Professional Documents
Culture Documents
Number
2 CO2 3 2 3 - - - - - - - - 3
3 CO3 3 3 3 - - - - - - - - 3
4 CO4 3 2 - - - - - - - - - 3
5 CO5 3 - - - - - - - - - - 2
6 CO6 3 3 3 - - - - - - - - 3
Part - A
(20 x 1 = 20 Marks)
Instructions: 1) Answer ALL questions. 2) The duration for answering the part A is 30 minutes (this sheet
will be collected after 30 minutes). 3) Encircle the correct answer 4) * denotes more than one choice may
be correct
Q. No Question Marks BL CO PO PI Code
1 In IPV4 address, Class A uses _______ bits for net ID and _______ bits for 1 1 3 1 1.7.1
host ID
a) 8, 24 b)16, 16 c)15, 17 d)24, 8
2 How many possible addresses per network are there in a class C of 1 1 3 1 1.7.1
an IPv4 address?
a) 65536 b) 128 c) 256 d) 2097152
6 In IPv4 datagram header there are many fields and one of the field is 1 2 3 1 1.7.1
Time to Live -TTL. This field is used to ______
a) optimize throughput b) reduce delay
c) set priority for packets d) prevent looping
7 The block 224.0.0.0/4 has the ________. 1 2 3 1 1.7.1
a) Multicast Addresses b) loopback address
10 Slash Notation is also called as CIDR. CIDR stands for _______. 1 1 3 1 1.7.1
a) Classful inter-domain routing
b) Classless inter-domain routing
c) Classful intra-domain routing
d) Classless intra-domain routing
12 In _______ the signal levels are on one side of the time axis, either 1 1 4 1 1.7.1
above or below.
a) Unipolar b) Polar c) Bipolar d) Multilevel
14 In Binary ASK, the peak amplitude of one signal level is _________ and 1 1 4 1 1.7.1
the other is ________.
a) 0, same as the amplitude of the carrier frequency
b) same as the amplitude of the carrier frequency, 1
c) 1, same as the amplitude of the carrier frequency
d) same as the amplitude of the carrier frequency, 0
15 Calculate the value of the signal rate for the case “One data element 1 3 4 2 2.6.3
per one signal element” if the data rate is 1 Mbps and c = 1/2.
a) 500 Kbaud b) 1 Mbaud c) 250 Kbaud d) 375 Kbaud
18 If there are n signal sources of same data rate, then the TDM link has 1 2 4 1 1.7.1
_______ slots.
a) 2n b) n/2 c) n*2 d) n
19 The Polar Return to Zero scheme uses _______ voltage values. 1 1 4 1 1.7.1
a) 1 b) 2 c) 3 d) 4
Part – B
(2 x 5 = 10 Marks)
Instructions: Answer ALL questions
Q. No Question Marks BL CO PO PI Code
Part – C
(2 x 10 = 20 Marks)
Instructions: Answer ALL questions
Q. No Question Marks BL CO PO PI Code
23. A Given the Class C network of 204.15.5.0, subnet the 10 3 3 2 2.6.3
network in order to create the network in the figure
below, with the host requirements shown in table.
23. B Solve the below-given scenario using VLSM for the 10 3 3 2 2.6.3
network 192.168.10.0 and list out the addressing range of
all subnets in detail.
24. A Explain Unipolar NRZ, Polar NRZ and RZ encoding schemes 10 2 4 1 1.7.1
with suitable diagram.
Or