Professional Documents
Culture Documents
MIDTERM EXAMINATION
First Semester, AY 2022- 2023
SR-Code
Name of Student
Instructions to Students
1. Answer FORTY FOUR (44) questions ILOs Questions Points
2. Start each question on a separate page 1 11 50
3. This paper is in THREE (3) section(s) only 2 34 50
NO. SECTIONS POINTS
1. Multiple Choices 30
2. Essay/Short Answer 70
3. Problem Solving
4 Others
TOTAL POINTS 100
Page 1 of 5
Leading Innovations, Transforming Lives, Building the Nation
Republic of the Philippines
BATANGAS STATE UNIVERSITY
The National Engineering University
Alangilan Campus
Golden Country Homes, Alangilan Batangas City, Batangas, Philippines 4200
Tel Nos.: (+63 43) 425-0139 local 2121 / 2221
E-mail Address: ceafa@g.batstate-u.edu.ph | Website Address: http://www.batstate-u.edu.ph
1.
a. Level control valve c. Chimney
b. Spreader d. Down comer
2.
a. Mist Eliminator c. Pressure relief Valve
b. Gas back pressure valve d. Diverter
3.
a. High GOR c. Low GOR
b. More gas- liquid interface d. Less Pipping
4.
a. Internal diameter c. Liquid capacity
b. Retention time d. Liquid settling section
5.
a. Alumina c. Molecular Sieve
b. Silica d. Glycol
6.
a. Acetic acid c. Nitrotoluene
b. Isoprene d. Sulfuric acid
7.
a. Diesel oil c. Crude oil
b. Pentane d. Gasoline
8.
a. Ethanol c. Ether
b. Benzene d. Naphtha
9.
a. Chloroform c. Chloroethanol
b. Acrolein d. Trichloroethylene
10.
a. Vapor pressure c. Temperature
b. Specific gravity d. Flash point
11.
a. Influent water c. Lubricants
b. Fire- fighting water d. Acids
12.
a. Carbon fiber c. Aramid
b. Steel d. Fiberglass
Page 2 of 5
Leading Innovations, Transforming Lives, Building the Nation
Republic of the Philippines
BATANGAS STATE UNIVERSITY
The National Engineering University
Alangilan Campus
Golden Country Homes, Alangilan Batangas City, Batangas, Philippines 4200
Tel Nos.: (+63 43) 425-0139 local 2121 / 2221
E-mail Address: ceafa@g.batstate-u.edu.ph | Website Address: http://www.batstate-u.edu.ph
21. The first-stage separator operating pressure is generally determined by the flowline pressure and
operating characteristics of the well. In situations in which the flowline pressure is less than 600 psi,
it is practical to let the first stage separator ride the line.
a. Statement 1 is true and Statement 2 is c. Statement 1 and 2 is true.
false.
b. Statement 1 is false and Statement 2 is d. Statement 1 and 2 is false.
true.
22. A two-stage separation requires one separator and a storage tank. While a three-stage separation
requires two separators and a storage tank.
a. Statement 1 is true and Statement 2 is c. Statement 1 and 2 is true.
false.
b. Statement 1 is false and Statement 2 is d. Statement 1 and 2 is false.
true.
Page 2 of 5
Leading Innovations, Transforming Lives, Building the Nation
Republic of the Philippines
BATANGAS STATE UNIVERSITY
The National Engineering University
Alangilan Campus
Golden Country Homes, Alangilan Batangas City, Batangas, Philippines 4200
Tel Nos.: (+63 43) 425-0139 local 2121 / 2221
E-mail Address: ceafa@g.batstate-u.edu.ph | Website Address: http://www.batstate-u.edu.ph
24. Natural gas's ability to contain water vapor decreases as the temperature is increased at constant
pressure. Excess water in the vapor state condenses and is removed from the system during the
cooling process.
a. Statement 1 is true and Statement 2 is c. Statement 1 and 2 is true.
false.
b. Statement 1 is false and Statement 2 is d. Statement 1 and 2 is false.
true.
25. The glycol circulating pump can be sized using the glycol circulation rate and the contactor's
maximum operating temperature. The lean glycol from the bottom of the contactor is used to power
the pump, while the rich glycol is pumped to the top of the contactor.
a. Statement 1 is true and Statement 2 is c. Statement 1 and 2 is true.
false.
b. Statement 1 is false and Statement 2 is d. Statement 1 and 2 is false.
true.
Prepared by:
Approved by:
Page 4 of 5
Leading Innovations, Transforming Lives, Building the Nation