Professional Documents
Culture Documents
Sign in
Explore
HP Customer Shop
Support Support
- Knowledge Base Sign in
Support Home Products Software and Drivers Diagnostics Contact Us Business Support
My HP Account
HP Z600 Workstation
HP Z800 Workstation
Questions/Symptoms
Power-On Self-Test (POST) fails
Beeps
Cause
Answer/Solution
Use the Diagnostic LED Code and Beep Code to isolate the failure.
NOTE: Workstation beeps are emitted from the chassis speaker. The flashing lights and beeps repeat for five cycles. After
five cycles, only the flashing lights repeat.
The Diagnostic LED blinks red 2 times and the system beeps 2 times (once per second), then a 2–second pause follows:
2) Open the access panel, and press the workstation power button.
https://support.hp.com/gb-en/document/c03599666 1/4
2022. 10. 24. 8:47 HP Z400/Z600/Z800 Workstation - Diagnostic LED Codes | HP® Customer Support
4) Verify that the processor heat sink fan spins. If it does not spin, ensure that the fan cable is plugged into the system
board connector. Ensure that the heat sink is properly seated. Need
help?
5) Replace the processor heat sink.
The Diagnostic LED blinks red 3 times and the system beeps 3 times (once per second), then a 2-second pause follows:
The Diagnostic LED blinks red 4 times and the system beeps 4 times (once per second), then a 2-second pause follows:
1) Open the access panel, and ensure that the necessary power supply cables are connected to the system board.
2) Locate a faulty device by removing all devices, and then reinstalling one at a time until the workstation fails:
- Disconnect AC power.
- Z400: Remove all internal power supply cables from the system board.
- Z600 & Z800: Remove the Power Supply from the chassis
- Plug in AC power.
If the power supply fan spins, and the LED illuminates, then the power supply is good. Replace the system board.
If the power supply fan does not spin, or the LED does not illuminate, then replace the power supply.
The Diagnostic LED blinks red 5 times and the system beeps 5 times (once per second), then a 2-second pause follows:
3) Replace the memory modules one at a time to find the faulty module.
The Diagnostic LED blinks red 7 times and the system beeps 7 times (once per second), then a 2-second pause follows:
This indicates system board failure (ROM detected a failure before video).
The Diagnostic LED blinks red 8 times and the system beeps 8 times (once per second), then a 2-second pause follows:
This indicates an invalid system ROM based on bad checksum and entering Failsafe (Boot Block) recovery mode.
The Diagnostic LED blinks red 9 times and the system beeps 9 times (once per second), then a 2-second pause follows:
This indicates that the system is turned on, but is unable to boot.
https://support.hp.com/gb-en/document/c03599666 3/4
2022. 10. 24. 8:47 HP Z400/Z600/Z800 Workstation - Diagnostic LED Codes | HP® Customer Support
Try one of our automated tools Ask a question on our HP Get in touch with one of our
or diagnostics Support Community page support agents Need
help?
Country/Region:
United Kingdom
About Us
Ways to buy
Support
HP Partners
Stay Connected
Recalls | Product recycling | Accessibility | Modern Slavery Act Statement | HP UK Gender Pay Gap Report | Privacy |
Use of cookies | Personal data rights | Terms of use | Consumer legal guarantee | Company details |
Limited warranty statement
https://support.hp.com/gb-en/document/c03599666 4/4