Professional Documents
Culture Documents
INSTALLATION MANUAL
Applied Machines: 362/282/222/350/250/200
MFP: 36 ppm/28 ppm/22 ppm/35 ppm/25 ppm/20 ppm
Product Code: A11U/A11V/A11W/4040/4041/4042
4551IXC003DA
3. Screw
3
4551IXC004DA
4. Modular Cable
*1
1
4040IXC006DA
4551IXC010DA
3. Remove the Rear Cover (thirteen screws).
5. Label *2
1 set
6. Installation
Manual
1 set
4980IXC019DA
area.
AM1-000206-003 4040-7185-03
E-1
4. Cut off the knockout cover of the Rear Left Cover 8. Reinstall the rear cover that has been removed in
with the appropriate tool such as nipper. step 3 (13 screws).
4551IXC501DA 4040IXC026DB
5. Install the PWB support to the position shown in 9. Reinstall the Upper Rear Cover that has been
the picture. removed in step 2.
Note:
When reinstalling the Upper Rear Cover, pass the
angle detecting lever into the hole in the cover.
Angle detecting lever
4551IXC502DB
CN4
CN3
4551IXC503DB
E-2
III. Affixing the Label IV. Specifying Settings for the Soft
Affix the label to the position shown below. Switches
Note:
Note:
• Place the proper label which corresponds to the
Conduct the specifying setting for the soft
area.
switches, when needed.
• Affix each label referring to the list below.
0: Make a calling from the selected line of port 1 or
Country Label 2 according to the status of operation and regis-
Singapore tration. (Auto selection is not allowed)
1: Make a calling from the available line of port 1
or 2 regardless of the status of operation and
registration. (Auto selection is allowed)
4040IXE213DA
*Default: 1
Australia
1. Plug the power cord into the power outlet and
turn on the machine.
2. Call the Tech. Rep. Mode to the screen.
4040IXE214DA
(For derails of how to call the Tech. Rep. Mode
screen, see the Service Manual)
South Africa
3. Touch “Soft Switch Settings.”
4. Touch “Mode Selection,” and then type in “006.”
5. Touch “Bit Selection,” and then use “←” and “→” to
move the cursor to bit 1.
4040IXE215DA
6. Set bit 1 to “0,” and then touch “Enter.”
China 7. Touch “Enter.”
8. Touch “Exit” on the Tech. Rep. Mode screen to go
back to the initial screen.
9. Turn OFF and ON the Main Power Switch.
4040IXE216DA
Note:
Korea Do not need to attach the label. When displayed the Tech. Rep. Mode screen, be
sure to turn off the main power switch after exiting
the Tech. Rep. Mode screen and wait for 10 sec-
onds or more before turning on.
4040IXE148DB
E-3