Professional Documents
Culture Documents
ASSIGNMENT # 01
SUBMITTED BY;
QANBAR ALI
SUBMITTED TO;
COURSE CODE;
3229
CLASS ;
MEEN 5B
REGISTRATION NUMBER;
MEEN201101038
OBJECTIVE
To demonstrate how the figure is establish on Autocad 2016.
ESTABLISHING PROCESS
Below are those steps which describe through which i establish this drawing on
autocad 2016.
First of all i draw a reference line of length 140mm.
After that i draw two circles of radius 15 and 21mm at the end point of
my reference line.
Then I take the center of the inner circle and draw a line in the upward
direction of 60mm
Then I take the reference line of 100 mm
At the end point of that line I draw two circles of radius 21 and 15mm
Then I take the center of the inner circle and draw a line in the downward
direction of 60mm
Also I take the reference line of 100 mm
At the end point of that line I draw two circles of radius 21 and 15mm
After that I draw the circle of radius 40mm
Then I use the center of that circle and draw a new circle of radius 32mm
For the third circle I use the center of second circle and draw the third
circle of radius 21
Now for the last circle I use the center of the third circle and draw the
fourth circle of radius 16
All these circles which are drawn at the center of my first refrence line of
140mm
After the draw of all the circles at center
Now I use the fillet command to make the curve between upper most
circles and the center circle of 40mm
Also with the use of fillet command I make a curve between the lower
circle and the center circle of 40mm
After this I use the center point of reference line of 140mm by use the
offset command I took a line on both side of center line of radius 3mm
Then I use the trim command and expulsion command to cut off the
circle to get desired drawing
Now at this point my drawing is almost complete but an important point
is left that is dimensioning
Now I draw all dimesions on drawing
All dimensions are in millimeters
Now my drawing is complete
DRAWING PICTURE
(A)
(B)