Professional Documents
Culture Documents
DE1MRVEA
DE1MRVEA
Operating Instructions
Measuring Point
Step Action Measuring Terminal
+ GND
1)
The adjustment of amplification can be made via the cali-
bration switch S4 ( Cal ). This easier procedure, however,
does neither checks the sensor function nor the correct
attachment.
Function of S4 see technical information.
HAEHNE Elektronische Messgeräte GmbH · Heinrich-Hertz-Str. 29 · D-40699 Erkrath Germany · Telefon 0211/9 25 91-0 · Fax 0211/9 25 91-20
http://www.haehne.de Email: info@haehne.de
MRV140 HAEHNE
Measuring Point
Step Action Measuring Terminal
+ GND
8 Remove weight.
2)
The optimum adjustment of GainC and t is dependent on machine and material. For serial machines, in most cases, it is
sufficient to determine these potentiometer positions once and always use them for adjustment.
3)
This procedure can be used only for thyristor drive amplifiers which have a differential input for the web tension signal. For
inputs referred to ground the sensor signal connections shall be exchanged (terminals 1 and 2 with 4 and 5).