Professional Documents
Culture Documents
: 0 0
INSP 09
REFERENCE
TOOLS REQUIRED
MATERIAL REQUIRED
G02219 TAPE, VINYL ADHESIVE, SCOTCH NO. 471, BRIGHT YELLOW, 1.5 IN (3.81 MM) WIDE 1
ACCOMPLISHMENT
NO. INSTRUCTION PERFORMED BY INSPECTED BY
A. Source(s) :
1. MP (Batik Air)
2. MP (Lion Air)
2 B. General
(1) Do this task every 4 weeks during Prolonged Parking in addition to these tasks:
BARCODE:
B789-10-INT-01-16-MLI
TASKCARD
WORK ORDER NO. A/C REG. A/C MSN. A/C Effectivity OPERATOR TASK CARD NO.
B789-10-INT-01-16-MLI
ACCOMPLISHMENT
NO. INSTRUCTION PERFORMED BY INSPECTED BY
3 WARNING: THE QUICK CHECK TABLE IS NOT A SUBSTITUTE FOR FOLLOWING THE
COMPLETE PROCEDURE WHICH CONTAINS WARNINGS, CAUTIONS, TASKS,
AND DETAILED INSTRUCTIONS. FAILURE TO FOLLOW THE COMPLETE
PROCEDURE CAN RESULT IN INJURIES TO PERSONNEL AND DAMAGE TO
THE AIRPLANE AND EQUIPMENT.
(2) The airplane prolonged parking preservation Quick Check table follows, and should not take
the place of the tasks in this task. It is for reference only and for a quick review of what is in
the task:
(a) The tables below are for a Quick Check to show what is necessary for the preservation to
an airplane. This data is in direct relationship with the tasks and subtasks within the task.
The table was created to help the mechanic understand quickly what is necessary to put
an airplane into a storage condition. The title of each table is the TASK TITLE for that
task.
Table 207/10-12-02-993-823
PRESERVATION PROCEDURES - QUICK CHECK
These procedures are to be done throughout the storage time.
Do these procedures at the same time:
- Service and Protection on 7 Day (1 Week) Cycles
- Service and Protection on 14 Day (2 Week) Cycles
Do this step:
ELECTRICAL/ELECTRONIC
- if installed, charge the emergency light batteries.
Do these steps:
EXTERNAL SURFACES (FUSELAGE, - check the covers on the pitot probes, static ports,
WING, HORIZONTAL AND VERTICAL temperature
STABILIZERS) probe, angle of attack sensor, and ice detector
- check the surfaces for corrosion or staining
- wash the airplane
- make sure all structural drain holes are open
- inspect tailcone compartment
- if the airplane is being stored for more than 60
days, check the
drain holes in the tape used to seal the fuselage
openings.
BARCODE:
B789-10-INT-01-16-MLI
TASKCARD
WORK ORDER NO. A/C REG. A/C MSN. A/C Effectivity OPERATOR TASK CARD NO.
B789-10-INT-01-16-MLI
ACCOMPLISHMENT
NO. INSTRUCTION PERFORMED BY INSPECTED BY
ENVIRONMENTAL CONTROL SYSTEM Do this step:
(ECS) - examine the equipment cooling overboard
exhaust valve port for the unwanted material.
MECH
4 C. Service and Protection
SUBTASK 10-12-02-620-079
(1) Do this task: Service and Protection on 7 Day (1 Week) Cycles, TASK 10-12-02-620-802.
MECH
5 SUBTASK 10-12-02-620-110
(2) Do this task: Service and Protection on 14 Day (2 Week) Cycles, TASK 10-12-02-620-803.
A/P
6 D. Electrical/Electronic
SUBTASK 10-12-02-620-096
(1) If it is installed, charge the emergency light batteries (TASK 33-51-06-610-802).
A/P
7 E. External Surfaces (Fuselage, Wing, Horizontal and Vertical Stabilizers)
SUBTASK 10-12-02-210-001
(1) Check the covers on the pitot probes, static ports, temperature probe, angle of attack sensor,
and ice detector.
A/P
8 SUBTASK 10-12-02-210-018
(2) If it is installed, inspect the mylar sheet covers on the outer windshields and control cabin
windows.
NOTE: For airplanes in storage for 60 days or longer that are not stored in a hangar.
NOTE: It is recommended to check the covers on the windshields and control cabin
windows more often if airplane is stored in wet/high humidity environment and
after rainy/stormy weather.
NOTE: : The mylar covers must be installed with no wrinkles in the tape or mylar,
no voids in the tape or mylar, no tears, punctures, holes, in the mylar or
tape.
(b) If soft cotton cloth, G50316, between the window and mylar sheet, G00111, is found
to be wet, replace it with new soft cotton cloth, G50316.
(c) Perform a general visual inspection of the moisture seal on the windshields.
A/P
10 SUBTASK 10-12-02-220-001
CAUTION: MAKE SURE THAT WATER DOES NOT GO IN TO THE PITOT AND STATIC
LINES. THIS COULD DAMAGE THE AIR DATA COMPUTER AND
INSTRUMENTS.
BARCODE:
B789-10-INT-01-16-MLI
TASKCARD
WORK ORDER NO. A/C REG. A/C MSN. A/C Effectivity OPERATOR TASK CARD NO.
B789-10-INT-01-16-MLI
ACCOMPLISHMENT
NO. INSTRUCTION PERFORMED BY INSPECTED BY
A/P
11 SUBTASK 10-12-02-210-003
(5) Make sure that all of the structural drain holes are open (TASK 51-41-11-200-801).
(a) If the airplane is being stored for more than 60 days, leave the screens that are installed
on the drain holes in place, unless they are clogged.
1) If the screen is clogged, put a new piece of screen material on the drain hole with
Scotch Brand No.471 tape, G02219
A/P
12 SUBTASK 10-12-02-210-014
(6) Inspect the tailcone compartment.
Number Name/Location
(b) Make sure that the drains in the tailcone are clear of unwanted material and water can
drain.
Number Name/Location
A/P
13 SUBTASK 10-12-02-210-005
(7) If the airplane is being stored for more than 60 days, check the drain holes in the tape
used to seal the doors and hatches.
SUBTASK 10-12-02-867-001
(1)If the airplane has not been moved to do engine runs, turn the wheels for a minimum of one
and one-third revolution.
NOTE: Wheel rotation can be done by lifting the wheels with an axle jack, putting the airplane
on jacks, or towing the airplane. If practical, rotate the wheel three or more turns to
redistribute bearing lubricant before establishing the new ground contact point.
A/P
15 G. Fire Protection
SUBTASK 10-12-02-212-001
(1) Do this task: Halon Fire Extinguishers - Inspection/Check, TASK 26-26-01-200-801.
A/P
16 SUBTASK 10-12-02-212-002
(2) Do this task: Water Fire Extinguishers - Inspection/Check, TASK 26-26-02-200-801.
MECH
17 H. Equipment/Furnishings
SUBTASK 10-12-02-620-018
(1) Do the preservation for the passenger compartment and flight compartment.
BARCODE:
B789-10-INT-01-16-MLI
TASKCARD
WORK ORDER NO. A/C REG. A/C MSN. A/C Effectivity OPERATOR TASK CARD NO.
B789-10-INT-01-16-MLI
ACCOMPLISHMENT
NO. INSTRUCTION PERFORMED BY INSPECTED BY
(a) If it is installed, make sure that the carpet is examined for moisture and mildew
(b) If it is installed, make sure that the seats are examined for moisture and mildew.
A/P
18 I. Flight Compartment
SUBTASK 10-12-02-200-009
(1) Examine the No. 2 openable window sill drain:
(a) Do this task: No. 2 Openable Window Sill and Frame Drain Inspection,
TASK 56-12-11-200-802.
A/P
19 J. Hydraulic System
SUBTASK 10-12-02-620-109
(1) Visually examine the following areas for evidence of leakage:
(a) Wheel wells (nose and main), wing front and rear spar areas, landing gear, 48 Section
(fwd and aft), rudder PCU area, and lower external surfaces of empennage, fuselage and
wings.
A/P
20 K. Environmental Control System (ECS)
SUBTASK 10-12-02-710-007
(1) Examine the equipment cooling overboard exhaust valve port for the unwanted material.
21 ---------------------END OF TASK---------------------
2.00
DATE (UTC) : ........................ TIME (UTC) : ........................ SIGNATURE : ........................ AUTHORIZATION NO. : ....................
BARCODE:
B789-10-INT-01-16-MLI