Professional Documents
Culture Documents
Lec_02_Test__PV_Cells__PV_Modules
1) Select which of the following terms is used to define the use of power over a period of time
Power is equal to x
Energy is equal to x
3) Ohm's Law dictates the relationship between voltage, current and resistance
When you connect solar modules in series, your system will increase in
When you connect solar modules in parallel, your system will increase in
4) Calculate how many Amps would be flowing through a 0.5kΩ resistor that has a voltage of
12V
5) The current flowing through a 200Ω resistor is 0.325A. Calculate the voltage across the
resistor.
.
6) In the circuit below, assume that the module has a voltage of 48V, R1 = 350Ω and R2 =
7) A solar module has a nominal output of 6A and 36V. If 4 of these modules are connected in
parallel:
8) the output voltage of a modules that has a nominal output of 8.9A at 25V. If 6 of these
modules were connected in series is V
9) Assume that the four modules below are identical, each with an output of 6A at 34V.
11) If a customer uses the following appliances, how much energy would they have consumed?
( Currunt Source , Open Circuit Voltage , Shunt Resistance , Diode , Series Resistance )
13) Identify the appropriate answer for what each value on the curves represents, and also
what the red and blue curves represent.
Isc A
Vmp V.
Pmax W
Voc V
Imp A
IV Curve
Power Curve
14) Calculate the voltage and current produced by the array below?
typical commercial silicon-based cell, with the main parts of the cell exposed. Identify the parts
or sections of the silicon cell with the labels A to E above. Image
Link https://i.postimg.cc/0Qrz9sx5/Picture1.png
16) Match the solar cell technologies with the definitions below:
Made from silicon, but has many small crystals pointing in different directions
18) Based on the information below, calculate the maximum number of modules that can be
placed on the roof in the portrait orientation Considering the Shading Distances .
According to the mounting rail manufacturer, the edge zones are calculated by multiplying 0.2 x
A. Where
• L = 9.9 m
•W=6m
G Luck