Professional Documents
Culture Documents
Cross Over Procedure: Do not put the machine into the Download Mode. Connect Cross Over Cable
(600T2252) between PWS and Network port on the Printer PWB. You must change the TCP/IP settings on
your laptop to match the printer settings.
- To perform this, click on START -> SETTINGS -> NETWORK CONNECTIONS, right-click on LOCAL AREA CONNECTION and select
“Properties”.
- Double Click on” Internet Protocol (TCP/IP)” (or click once and then click on properties).
- Select “Use the following IP Address” and enter a TCP/IP address for your laptop to use. Your address must be in the same range as the
printer, simply select one that is either one above or lower than the printer’s address. If the printer is 192.168.1.101, set your laptop to
192.168.1.102.
- Enter the same Subnet Mask as the printer. (no default Gateway)
Start the Firmware Download Tool: Double click on (found in C:\Download Tool)
Select Product
1.- On the License Agreement Screen click on 2.- Under Printer Model select your product.
the Agree(N) button. Under file name use the Browse button to
select the file.
Alain.Miron@xerox.com
Software Download Tool
VersaLink B70XX WC5325/35 WC7425/35 4110/4595
VersaLink C70XX WC5222/30 WC7328/45 4112/4127
Xerox C60/C70 WC118 WC7120/25 D95/110/125
Xerox C75/J75 WC123/128 WC7232/42 D136
Xerox 700/770 Xerox 550/570 DC240/260 Versant 80/2100
3.- Browse to the firmware file location (CD or 4.- Select the Firmware file, typically all Fuji
Hard Drive) and open the folder for your based controller firmware have a bin
machine configuration. Select Open. extension. Select Open.
7.- (Network upgrade only) When the Printer 7a.- If you press the
Specification screen opens, click on the Search(R) Version Info(V) button the
button. The device connected to the Cross Over machines actual Firmware
Cable will show. Mark the checkbox beside the levels will be shown.
printer discovered and select Next(N).
8.- The Upgrade in Progress screen will open 9.- When the transfer process is done, the
and the progression bar should start to machine will reboot and come up to Ready to
increase. The upgrade process should take Copy. The result window will open and show the
around 20 minutes. upgrade as completed. Click on the Finish button
to close the application.
Alain.Miron@xerox.com