Professional Documents
Culture Documents
Tool, removing
Showing Selected Profile
Op nbr 926-004
1. Place the hydraulic breaker on the floor and make sure that the holes for the tool retaining pins can be accessed (over
the edge of the pallet).
NOTE!
Never use your fingers to check if the recesses on the work tool's shaft are aligned with the slots for the tool pin.
NOTE!
Always wear protective goggles when installing or removing the tool, since metal splinters may fly off when breaking
out the stopper pins.
2. Remove plugs.
Figure 1
Plugs, removing
1. Plugs
WARNING
The parts are hot, take appropriate safety precautions.
Figure 2
Plug and lock pin, removing
1. Plug
2. Lock pin
3. Punch
4. Hammer
Figure 3
Eye bolt, installing
1. Eye bolt
Figure 4
Lock pin and retaining pins, removing
1. Retaining pin
2. Plug
3. Lock pin
4. Punch
5. Hammer
Figure 5
Tool, removing
1. Hoist