Professional Documents
Culture Documents
1 SAFETY HELMET
1.2 Specification
Helmet shall be compatible with other ancillary equipment such as earmuffs, welder's shields, face
shield, Miners Cap Lamp etc.
Suspension
Shall be “Nape Type” or Ratchet Type”.
Chin Strap
15 mm width and 55 cm long with buckle for adjustability.
Shell
Hard & smoothly finished HDPE material.
Colour To be used by
WHITE Staff
Sub – Contractor and their
BLUE
Supervisor
YELLOW Workmen
RED Electricians
2.2 Webbing
The webbing shall be made of Nylon
D-ring / Textile loop shall be available for Fall Arrestor arrangement
2.3 Buckles
Buckles shall be of friction type and no slip type design.
2.5 Lanyard
Lanyard shall be of 12mm polypropylene rope and of length not more than 2 m.
The ends shall be spliced and covered with transparent sleeve & the curved portion protected with
thimble.
The hook shall be non separable from the lanyard.
It shall be of double lanyard
2.6 Hook
Hooks shall be of self-closing type. The hooks should not disengage if the pressure is exerted
accidentally on the tongue or latch.
The opening in the hook shall be minimum 18 mm.
Hooks shall be of any one of the following types
Scaffold Hook
5 SAFETY SHOES
6 WARNING TAPE