You are on page 1of 6

EXERCISCE 1:

At first I choose the line from the drawing group from the home tab. After
that I entered my first points A (50, 50) and press Enter. Specify next point B
or [Undo]: Type 55, 50 and press ENTER. Specify next point C or [Undo]:
Type 55, 52 and press ENTER. Specify next point D or [Close Undo]: Type 59,
52 and press ENTER. Specify next point E or [Close Undo]: Type 59, 54 and
press ENTER. Specify next point F or [Close Undo]: Type 55, 54 and press
ENTER. Specify next point G or [Close Undo]: Type 55, 56 and press ENTER.
Specify next point H or [Close Undo]: Type 59, 56 and press ENTER. Specify
next point I or [Close Undo]: Type 59, 61 and press ENTER. Specify next
point J or [Close Undo]: Type 50, 61 and press ENTER. Specify next point K
or [Close Undo]: Type 50, 59 and press ENTER. Specify next point L or [Close
Undo]: Type 48, 59 and press ENTER. Specify next point M or [Close Undo]:
Type 48, 57 and press ENTER. Specify next point N or [Close Undo]: Type 50,
57 and press ENTER. Specify next point O or [Close Undo]: Type 50, 55 and
press ENTER. Specify next point P or [Close Undo]: Type 52, 55 and press
ENTER. Specify next point Q or [Close Undo]: Type 52, 51 and press ENTER.
Specify next point R or [Close Undo]: Type 50, 51 and press ENTER. Then
select the close option. Note that the entire figure was drawn keeping
ortho-mode, grid mode and snap mode on.

EXERCISCE 2:

In this drawing first choose the line option from the Drawing group from the
home tab. entered the first point 0, 0 and press Enter. Then choose the circle
option from the drawing group and choose the centre and draw two circles of
R 15 and φ16 note that two circle are on the same line and are identical to
each other, then choose the line option from the drawing group draw a
horizontal line from the first point towards the rightwards of 100 below the
circles cancel the line option. Then draw a line of 25 over the both of the circle
choose the end points of both the 25 lines and draw a vertical line upwards of
40. Then choose the arc option from the drawing group select the endpoints of
the arcs and drew three arcs choose cancel and completed the remaining
drawing and then entered the dimensions of the drawing than close it.
EXERCISCE 3:

In this drawing first choose the line option and specified the first points and
press enter. After that moved the cursor horizontal right wards entered the
line length 50 and press enter, after that move the cursor vertically upwards
typed in the line length 20 and press enter. After that moved the cursor
horizontally right wards enter line length 100 press enter, moved the cursor
vertically downwards enter 20 and press enter. After that moved the cursor
towards horizontally right entered 50 and press enter. Moved the cursor
upwards vertically and entered 50 and press enter. Now draw to line of 50
lengths on the both sides of the base which was created choose the end
point of the lines and draw an arc of radius 80. After that select the circle
option and draw a circle of diameter 60. After that close the diagram. Note
that the entire figure was drawn keeping ortho-mode, grid mode and snap
mode on.
EXERCISCE 4:

In this drawing first choose the line option after that specified the first the first
points and then press enter, after that move the cursor towards horizontal
rightwards direction enter the line length 90 and press enter. Move the cursor
vertically upwards draw the line of length 30 press enter as the dynamic input
and ortho mode are on we make the next line at an angle of <45, the length of
the line is entered 50 and press enter. After that draw a vertical line in upward
direction of length 5o then move the cursor horizontally left wards and draw a
line of length 40 after that move cursor vertically downwards and draw a line
of 50, after that choose the cancel option and from the first point of the first
line made a line vertically upwards of about 30 length, then move the cursor
horizontally rightwards and draw the line of length 50 choose the endpoints of
the line and join them the angle between them will be <135. Then close the
diagram. Note that the entire figure was drawn keeping ortho-mode, grid
mode and snap mode on.
EXERCISCE 5:

You might also like