Professional Documents
Culture Documents
INSTALLATION MANUAL
Applied Machines: C554/C454/C364/C284/C224
COLOR MFP: 55 ppm/45 ppm/36 ppm/28 ppm/22 ppm
Product Code: A2XK/A4FJ/A161/A4FK/A4FM
3. Screw A
Note:
3 • If none of the later steps instruct you to use the
parts including screw and cover that you
9646 removed following the instructions described in
4. Screw B this manual, discard them.
• This manual provides the illustrations of the
3 accessory parts and machine that may be
slightly different in shape from yours. In that
9J08IXC075DA
case, instead of the illustrations, use the
5. Cord clamp appearance of your machine to follow the
installation procedure. This does not cause any
1
significant change or problem with the proce-
dure.
A0W4IXC019DA
6. Cable tie *
4551IXC007DB
7. Cushion *
A0W4IXC020DA
8. Authentication
label *
1
9. Installation
manual
1
set
4980IXC019DA
A0W4-9570-00
E-1
I. Installation procedures 4. Attach the supplied mounting plate.
(Three supplied screws A)
1. Remove the knockouts (at three places) from the
scanner right cover using nippers.
Knockout
A0W4IXC034DA
A0W4IXC031DA
5. Reattach the scanner right cover removed in
step 3. (Three screws)
2. Remove the caps. (Three places) 6. Insert tabs (at three places) on the working table
into the holes in the machine and slide the work-
ing table in the direction of the arrow.
A0W4IXC032DA
A0W4IXC033DA
A0W4IXC036DA
E-2
<When installing the key counter mount kit> 6. Remove the harness from the wire saddles (at
1. Remove the working table. (Three screws) two places).
2. Remove the three screws from the scanner right
cover.
A0W4IXC041DA
A0W4IXC040DA
A0W4IXC038DA
A0W4IXC042DA
E-3
10. Remove screws from the underside of the work- 14. Attach the mounting plate of the key counter
ing table, and remove the cover for the key mount kit to the working table.
counter harness. (Four screws) (Two screws removed in step 10)
Cover
A0W4IXC008DA A0W4IXC011DA
11. Run the harness through the hole on the working 15. Attach the socket to the mounting plate.
table as shown in the illustration below. (Two screws furnished with the key counter
mount kit)
A0W4IXC009DA
A0W4IXC012DA
A0W4IXC010DA
A0W4IXC013DB
E-4
17. Insert the socket harness into the edge cover (at
one place) and connect the socket connector to
the connector from the machine.
A0W4IXC015DA
A0W4IXC016DA
19. Attach the cover for the key counter harness that
was removed in step 10.
(Two screws removed in step 10)
Cover
A0W4IXC017DA
E-5