● Good safety practice protects everyone ● Do not remove guards from machines or tools ● Pay attention to safety demonstration and ask if you need help ● Kepp floors clean from backpacks and debris ● Observe “satey zone” around machines. Only the operator and instructor are allowed in these zones - allow for a 6 ft distance between people ● Never sit on a piece of machinery ● Compressed air can be dangerous! Neer point it atyour eyes or ears ● Saftey glasses must be worn whenever you or another student is using a tool/machine ● Horseplay, messing around, goofing off is never allowed ● Have the instructor double-check your set-up ● Unplug tools before making adjustments ● Make sure the switch is the “off” position beforeplugging in any ower tool ● Unplug tools by pulling on the plug, not the cord ● Report damaged tools to the instructor at once! ● Tie long hair back! Long hair / loose clothing / jewelry can get caught in revolving machinery. Remove / tie back / tuck in. ● No gloves / headphones / baggy clothes ● Let the instructor know immediately if you get injured ● Watch what you are doing! Focus your attention on the task at hand ● Caution another student if you see the doing something dangerous. Let the instructor know too ● Sharp tools cut netter, require less effort, andare much safer! Let the instructor know if a tool is dull ● You are responsible for reporting any situation that could cause you to be a hazard to yourself or others ● You must pass the Saftey test AND recive instruction on each specific tool/machine before operating it