Professional Documents
Culture Documents
SCDM CFD Intro 2020R2 EN WS01.2
SCDM CFD Intro 2020R2 EN WS01.2
Modeler
Release 2020 R2
Make sure that the Length unit is set to mm in the SpaceClaim Options
• Switch to 3D mode
• Move the grid again until the end of the created line
• Draw a line starting from the end point of the first line with a length of 355.6 mm and
an angle of 90°
Write in 355.6
• Switch to 3D mode
• Create a rounded corner at the intersection of the two lines; set the radius to:
101.6 + 101.6/2 = 152.4 mm
Write in 152.4
Hit escape. Repeat the same procedure with the second end of the 1 3
Cylinder and the second line
2
Then with the third end
and the third line 3
1
- In 3D mode, move the created circle down through the cylinder’s axe for:
- 406.4 + (101.6 - 96.41) = 411.59 mm
Write in 411.59
3
4