You are on page 1of 2

DAMAGE STABILITY ASSUMED DAMAGE EXTENT

OIL TANKERS AS PER MARPOL ANX. 1 REG 28


SIDE DAMAGE BOTTOM DAMAGE
0.3 L FROM F.P. ANY WHERE ELSE

1/3 L 2/3 OR 14.5 M WHICH 1/3 L 2/3 OR 14.5 M WHICH 1/3 L 2/3 OR 5 M WHICH EVER
LONGITUDINAL EVER LESS EVER LESS LESS

B/5 OR 11.5 M WHICH EVER B/6 OR 10 M WHICH EVER B/6 OR 5 M WHICH EVER
TRANSVERSE LESS LESS LESS

B/15 OR 6 M WHICH EVER B/15 OR 6 M WHICH EVER


VERTICAL ANYWHERE FROM KEEL LESS LESS

GAS TANKERS AS PER IGC CODE


SIDE DAMAGE BOTTOM DAMAGE
0.3 L FROM F.P. ANY WHERE ELSE
1/3 L 2/3 OR 14.5 M WHICH 1/3 L 2/3 OR 14.5 M WHICH 1/3 L 2/3 OR 5 M WHICH EVER
LONGITUDINAL EVER LESS EVER LESS LESS
B/5 OR 11.5 M WHICH EVER B/6 OR 10 M WHICH EVER B/6 OR 5 M WHICH EVER
TRANSVERSE LESS LESS LESS
B/15 OR 2 M WHICH EVER B/15 OR 2 M WHICH EVER
VERTICAL ANYWHERE FROM KEEL LESS LESS

GAS CARRIER DAMAGE STABILITY CRITERIAS


In any stage of flooding:

the final waterline, taking into account sinkage, heel and trim, shall be below the
lower edge of any opening through which progressive flooding or
1 downflooding may take place. Such openings shall include air pipes and
openings that are closed by means of weathertight doors or hatch covers
and may exclude those openings closed by means of watertight manhole
covers and watertight flush scuttles, small watertight cargo tank hatch
covers that maintain the high integrity of the deck, remotely operated
watertight sliding doors and sidescuttles of the non-opening type;

2 the maximum angle of heel due to unsymmetrical flooding shall not


exceed 30°; and

3 the righting lever curve shall have a minimum range of 20° beyond the
position of equilibrium in association with a maximum residual righting lever
of at least 0.1 m within the 20° range
4
the area under the curve within this range shall not be less than 0.0175 m-radians.
The 20° range may be measured from any angle commencing between the position of
equilibrium and the angle of 25° (or 30° if no deck immersion occurs).

5 Unprotected openings shall not be immersed within this range unless the space
concerned is assumed to be flooded. Within this range, the immersion of any
of the openings listed in 2.7.1.1 and other openings capable of being closed
weathertight may be permitted;
6 the emergency source of power shall be capable of operating

You might also like