Professional Documents
Culture Documents
Submitted by
The purpose of this lab project is to get familiar with upcoming challenges related
to design field and to gain knowledge about part modeling and their assembly the
software used for this task is Creo 7.0 all parts are modeled in software. After the
part modeling, assembly of angled crank shaft is done by using the assembly
command. it is very common component within vehicles, which is the main reason
behind choosing this as my CAD II project.
Angled crank mechanism
Angled crank mechanism is very useful part for power transmission. Sometimes we
transmit power in one direction but wants to get output power at an angle, similarly
angled screw drivers use the same phenomenon. It is like a bevel gear.
Parts of engine blower:
1. Blue pin
2. bracket
3. fastener
4. handle crank
5. handle shaft
6. red pin
7. spider hinge
8. yoke female
9. yoke male
3D Modeling of parts:
1) blue pin
2) bracket
3) Fastener
4) Crank handle
5) Crank shaft
6) Red pin
7) Spider hinge
8) Male yoke
Female yoke
ASSEMBLY