Professional Documents
Culture Documents
INSTALLATION MANUAL
Applied Machines: /
AD67-9600-00
2020. 9 Printed in China E-1
P/N: 1BP0836801
4. Accessory Parts 6. Removing Protective Tape and Packag-
No. Name Q’ty ing Materials
(1) Remove pieces of protective tape and packaging
1. User’s Guide 1 set
materials.
2. Installation Manual (this manual) 1
3. CD-ROM 1 set
E-2
(2) Open the right door. (8) Open the front door.
(3) Remove protective tape. (9) Remove the protective tape from the imaging
(4) Push the shafts in the direction of the arrows to unit.
remove the fixing brackets that fix the transfer
roller.
E-3
8. Installing the Toner Bottle 9. Starting the machine
Note: (1) Turn ON the main power switch of the left side of
Since a toner bottle is not supplied with the the main body.
machine, purchase one separately.
(1) Shake the toner bottle well about five times in the
vertical direction. Then, turn it over and repeat 10. Connecting the network cable
the same procedure.
(1) Connect the main body and networking equip-
Note:
ment (HUB) using the network cable.
The toner can cake in the toner bottle. Be sure to
perform this procedure. Note:
The following shows the recommended network
cables that correspond to each communication
speed.
• 10BaseT/100BaseTX: Category5
LED2 LED1
Network port
(2) Insert the toner bottle halfway with the tape side
up, and then slowly peel the tape off the bottle.
E-4
11. Network setting
Make the TCP/IP address setting for the network.
Note:
Consult the network administrator for the setting
value to be entered and make settings as
required.
(1) Press the [▲] or [▼] key to select “UTILITY” on
the display.
(2) Press the [Menu Select] key.
(3) Press the [▲] or [▼] key to select “ADMIN.
MANAGEMENT” on the display.
(4) Press the [Menu Select] key.
(5) Enter the administrator password, and then
press the [Menu Select] key.
(6) Press the [▲] or [▼] key to select “NETWORK
SETTING.”
(7) Press the [Menu Select] key.
(8) Press the [▲] or [▼] key to select “IP ADDRESS
SETTING.”
(9) Press the [Menu Select] key.
(10) Press the [▲] or [▼] key to select “SPECIFY”
on the display.
(11) Press the [Menu Select] key.
(12) Enter the IP address, and then press the [Menu
Select] key.
(13) Enter the subnet mask, and then press the
[Menu Select] key.
(14) Enter the gateway, and then press the [Menu
Select] key.
(15) Press the [Reset] key.
E-5