'---+---"+-"-++......+----+-+-++++---------..-+--+-1-.-+-+-+.-1-H+-.....-,-.-+-_...~--++-t 2K
V
w
III - ·
A µ.......-1---1--,o.~~-+'-l----1-4-~.;..,...;.i.-'-'--'"-i--1---l-4--'-1--1---14-1-~-l-~.....i--4-1-'-1-1--+4-..........-""-+-.-+-l--+--+-+-+-i-l + I
IO
0 r---r:-H-----rti""ti"tt-----t:--t----t-H--ti-tt:t--t--t---t---r.~-..l:::!:k.__
V
-I
-2
w
>~ ---t-----,~f-,-1--f-"-w--.o;,--\.+li:JY-
a: - ~--~~~t~
I-
It -B
.J
w
-1111
PHASE RESPONSE
Ii!!
A
Ln
w
w
[t
-!u!I
l!I
w
0
V
l li!lli!I
w
IJ1
ct
J: 1~111
n.
w
> 21i!1111
I-
ct
.J
w
a:: 2~111
2li!I 2li!lli!I 2K
F'RElilUENCY <HZ >
JE•llP-1 GENERAL CHARACTERISTICS
Turns Ratio
1: 1
Impedance Ratio
(15K/ 15K)
Pri mary Source Impedance
6 00 ohms or less 0
Secondary Load Resistor 15K ohms 2.2 Meg ohms
Secondary RC Network 30K ohms. 270pF 13K ohms, 620pF 0.7"
(most plug-in ty pes have RC net built-in)
~
Faraday Shiel d
Separate Lead
Magnetic Shield 0
30d8, separate case lead (standard)
60d8, (octal plug-In wpes)
Maximum Input Level at 20Ht
+ 18d8v (Re: 0.775vl
Co.,. ::J
r - - 1· 1/ 8" - - - 1
PHYSICAL CHARACTERISTICS
Packege
Mu-metal can (standard) or octal plug
Termi nation
Wire Leads (standard)
I
1- 1/ 16"
L_______
Octal p lug types also available
Di mensi ons
1-1/ 8" diameter, 1-1 / 16" high (standard)
1-5/ 16'' diameter, 2" high (octal plug)
Mounting (standard )
2 holes, 0. 7" center-to-center/ self-tapping screws supplied
T7
Secondary Source Impedance
4300 ohms@ 1 kHz
4900 ohms@ l0kHz
Total Harmonic Distortion (Below Saturation)
0.045%@ 20Hz
0.03% @J0Hz l 15/16"
0.013% @ 50Hz
Input Level @ 1% Saturation (dBv Re: 0.775v)
+17d8v@ 20Hz
+20d8v @ 30Hz
+26d8v@ 50Hz
Common-Mode Voltage (maxi mum)
> 200v peak
Common-Mode Rejection Rati o
~ --
> 75d8@ 1 kHz
> 55dB@ 10kHz
2"
I l
.. - -
1617 NORTH FULLER AVENUE
HOLLYWOOD, CALIFORNIA 90046
~
-
PHONE 12131 876-0059
( Visitors by A ppointment Only}
www.SteamPoweredRadio.Com
.. www.SteamPoweredRadio.Com
SPECIAL TYPES
www.SteamPoweredRadio.Com
Data Sheet JE-44K-DX
400HM
MOVING COIL
CARTRIDGE
The JE-44K-DX is a step-up transformer for matching a 40 ohm
INPUT
moving coil cartridge to the 47K ohm input of a standard phono pre-
amplifier. The transformer steps up the cartridge ou tput level by 19.7dB
TRANSFORMER
and bridges the cartridge with about 400 ohms input im pedance.
The JE-44K-DX has a multiple interleaved layer winding for low
leakage inductance. This yields wide bandwidth quite insensitive to
load, low losses which affect noise in the upper spectrum, and very
high frequency low O resonance. A series RC network of 13K ohms
and 130pf should be connected across the secondary for minimum
transient distortion. T he high frequency bandwidth is 170kHz with
only - 10° of phase shift at 20kHz. The rise time is 2.3µS with less
than 1% overshoot.
The input circuit of t he phono pre-amp loads the transformer in
4 7K ohms. If there is a capacitor across the input, it should be
removed. Also any cable used on the secondary of the transformer
should be a special low capacitance type and no longer than necessary
for minimum capacitance.
The series loss ratio referred to the secondary for 20kHz bandwidth
is 1.4 ohm/ohm. This results in the transformer related noise figure of
only 1. 7dB. The 1Ok Hz secondary source impedance is only 2.4%
higher than at 1kHz, so the noise spectrum is very close to a pure
resistance.
The dis tortion at 20Hz is on the order of 0.1 % for all levels up to
30mv at the input. At 30Hz, 0.06% and at 50Hz. 0.03%.
Faraday type electrostatic shields are used between the primary and
secondary sections. Combined with balanced capacitance in t he
primary winding, this e liminates capacitive coupling through the t rans·
former o f high freq uency environmental noise which is common to
the two input leads. The Faraday shield (black lead) shou ld be con·
nected to the same ground as the low side o f the secondary
(orange lead).
The transformers are cased separately (not paired), with dual
m u-metal cans for greater than 60dB of magnetic shielding. They can
be mounted with two self-tapping sheet metal screws (supplied) or
ring type capacitor clamps (supplied) which allow custom orientation
for minimum hum pickup for each channel. The two mu-metal cans
can be grounded with the two white lead wires.
JE--44K- DX
,-
I
-------4014K
- --- -----,I
I
I I I
RED I I VEL
400HM
CARTRIDGE
BRN I t ORG
BLK
--------------,--- WHT
www.SteamPoweredRadio.Com
REGARDING THE OSCILLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration).
50µS/division
5µS/division
www.SteamPoweredRadio.Com 1 µ$/division
All curves were generated by a Hewlett-Packard
9815A/ 9862A programmable calculator/ plotter.
All calcu lations were either derived from or verified
by actual measurements. Verified accuracies are on
the order of one pen-line width.
DISTORTION
I
ll
ll
3:
D
z
('I
0
1
t~~~E~~=E:~;E:::t::jE=:jt:~3===1~~~~:3t~===~~=~t=E=t::.--i ~
0
:
0
ll
-t
0
z
A
1J
l'l
ll
('I
l'l
z
.. -t
V
6l!IIZI
A
I:
I 5:00
□
V
w '-tlZl0
V
z
a:
Cl
w
n. 3021
I:
I-
::J 2Rl21
n.
z
112121
:2121 2Rl21 2K
FREQUENCY <HZ>
SECONDARYSOURCEIMPEDANCE
.." w
"
A
:I:
I□ 1----.:.+-!--i--+....j...,l...+-1-+--i--;J....1-1---+--'-i--.;_;1-+--4--'-!---'--<f.:.....+-+-+-l-f-'---+-----ll--',~;.+-,1-'-t-1=+-+YH--4
V
FREQUENCY <HZ>
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
A +I
ti]
C
V
__J 21
w
>
w
__J
-I
r-
::J
11.
r-
::J -.2
D
w
> -3
PHASE RESPONSE
~
"
21
A
-IIZI
U1
w
~ ....t...,...,.--';-f-nt-tt-r-l-4+"-t-t+t-l--t--b.-:+rtrr+-t+.t-t-t+-H-~-4--t-r+-H-.;jf4-t+f-'-+-+--'"l,..-i,-+-+t+,!-~;,++ti -2111
I!]
w ttrt-"-htf-:~ ~ ~ ~ ~ -321
~
-7111
w
>~ -+t-f-;;rht:-+-t-::-Et-t+-t+.--:--:t=-t.-+.:-t½-t-:-t--+t+t-l-:-+i---t--+-il-f-H-+ii+-t+t+--f4-:-t-~~ti+,i-+-4-++H-B21
r-
lI
__J
H-++~4--1-1-11-4-H ••__,....._,_..__+-
- 921
w
~ n --+-+-t-t--+r+.:+-H--H--:+~-'&~H+-H-t+l---f-+'i'H'-,-+,,++-++++-~""'+'-I-H--lf-'++++H ll!l121
I 121
! '
221 20121 2K 2IZIK 21Z1111K
FREQUENCY <HZ>
GENERAL CHARACTERISTICS
Turns R at io
1:10
I mpedance Ratio
40/4K
Primary Source Impedance
40 ohms
Secondary Load I mpedance
47K ohms (Phono pre-amp)
Secondary Load R esistor
None required
Secondary RC Network 0
RN : 13K o hms CN ~ 130pf
Faraday Shield
Separate lead
Magnetic Shield
60d8, separate case leads
Maximum Input L evel at 20Hz 0
- 12dBv (Re: 0.775v)
PHYSICAL CHARACTERISTICS
Package
Dual Mu-metal can
Termination
Wire leads
Dimensions
1-5/16" diameter. 1.1 /4" high
Mounting
2 holes, 0. 7" center-to-center, self-tapping screws or clamp
TYPICAL PERFORMANCE
Voltage Gain
19.7d8
Input Impedance
4 20 o hms @ 1 kHz
375 ohms@ 10kHz
Secondary Source Impedance
5450 ohms @ 1 kHz
5580 ohms@ 1Ok H z
Frequency Response (Re: l kHz)
- 0.3d8 @ 20H z
0.02d8@ 20kHz
(No resonance peak) Mounting H oles
Bandwi dth Clearance for ,r 4 ~crew.
170kHz@ - 3d8 Lead Holes
Phase Response Use 0.35" hole to clear grommet.
- 10° @ 201<Hz.
Rise T ime
2.3µS ( 10%-90%)
Overshoot
< 1%
Total Harmonic D istortion (Below Saturation)
0.12% ma><imum@ 20H z
0.065% maximum@ 30Hz
0.03% ma><imum@ 50Hz
0.006%@ 1kHz
Input Level @ 1% Saturation (dBv Re: 0 .775vl
- 12dBv@20Hz
- 7d8v@30Hz
OdBv@50Hz
Common-Mode Voltage (ma><imum)
:> 200v peak
Common-Mode R ejection R at io
> 85d8@ 1kHz
> 6 5d8@ 10kHz
Transformer Noise Figure•
1.7d8 Re : 36.1 ohms '•
www.SteamPoweredRadio.Com
Data Sheet JE-34K-DX
30HM
MOVING COIL
CARTRIDGE
The JE-34K-D X is a step-up transformer for matching a 3 ohm moving
INPUT
coil cartridge to the 4 7K ohm input of a standard phono pre-amplifier.
The transformer steps up the cartridge output level by 31 dB and bridges
TRANSFORMER
the cartridge with about 30 ohms input impedance.
The JE-34K-DX has a multiple interleaved layer winding for low
leakage inductance. This yields wide bandwidth quite insensit ive t o
load, low losses which affect noise in the upper spectrum, and very high
frequency low O resonance. A series RC network of 13K ohms and
120pf should be connec ted across the secondary for minimum transient
distortion. The high frequency bandwidth is 148kHz with only - 11 ° of
phase shift at 20kHz. The rise time is 2.0µS with less than 1% overshoot.
The input circuit of the phono pre-amp loads the transformer in
4 7K ohms. If there is a capacitor across the input, it should be removed.
Also any cable used on the secondary of the transformer should be a
special l ow capacitance type and no longer than necessary for minimum
capaci tance.
The series loss ratio re ferred to the secondary for 20kHz bandwidth
is 1.33 ohm/ohm. This results in the transformer related noise figure of
only 1.4ct8. The 10kHz secondary source impedance is only 1.9% higher
than that at 1kHz, so the noise spectrum is very close to a pure resist ance.
The distortion at 20Hz is on the order of 0.1 % for all levels up to
10mv at the input . At 30Hz, 0.06% and at 50Hz, 0.03%.
Faraday type elect rostatic shields are used between the primary and
secondary sections. Combined with balanced capacitance in the pri-
mary winding, this eliminates capacitive coupling through the transfor-
mer of high frequency environmental noise which is common to the two
input leads. The Faraday shield (black lead) should be connected to the
same ground as the low side of the secondary (orange lead).
The transformers are cased separately (not paired), with dual mu-
metal cans for greater th an 60d8 of magnetic shielding. They can be
mounted with two self-tapping sheet metal screws (supplied) or ring
type capacitor clamps (supplied) which allow custom orientation for
minimum hum pickup for each channel. The two mu-metal cans can be
grounded with the two white lead wires.
JE- 34K- DX
J/ 4K
,------------
1
-----
RED
: ---- --------,
I YEL
30HM
CARTRIDGE
BRN l20pl
ORG
BLK
'- _
---------------'----
_ _ _ _ _ _ _ _ _ _ _ _ _
WHl
WHT
www.SteamPoweredRadio.Com
REGARD ING THE OSC I LLOSCOPE PHOTOS
Actual oscilloscope photos were made from a Tektronix Model 453A (certified calibration).
SOµS/division
■■■■
SµS/division
www.SteamPoweredRadio.Com
1 µ $/division
All curves were generated by a Hewlett-Packard
9815A/ 9862A programmable cal cu lator / p lotter.
A ll calculations were either derived from or verified
by actual measurements. Verified accuracies are on
the order of one pen-line width.
DISTORTION
-
-i
□
-i
JI
r
r
JI
::ll
:I
□
-flz
L
t Q
-111
-i
□
ll
--i
z□
"'
11
l"'1
::ll
fl
l"'1
z
-i
V
61!1
/\
I:
I 5:IZI
□
V
w '-1121
V
z
er
C
w
Q.
:aim
I:
2JZI
I 111
SECONDARYSOURCEIMPEDANCE
II !I g l!I II ll II I! ii
/\
I:
I
□
V
w
V
z
a:
0
w
Q.
I:
w
V
a::
:J
□
U1
SK
21!1 21!1121 2K
F"REulUENCY <HZ >
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
A +I
ti]
C)
V
_J 121
w
>
w
_J
-I
I-
:J
a..
I-
:J -:2
D
w
>
-I- -3
a:_J
w
II -'-i
PHASE RESPONSE
111 .J.
w
w 1-1-.-1-1-,~-!---IJ!.4...l~~-l-4-.........'"'-l-~~~~...i....i...u.~~~-.l.;J.~~....u...u.J-....J..::w....J-i..;.i;.......J•...111-J-WJ _ :2121
II
l!J
W litl+tti~t~ ~ ~ ~ ~ ~----ttttf.::::t:t:117:1 .•~.....::....:.4 -1-1-t..i..i.!.~~l-.ll-..j.;..j.._,;..j;jj,,l.;u...j.;.W..;..;..;...,.....1
C)
V l-r-i-'-t-''-tf!l-°'Pl~""-i--H-+++--t--t--!-'ii'-Hl-+-H-f-++,-i-.:..+:.;.;+-,-i-1-i-f-l-l-+H-+-++:-!-.;.:.+--l--i-f-).,-f-+++-i'-1H+i -Yl2I
-7121
w
> H-rt-HH--t-i---H-+-H-++-t--+'-r+--~1-:-Ht-+-H-+++-'-+--+-'+-ll-'-'i-t+-H...J-++;..;.-+;..+-+-H-1-..::+-h-l-\+-+-I-B.li!I
l-
a:
_J
l-++t~:..\1-,-~ ·'-+-++~..+414++-'~ l,1<+1 -9121
w
II H--t--t--H-t-t-+-H-+++:-'.""+.--+--:rit--;-,1--+-H-+++----,-+--+--r,-t--,t--+-H+++-'--+--+--+-r,-t--,t-+-H-++1 1121121
PH YSICAL CHARACTERISTICS
Package
Dual Mu-metal can
Termination
Wire leads
D imensions
1-5/ 16" diameter, 1-1/ 4 .. h,gh
Mounting
2 holes. 0.7" center -t o-center, sell-tapping screws or clamp
TYPICAL PERFORMANCE
Voltage Ga,n
31d8
Input I mpedance
31 ohms@ 1kHz
29 ohms @ 1OkHz
Secondary Source Impedance
5200 o hms @ 1 k Hz
5300 ohms@ 10k H z
Frequency Response (Re: 1kHz)
•
- 0.35d8 @ 20Hz Mounting Holes
+0.02d8 @ 20kHz Clearance l or = 4 screw
(No resonance peak) Lead Holes
Bandwidth Use 0.35" hole 10 clear grommet
148kHz @ - 3dB
Phase Response
1 !'' @ 20kHz
Rise Time
2µS (10%-90%)
Overshoot
< 1%
Total Harmonic Distortion (Below Saturation)
0.12% maximum @ 20Hz
0 .06% maximum@ 30Hz
0.027% maxi mum @ 50H7
0.025% @ 1 k Hz
Input Level @ 1% Saturation (dBv Re: 0.775v)
- 24d8v@ 20Hz
- 19dBv@ 30H z
13dBv@50Hz
Common-Mode Voltage (maximum)
> 200v peak
Common-Mode Rejection Ratio
> 85dB@ 1 kHz
_,. 65d8 @ 10kHz
Transformer Noise Figure•
1.4d8 Re : 2.7 ohms••
www.SteamPoweredRadio.Com
Data Sheet JE-MB-C
MICROPHONE
BRIDGING
TRANSFORMER
The JE-MB-C is a 1: 1 turns ratio microphone bridging t ransformer
with a single primary and a single secondary winding, each surrounded
with its separate Faraday shield.
The JE-MB-C can be used to isolate and balance an unbalanced pre-
amplifier input or to bridge a balanced microphone line, which is
terminated with a balanced preamplifier input , to feed a second
balanced preampli f ier input.
The transformer, with separate Faraday shields for each winding,
isolates and rejects the common- mode noise caused by the noise
voltage difference between the chassis of the two mixers. With t his
type of isolation, the microphone shield can be connected through t o
the chassis of one mixer but need not be connected through to the
second mixer chassis. Instead, the chassis (shield) of the second mixer
connects only t o the Faraday shield of the secondary. T his eliminates
the ground loop which would be caused if the microphone shield were
connected through to both mixers.
Phantom power can be provided by the mixer which terminates the
microphone directly.
If cables wi th the shell connected to pin 1 (shield) are used in the
system, insulated mounting will be required for the connectors.
The design is optimized for a source impedance at the primary of
150 ohms (microphone) and a secondary load of 1000 ohms ( typical
microphone preamplifier input impedance). No resistors are used in
the usual applicat ion of a "mic-split box."
If the transformer is used to balance an unbalanced preamplifier
input, a secondary termination resis t or may be necessary to result in a
load of 1000 to 2000 ohms . A higher secondary load impedance may
result in a ringing response.
JE-MB C UNBALANCED
MICROPHONE
PREAMPLIFIER
II ,so 1so ORN I
BAN I I ,,..__ _ _..__ _ _-----<
I I
1 I RL 1500
JE MB C
BLK I I I '--V;..:E..:..L_ _-4, FEMALE
,---------- MALE
1
L - _J 3 1BRN VEL
BLK MICROPHONE
INPUT
• •
WHT
ORN
BLK
I BLK
---- -
I
------'
WHT
MALE
3
DIRECT LIFT
ON
OUTPUT
GROUND
SWITCH
CHASSIS
50µS/division
5µS/d ivision
1 µ S/ division
All curves were generat ed by a Hewlett-Packard
9815A/ 9862A programmable calcu lat or/ plotter.
A ll calculations were either derived from o r verified
by actual measurements. Verif ied accuracies are on
the o rder of one pen-line width.
DISTORTION
..
-I
□
-I
ll
r
I
ll
::0
:I
□
z
.... (\
0
IJ1
-I
□
::0
-I
-
z□
A
1J
fTl
::0
,GIi
•• (\
fTl
z
-I
V
INPUT IMPEDANCE
A
I:
I t-----C--+--
□
V
...,....._--+-,-.-- t--r-!--t-1--t- ---l-!--t-
w
zV 1--'----.,..;+-..c+f +~=¼-'+- t--r-::--t-t--t--t -t-,---o-=t--,-½ -'-+=+-"c...i-;.- -+-1-+-+ + - + - - ~ - ---'-1--
-,-++--!l'-tlllil
a:
0 t---~~-::-::t,;- +.:c:+-+-::+.:: +-Ji,,--1-!l-:i- -:--:-,-t-:--,c~ ,t-t-t-~--t--t -t--H---;--t- --t--t-T'""'t"-
w t-l'"-t-r1rt-"t-1 "112l!llll
a.
I: 11!111111
I-
~
a. t--,.-.z...:..:...;.::~.;....:.::.:=i:;::+-++-1-~ ....,~ ~ ~...r....,.-1-1, ~-..,..-+-1,~ ¥-f-L-IY'-<~~ +='~~Er +-,-tr.,tt-;';t.'-t-+1 611111
z
w
V
a: - - ------t-,~-t-- ;,--..-1-,-t-t- -t-+--t------- .--.....-t--t--- t-..-t'"--t---r -ir-t-l~--~-r- ---
~
□
Ul ~ :::4---i-L4 --+-1-=-4*~---.- -1-rH f++++ t-~r-r
>- - ---'-4--~--+ -"--"+----¼ -+-1-f-l--+- -+-....._---- ----+-+-+-+ -+---;.-t-,-J -,-+---+-t--
i-............,....,-,
a:
a:
0
z
□ t - --.-,. -.>-----1---t- +--t-+-+-•·t - - t - - - - + - ~ -.........~-t--t-t-t-t-t ------r-~--t- --t-,,-,.....-t --t--t--t-t
V
w
Ul
:221
FREQUENCY <HZ>
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
l +2
A ~ ~f+i'!.J.JH-+-i-f-~++-f-~f+:-:#~Jl+.t+J...++tri+f-+~f+.H~:+.-f--+-f.!4~H+!--4-t-*- ~rt:-+rll"++"'f'::+-t-H+ I
!fl
e1:Lr...~,1t4,4+H4-++tt~ ~ ~hi-t-ti11t"--t"""1"'-r;;titr-rt"t++4.. IZI
-6
w
>~ -+t-ttH+++-H+.:-++-H+--:-:-t--;t-,-:+':;~•.j...j.....ll,-l-+1-H-,~~"++f~-+-&11-i:-t-t-t+.-~~'±'-r+t-'-t-f'--H+t-7
f-
er -B
...J
w
a: --------i--•H--~#t..:+i,.;+..+,+.,t-+:H-++--~~4-++.-t':--1-t:++,--:--:-~fl-iitbttl:"'T't"rt-t-t
- I IZI
PHASE RESPONSE
A
U1
w
w~ ~'-1-4....J,. - s:ra
a:
I.!]
w
0
V
w
U1
a:
I I S:121
n.
2S:121
TYPICAL PERFORMANCE
Vol t age G ain
- 0.8dB
Input I mpedance
1040 ohms@ lkHz
1080 ohms@ 10kH z
Secondary Source Impedance
245 ohms@ 1kHz
290 ohms@ 1Ok H z
Frequenc y Response (Re: l k H z) Mounting H oles
- 0 .25dB@ 20Hz Clearance for # 4 screw
- 0.20dB @ 20k H z L ead H oles
(No resonance peak) Use 0.35" hole to clea r grommet
Bandwidth
88kHz@ - 3dB
Phase Response
- 15" @20kH z
Rise T i me
4.3µS (10%-90%)
Overshoot
< 1%
Total H armonic Distortion (Below Saturation )
0 . 18% maximum@ 20Hz
0.10% maximum@ 30Hz
0.05% maximum@ 50Hz
0 .005%@ 1k H z
Inpu t L evel @ 1% Saturation (dBv Re: 0 .775v)
- 2dBv@20Hz
t3dBv @ 30Hz
Common-Mode Voltage (maximum)
• 200v peak
Common-Mode Rejection Ratio
> 85dB@ 1 kHz
> 65dB@ l0kHz
www.SteamPoweredRadio.Com
Data Sheet JE-MB-D
MICROPHONE
BRIDGING
TRANSFORMER
The JE-MB-D is a 1: 1: 1 turns ratio microphone bridging transformer
with a single primary and two secondary windings, each surrounded
with its separate Faraday shield.
The JE-MB-D can be used to bridge a balanced microphone line,
which is terminated with a balanced preamplifier input, to feed second
and third balanced preamplifier i nputs.
The transformer, with separate Faraday shields for each winding,
isolates and rejects the common-mode noise caused by the noise
voltage difference between the chassis of the multiple mixers. Wi th
this type of isolation, the microphone shield can be connected through
to the chassis of one mixer but need not be connected through to the
second or third mixer chassis. Instead, the chassis (shields) of the second
and third mixers connect only to the Faraday shield of the appropriate
secondary. This eliminates the ground loops which would be caused if
the microphone shield were connected through to multiple mixers.
Phantom power can be provided by the mixer which terminates the
microphone directly.
The design is optimized for a source impedance at the primary of
150 ohms (microphone) and secondary loads of 1000 ohms (typical
microphone preamplifier input impedance). No resistors are used in
the usual application of a "mic-split box."
The primary winding is interleaved eqlfally with both secondary
windings for matched transfer characteristics to both secondaries and
to minimize variations in response with an unloaded secondary.
If cables with the shell connected to pin 1 (shield) are used in the
system, insulated mounting will be required for the connectors.
.
( HotH.iN(l
I I
''VlAHO
'" ""'
...
I OUTNf
I
M11 k0,111tfll1
INl'UI I
.
't ORt.
I
I
I
Rt0 1
V IO I
. I
I
I
GRA V
,;!,
I
I
I
I
- ❖ WHO
- ----- '
j 'I'll
I Q~AY I
I
.CRN I '
1,0lAfft)
a-nro,
•
I __ -
'
I •
••o
'
!,_ ___
---- - -' V IO
JE MALl
Q
___ n,11
BLU
"" '
GROUNO
l1Jf
I GltAV OLK '
I
sv.1,c.. u ,;] I
I
MIC sP!.11 80)( SCHEMATIC '- - - - ,- - - - - - _,
'\l'WHf
www.SteamPoweredRadio.Com
www.SteamPoweredRadio.Com
SOµS/di visio n
SµS/division
1 µS/division
A ll curves were generat ed by a Hewlett-Packard
9815A/ 9862A programmable ca lcu lat or/ plotter.
A ll calcu lations were either der ived from or verified
b y act ual measurements. V erified accuracies are on
t he order of one pen- line width.
DISTORTION
-;
□
-;
+ ll
r
I
ll
lJ
:I
z□
f'I
Q
Ill>, I -
•
I
Ill
-;
□
lJ
-;
-
z□
A
11
fT1
lJ
f'I
fT1
z
-;
V
- Y0 -30 -20 -1 0 0 + 10
.. www.SteamPoweredRadio.Com
I NPUT L E VEL <DE5V R E . 77S.V >
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
..
"
1
.
·t
- "
,,
.J ii'• 1,
,,,
! :, ' .,.,.. I.+
µ.,;;.. -'
., r-:-
.,r:
uit ·u
:,c-,- 1 _;_ IU,
J_
/ f'
j•l
+ .•
!:er:'
t• j,
ff
:c;... '
. . . .1--1
• r
...,..
L
:r..t·I .. r,, •
...,....
-•n m
~--
,-~ .. .., ·i+t. f l'. -~ 1
..
!
,_ r-, -:,-:,
~ l
. ~ F
···-
'r :z ~
... l
P l ... . .t . ,µ
J fl ~ . ....c . :-+LEIi' "' t:. -,J ~ ~~ -j-f-,- +i-· .. .., . L ll-
,f :1
- t'lT . >..;. ~ Mo- .J..
n . rt-· .. '
-......'t- .. ' - . -
I
II ~" / ~
1-, . ;.;. . ~ -♦- e-+--
• ., F .2 >. t •· 1-t , · ,.
' I: . "I
"'--- i-:-- - ';ll. l.T .t - n
f-· . •";:
i
I
2 -~
,. w f+ ..
..,,
..
~
I ~ t L c
__ '" I" ~
. . . f-- , .
J f' •_!:
- .. .. "'I - -- .. ... r,,. ..
l
_;,_
~t i
A
I: --+.. R, ='.[ 'ti:: CIH M ..c...-,
....
i"t:~ ~ : ,: • ! 7, ,f: -
I
□
V ~¥
J..>_
:_J
c:-
j ~. - ==:.;..":I:, -~- D ei~ c{_RE ~;,- 15: -L., --·I,J. - I
.•. I
1 I
. -r: .t. :
-·
I
--
w -=
:
t!i .... ,. ....
~
'
-~. ,: '
,;.;
¾
...
;
.. ,.. .J ~~ r : ;::--: I .. ..o...,.,..
ti :it ·rn 7.: !n' ·i: : . 'Hi"" 17~ r
7'
1! 1+ ,l. j( ,:
V
z ~-+ t'' ➔i-t- ?it l~ i!l l . . " :. .. ·!.i. l ~
I .
•t~E1
s•J't:!:t ,, ..... ...7 ~
; .....!... - ; I~
·•
,.:_
1.
:1:l
:;
L :, f ' I
:t
SECONDARYSOURCEIMPEDANCE
A
I:
I ........-"--1----l--~-+-+- l--t+-++1-+~-+;-.;.+.;..;.+.:+-+-+++-+-lH-++~....:+~+---++;..+:-+++--4-:+:+-+--I
□
V
w
V
Z '--__;_4-_µ~ ~ ..µ ...-......3--111-U.1::i:.+-,"--"'--4--+:-+-.f-;--4-.i...+:...;.\-.::J-,44-__;_+:-~...;....,,.;..+~.µ..,..+--1-'-l-+-+-I
a:
0
w
n.
I: ~ --1---1-.....J..~ - 1---- ' - - ~ ,l....+....j......-
>- - - ~-l---+--+-+-+
ct
a:
Cl
z
□ t - -...,......t----t-..-t--tr-·
V
w
lfl
1-
:::i
Q.
_ 4'"'++.4_ .,.,
l-
:::J ~ J.1.'-'--1+4~ i,........4-4,.-1-l--14--'-1-...J.h.,l,-4-;.j..-4-..,µ:.j.;..i.::.i,.+i-,;..;_;.i...;.;...i;.-+-1i.;..;....i_µ-1-1-~~~-4--1.1--1--1-+-1-41-1-~-i-...1-s
□
-6
w
> t---+t-----t-,--1-+-H--t+t--t-,,H'-!--t--rl-+-+++---t-1'-++++---+--+-+-1i--+-'-+-+-+-+-++_._l--l..-Y--+++-r+-!-,-1,-1-+i -7
I-
II
_J -a
w
~ tt-'--r.r.-:t;:-1-::-t::-r.t-::-"h!t--rH~-:-T"-:-:T":'.":t-l-:-t'"t-"1-::1'."""M,..;-~-:-:-r.-t-::-lt-::-?-t---t--'-t-t-ttt-~r:""-:i-t--+-'":~-t'-ttt-11 -9
-Ila
PHASE RESPONSE
A 1+---++"'-1"1"l,l!,_..f.4-l '-I.;..!
111
w
w t-r-77t:t:-:t;ml""'l-rt-+-t'+ tir-1"7r~-'Hl~++:+'-t'.""tt+t-:--.--tr+'-l-li':-'H"7t'.:+'il-H+~Hr-l..ui-r-i,.+;~~++-4
~
l!J
W .--...-, .i:=i::~~;..1
Cl
V H--~+,J-11-4'"1''¥-4'- M~l-t-'l-'-...,._..+"'"t.£.t--,H---¥::-f--+-H-+-,-....,-H~+"+r++--+,,-+.-1!-++l-'-~'-+-l-l-++--+'-+t-+,-l-+-I
w
> t-'-t-++'~~ itt+f+t.H~;-;t!;:;-+.:;1;:::t--+.::!;:::t:H.;'r-';l;:;f-;;;-;;:::--;r.=!.--+.--l~ ~;!::+-H+;+.-,-l--l..f½-++++-:+!j,!J44-H2JZIIZI
1-
II
_J
l+-H-++tt-.++-tt-'"-h+l
w
~ r +.t*-:rl~r±r-~t-H;+-:-+~~+-+:r+:.++1-++:++-~~':-tlr++-+-++H+--:-:-:-~~++µ+++++-12~
2lil
r 2rara 2K
FREQUENCY <HZ>
GENERAL CHARACTERISTICS PHYSICAL CHARACT ERISTICS
T urns Ratio Package
1: 1 : 1 (2 secondaries) Mu-metal can
Impedance R atio T erm ination
150/1 50/150 Wire leads
Primary Source Impedance Dimensions
150 ohms 1- 118" diameter, 1- 1/ 16" high
Secondary Load Impedances Mounting
1 K ohms (mic pre-amps) 2 holes. 0.7" center•to-center. self-tapping screws supplied
Secondary Load Resistors
None requi red TYPICAL PERFORMANCE
Secondary RC Networks
None req uired T otal H armonic D istortion (Bel ow Satura t ion)
Three Faraday Shields 0 .18% maximum @ 20Hz
Separate leads 0 . 10% maximum @ 30Hz
Magnetic Shield 0 .05% maximum@ 50Hz
30dB, separate case lead 0.005% @ 1 kHz
MaKi mum I nput L evel at 20Hz Input L evel@ 1% Saturation (dBv Re: 0 .775v)
+2dBv (Re: 0.775v) 0dBv@20Hz
+4dBv @30Hz
+ 10dBv @ 50Hz
Common-ModP. Voltage ( maxi mum)
> 200v peak
Common-Mode Rejection Ratio
> 85d8@ 1 kHz
> 65dB@ lOkHz
TYPICAL PERFORMANCE
Secondary L oads
One T wo
Voltage Gain - 0.9d8 - 1.4d8
Input Impedance @ lkHz 1040 ohms 575 ohms
@ 10kHz 1080 ohms 590 ohms
Secondary Source Impedance @ lkHz 260 ohms 225 o hms
0
@ 10kHz 300 ohms 270 ohms
Frequency Response @ 20Hz - 0.25dB - 0.25\JB
(Re : lkHz) @ 20kHz - 0.20dB - 0.16dB
(No resonance peak)
Bandwidth @ - 3d8 88kHz 100kHz
0
Phase Response @ 20kHz - 1s - 12"
Rise Time (10%-90%) 4.0µS 3.6µS
Overshoot < 1% < 1%
Mounting H o les
Clearance for # 4 screw
Lead H ol es
Use 0.35" hole to clear grommet
www.SteamPoweredRadio.Com
Data Sheet JE-MB-E
MICROPHONE
BRIDGING
TRANSFORMER
The JE-MB-E is a 1: 1: 1: 1 turns ratio microphone bridging trans•
forme r with a single primary and three secondary windings, each
surrounded with its separate Faraday shield.
The JE-MB-E can be used to bridge a balanced microphone line,
which is terminated with a balanced preamplifie r input, to feed three
additional balanced preamplifier inputs.
The transformer, with separate Faraday shields for each winding,
isolates and rejects the common-mode noise caused by the noise
voltage difference between the chassis of the multiple mixers. With
this type of isolation, the microphone shield can be connected through
to the chassis of one mixer but need not be connected through to the
additional mixer chassis. Inste ad, the chassis (shields) of the additional
mixers connect only to the Faraday shield of the appropriate secondary.
This eliminates the ground loops which would be caused if the micro-
phone shield were connected through to multi pie mixers.
Phantom power can be provided by the mixer which terminates the
microphone directly.
The design is optimized for a source impedance at the p rimary of
150 ohms (microphone) and secondary loads of 1000 ohms (typical
microphone preamplifier input impedance). No resistors are used in
the usual application of a "mic-split box."
The primary winding is interleaved equally with each secondary
winding for matched transfer characteristics to each secondary and to JE MB E
minimize variations in response with unloade d secondaries. ,---- -- -- - - --1 MAU
I
If cables with the shell connected to pin 1 (shield) are used in the I ORN
3
system, insulated mounting will be required for the connectors. !SULA I EU
OUTl'UT I
VH
1· 1
GHN
3
I • ISOU\lEO
OU TPUl 7
I
FEMALE I
1BHN 8LU
3
MICROPHONE
INPU T
• RE DIWIH
VI O
I ORNIWHT
I
• ISOLAHD
OUTPUT 3
I
GRAV
BLKIWHl
--- - - ------ I
WHl
MALE
O IHECl
OU TPUT
2
GROUND
CHASSIS Llf T 'HIIS Wl flE MAV BE HEO/V(L
SWITCH ES GRN/ WHT. OR BRNIWHT
50µ$/ division
5µ S/ division
1 µ$/ division
All curves were generated by a Hewlett-Packard
981 5A/ 9862A programmable ca lculator/ plotter.
A ll calculations were either derived from or verified
by actual measurements. Verified accuracies are on
the order of one pen-line width.
DISTORTION
·-
-
-t
D
-t
lJ
I. 111
r
•' I
lJ
;o
:I
D
-z
('I
l:;:i
1!11o I tn
-t
□
;o
-t
-
D
z
"'
1l
111
;o
('I
111
z
-t
V
- li'll!I I
- '-1121 -3121
INPUT
-2121 -1 121
LEVEL
IZI + 1121
<DBV RE . 77:..V>
+2121 +.3121
www.SteamPoweredRadio.Com
www.SteamPoweredRadio.Com
INPUT IMPEDANCE
F"REGIUENCY <HZ>
SECONDARYSOURCEIMPEDANCE
Ii l! g lS
A
I:
I
□
V
w
V
z
II
0
w ....L
n.
I:
w
V
I!
:J
□
lJ1
>-
a:
II
0
z
□
V
w
.
lJ1
.. 21Zl
F"REl'.ilUENCY < HZ>
www.SteamPoweredRadio.Com
FREQUENCY RESPONSE
- A
HI
0
V
...J
w
>
w
...J
I-
::I
a.
I-
::I
□
-6
w
>
I-
a: -a
...J
w
I!
PHASE RESPONSE
Ill
A
m
w
W l-,---'-l.l--,......l....J...-14--+-l-+-+-++'-~-'-'-'-+-l'-+-+-,-;...i...+......++!--'-"--'-4,--'+-f-+-++-+-+++++---+-+_.,.,..+-Nl-r-+,<:!,
- r+-l·• -s-121
I!
l!I
w
0
V I----J+.!.-4-+'~ ~+-=!~-H-~:.....+.::,..:-_+-.i--:4-..+4--1+!--~+-l-+.fr.~+::f"-++-l+-.JJ+~.:..\-H-l--++f4::!H-l 1111111
w
> 2111121
I-
a:
-
...J
w
I! 25"13
TYPICAL PERFORMANCE
Mounti ng Holes
Clearance for = 4 screw
Lead Holes
Use 0 .35" hole to clear grommel
www.SteamPoweredRadio.Com
Data Sheet JE-DB-D
DIRECT BOX
TRANSFORMER
PAO IN/OUT SWITCH JE•08·D
r·-----------------···••···--' 201<./lSO
(INSULATED BUSH1NGI
$WITCHCRAn N 111 LJ ' '
;·----i--•i--···1
(133K/1KI
2 2KO
T 02.Zuf l : : M IXER)
1
• _____ J' OUTPUT
JACK :
FILTER
SWITCH
~--- ,-·BLK
GND
SWITCH
SCHEMATIC DIAGRAM OF 1'VPICAL TRANSFORMER APPLICATION A GUITAR DI RECT BOX
(TRANSFORMER MAY ALSO BE MOUNTED INSIDE THE INSTRUMENT FOR A LOW- IMPEDANCE GUifAR)
w
Ill
a:
JE:-DlrD
I
.r
...
..,
•
....
-
R• = 22
:r
a.
2Q9<::/l~.
1 -~•
I( R• • 20 ~
t.l R I.. :: 1000 OHM t.l RL ,; ) 0;,0 OHM
>
I-
EG" ~ 0 C>SV <RE:. 77Sv-, ::
I-
c; r eit>BV <R£ ,77f!5.V "'>
-n
I[
.J
a:
.J
t.l t.l
It a: -.-!--+· "'"
..... 2K
J"'RE:ulUE:NCY <HZ)
.., .... ""
F"REtilUENCY <HZ> - -"
INPUT IMPEDANCE SECONDARY SOURCE IMPEDANCE
t I A
-
X:
:I
C
V
....
w
JE-D8-D V
z ,.,.
~ a:
21aK/'IS:0 0
:r
0
V R 1..::::: 10;,0 OHM "'a.
X: ,..,
"'z
V
a:
0
Ee;. = 0 OBY < RC. 77SV >
-- w
V
a: JE-D8-D I f• ,..,
"'
-
:I
a. 0
2;,iiutil
!:
-
Ill
Rs = '20 I' ..,
I-
:I
~
a. ' I
•
--
""" ►
a:
a:
0
z
0
E 0 • -~0 ~av <R£.77~V>
"'
-
V
w
Ill
.., _,
F"RE:QUENCY <HZ) "' - ... ...,
F'RE6lUENCY < HZ > "" -
,e
DISTORTION
All curves were generated by a Hewl ett-
Packard 9815A/9862A programmable ca l cu -
lator/plotter. Al 1 ca lculation s were
-t
0 e ith er derived from or verified by
-t
R• = actual measurements . Verified accura-
, .a ~
:t
cies are on the order of one pen-1 ine
2 0 1-iZ E
:I
width .
0
:30 >lZ z
"
5'0 HZ 0
a., Ill
-t
C
:0
-t
0
z
A
.,
I
..,.....---,-
KHZ l1
l'1
:0
~ "2
-t
l
""''--~--------~-~--~-~
- '10 - ~0
INPUT LEVEL <OSV RE.7 7 SV>
- 20 -tB ~ ♦ ID +20 +-3 0
- - PC Type - Pkg fl 1
PC Miniature - Pkg f/ 12
- JE-l 35K-D
JE- 150K- A
JE- 16- A
150
150
35K
SOK
150 600
-6
- 10
+8
1
1
l
l
l
2
1
l
1
1
l
1
30. 55
26 - 34
41 . 37 26
8
2
-
..
JC- 642 l : 9 turns ratio
www.SteamPoweredRadio.Com
20Hz Max Magne tic Far aday Unit Price *
Part Nur.iber Description Level I n Terr.i Pkg Shield Shield t'rice Schedule -
BRIDGING TRANSFORMERS
- - \.Jire leads - -
JE- 1 12- CF 1: l , 1: 2 +24 l 18 0 0 15 , 30 39
JE- 123-S 1: 1 , 1: 2 +27 1 4 0 0 17. 71 17
JE- 123- SCF 1 : 1, l : 2 +27 1 5 0 0 17. 71 17
JE- 123- SS 1: 1 , l : 2 +27 1 3 1 0 31-25 25
JE- 123- A 1: l , 1: 2, l : 3 +30 1 6 0 0 21. 94 16
JC- 123- ACF l : 1 , 1: 2, 1: 3 +30 l 7 0 0 21, 94 16
JE- 14S- T 1: 4 split +30 l 8 0 0 21 . 94 16
- www.SteamPoweredRadio.Com
20Hz Max Magne t ic Fa r aday Unit Price *
- Pa r t Nu□ber Descrip tion Level Out Term Pkg Shield Shield Pr ice Schedule
OUTPUT TRANSFORMCRS - Nickel Core - for highe r source impedance applications (600 ohns)
\Ji r e leads
JC- 123- SL 1: 1, 1: 2 +22 1 4 0 0 21 . 77 41
JE- 123- AL 1: 1, l : 2 , 1: 3 +24 l 7 0 0 27 - 42 40
JE- 1 l S- L 1 : 1, 1: 2 +26 1 7 0 0 27 . 42 40
JE- 11- T 1: 1 +22 1 19 0 0 33 - 22 42
TERMINATION
l - \Hre leads
2 Printed circuit pins
3 - Octal Plug- in
4 - Solder Terninals
PACKAGE L H
-
.
1 - 30 dB nu - metal can
2 - 60 dB mu-netal can
www.SteamPoweredRadio.Com
www.SteamPoweredRadio.Com
PRICE SCHEDULES
jenitQHE!fJJ1~fS?imers
.. 1617 NORTH FULLER AVENUE H OLLYWOOD, C ALIFO RNIA 9004 6 PHONE (213) 876 -0059
www.SteamPoweredRadio.Com
jen!tQHE
tr~J!~G
f~1:mers Price List
- Part Number Description
20Hz Max
Level In Term Pkg
Magnetic
Shield
Faraday
Shield
Unit
Price
--
Price*
Schedule
-
l l
JE - 34K- DX 3 4K - 21 l 13 2 l 34 . 66 27
JE- 44K- DX 40 4K -12 l 13 2 1 34 - 66 27
-
JE-7552 4K 150 +4 l 11 0 0 14-65 18
-
Part Number Description Level In Term Pkg Shield Shield Price Schedule
--
LINE INPUT TRANSFORMERS
BRIDGING TRANSFORMERS
+18
+18
3
3
15
15
2
2
1
1
35 , 41
35 , 41
33
33 -
JE- lOKB- A lOK 600 +16 l l l 1 24, 90 7
JE- lOKB- B 25K - 1500/375 +28 1 2 1 1 36 , 87 9
JE - l 5P- l 37 , 5K - 1500/375 +28 1 2 1 1 36, 87 9
OUTPUT TRANSFORMERS - Steel Core - for zer o ohm source i~pedance applications
- - \Jire leads - -
JE- 112- CF l : 1, 1: 2 +24 1 18 0 0 14,29 39
JE- 123- S l : 1, 1: 2 +27 1 4 0 0 16,55 17
JE- 123- SCF l : 1 , 1: 2 +27 1 5 0 0 16 , 55 17
JE- 123-SS l : 1 , 1: 2 +27 1 3 1 0 29. 2.0 25
JE - 123- A 1: 1, 1: 2, 1: 3 +30 1 6 0 0 20,50 16
JE - 123- ACF l : 1, 1: 2, l : 3 +30 l 7 0 0 20, 50 16
JE- 14S- T 1: 4 split +30 l 8 0 0 20 . 50 16
www.SteamPoweredRadio.Com
20Hz Max Magnetic Fa r aday Unit Price*
-
Part Number Description Level Ou t Term Pkg Shield Shield Price
--- Schedule
OUTPUT TRANSFORMERS - Nickel Core - for higher source impedance applications (600 ohms)
Wire leads
JE - 123- SL l: 1, 1: 2 +22 l 4 0 0 20. 33 41
JE - 123- AL 1: 1, 1: 2, 1: 3 +24 l 7 0 0 25 - 62 40
JE- 1 lS - L 1: 1, 1: 2 +26 1 7 0 0 25. 62 40
JE- 11- T l:1 +22 1 19 0 0 31.03 42
- - - - - - -- - - - - - - - - - -- -- - - -- --
TERMINATION
1 - Wire leads
2 - Printed circuit pins
3 - Octal Plug - in
PACKAGE L w H
- 1 - Mu - metal can
2
3
4
5
6
-
-
-
-
-
Mu - metal can
Mu- metal can
Uncased
Channel frame
Uncased
1- 1/8"
1- 5/16"
1- 5/8"
1-5/8"
1- 11/16"
1- 7/8"
diam .
diam .
diam .
1- 5/16"
1- 3/8"
1- 9/ 16"
1- 1/ 16"
1- 9/ 16"
1-3/4"
1- 1/8"
1- 1/8"
1- 1/4"
7 - Channel frame 1-31/32" 1- 21/32" 1- 1/4"
8 - Uncased 2- 5/8" 2- 3/16" 1- 1/4"
9 - Printed circuit channel frame - upright 1- 7/16" 1-1 /4 " l"
10 - Printed circuit bobbin -
low profile 1- 5/8" 1- 5/16" 1- 3/16"
11 - Miniature uncased 1/2" 7/16" 3/8"
12 Miniature mu- metal can with PC pins o. 73" o. 73" 1 . 1"
13 - Dual nested mu- metal cans 1- 5/ 16" diam . 1- 1/4"
14 - Pr inted circuit - mu- metal can 1. 9" 1 . 6" 1- 26"
15 - Octal Plug- in w/ mu- metal can L 4" daim . 1. 65 "
16 - Pr inted circuit bobbin - upright 1. 7" 1 . 3" 1 . 4"
17 - Pr inted circuit bobbin - low profile 1. 6" 1 . 3" 1 . 2"
18 - Channel frame 2. l " 1. 15" 1 . 2"
19 - Uncased L 75" 1. l " 0 . 76"
www.SteamPoweredRadio.Com
www.SteamPoweredRadio.Com
PRICE SCHEDULES
jen!~~HE!r~Hq!f~i~ers
1617 NORTH FULLE R AVENU E H O LLYWOO D , C AL I F O RNIA 90046
I PHON E (2 1 3) 876-0059
"