Professional Documents
Culture Documents
By:
Instructions
Sequence Table Action required
1 A Record machine data in Table A
2 B Insert hammer flow specifications in Table B
3 Adjust PRV setting with flow meter
4 C Record flow meter at pressures listed in table in Table C.
5 D Record back pressure and relief pressures in table D
6 E Record operating pressure while hammer is running in Table E.
7 E Click on blue line and position on graph to crack point value measure in Table D.
8 E Click on red dash line and move to chart equal to operating pressure measured in Table D.
9 F Complete questionnaire in Table E
Table A:
Date: 23May03
Carrier: 345B PIN 4SS000788 SMU 4390 Correct setting:
Hammer H180s PIN 9PM00577 SMU 0
When flow curve intersects operating pressure
line within the allowable flow range of the hammer
Table B:
Hammer MIN - MAX
Flow spec 58 - 80
Table C: Pressure-Flow
Data D: Curve
Pressure Flow
psi gpm
1000 90
1200 85 100
1400 85
1600 85
1800 84
80 Maximum gpm = 88
Flow (gpm)