For laminar flow in a round pipe, the actual velocity is equal to the average velocity at a distance of 0.707D from the centerline. For a fully developed laminar pipe flow, the expression for flow rate Q can be derived from F=ma as Q = πΔPR^4/8μL, where ΔP is the pressure drop over length L, R is the radius and μ is the dynamic viscosity. A 0.02-N ball rising to the surface of a swimming pool from the bottom will have a terminal velocity of 0.71 m/s.
For laminar flow in a round pipe, the actual velocity is equal to the average velocity at a distance of 0.707D from the centerline. For a fully developed laminar pipe flow, the expression for flow rate Q can be derived from F=ma as Q = πΔPR^4/8μL, where ΔP is the pressure drop over length L, R is the radius and μ is the dynamic viscosity. A 0.02-N ball rising to the surface of a swimming pool from the bottom will have a terminal velocity of 0.71 m/s.
For laminar flow in a round pipe, the actual velocity is equal to the average velocity at a distance of 0.707D from the centerline. For a fully developed laminar pipe flow, the expression for flow rate Q can be derived from F=ma as Q = πΔPR^4/8μL, where ΔP is the pressure drop over length L, R is the radius and μ is the dynamic viscosity. A 0.02-N ball rising to the surface of a swimming pool from the bottom will have a terminal velocity of 0.71 m/s.
flow is 0.1 m/s, what is the entrance length? What percentage change will be there in the entrance length is the flow velcoity is 2 m/s. Take kinematic viscosity of water as 10-6 m2/s 2. For a fully developed laminar pipe flow using F = ma, derive the expression for flow rate Q in terms of the pressure drop. 3. A 38.1-mm-diameter, 0.0245-N table tennis ball is released from the bottom of a swimming pool. With what velocity does it rise to the surface? Assume it has reached its terminal velocity. 4. For laminar flow in a round pipe of diameter D, at what distancefrom the centerline is the actual velocity equal to the average velocity? 5. Derive an expression for Volumetric flow in Pipes as a function of pressure drop using Dimensional Analysis 6. Water, assumed incompressible, flows steadily through the round pipe in Fig. 1. The entrance velocity is constant, u = U_0, and the exit velocity approximates turbulent flow, u = u_max 〖(1 - r/R)〗^(1/7). Determine the ratio U_0 /u_max for this flow. 7. A shaft having a diameter of 50 mm rotates centrally in a journal bearing having a diameter of 50 mm and length 100 mm. The annular spacing between the shaft and the bearing is filled with oil having viscosity of 1 Poise. Determine the power absorbed in the bearing when the speed of rotation if 60 rpm. 8. A ball weighing 0.02-N and diameter 5 cm is released from the bottom of a swimming pool. With what velocity does it rise to the surface? Assume it has reached its terminal velocity. 9. For a fully developed laminar pipe flow using F = ma, derive the expression for flow rate Q in terms of the pressure drop. 10. A laminar flow takes place in a pipe of diameter 200 mm. The maximum velocity is 1.5 m/s. Find the mean velocity and the radius at which this occurs. Also calculate the velocity at 4 cm distance from the wall of the pipe. 11. A venturimeter is a carefully designed constriction whose pressure difference is a measure of the flow rate in a pipe. Derive an expression for the flow rate Q. 12. For laminar flow in a round pipe of diameter D, at what distance from the centerline is the actual velocity equal to the average velocity? Derive the necessary equations.