Professional Documents
Culture Documents
SUPPLIES:
• 11/0 seed beads (SB11)
• 8/0 seed beads (SB8)
• DiamonDuos - color 1 (DD1)
• DiamonDuos - color 2 (DD2)
• Jump rings
• Earring wires
• FireLine, about 2 yards
NOTE: The color 1 DiamonDuos are the main color and color 2 is the
one bead in the center of each earring.
TIP: Test the holes in the DiamonDuos before you start to check for plugged holes.
1. Pick up one DD1 through the bottom hole 4. Pick up one DD1 through the top hole from
going from right to left. Leave a tail long enough right to left. Step down and go through the
to weave in later. bottom hole of the same DD1.
3. Pick up one DD1 through the bottom hole. 7. Pick up one DD1 through the
from right to left. top hole from left to right.
8. Pick up one DD1 through the bottom hole 12. Pick up three SB11. Go down and through
from left to right. Step up and go through the top the top hole of the DD1 below and to the right in
hole of the same DD1. Tie a knot with the tail the middle row.
thread. Pull the thread and the beads snug but
not too tight.