Dust Collector Assembly

Related to case 04487704

Dust collector group BH00024205-B
Refer to:
Hyd schematics used BI00044493-D
Electric schematics used BG01496487-F
Important locations on rig Dust Collector
Dust Collector manifold

Drain line in
mast pedestal

RC Module inside
Hydraulic Cabinet
 RC Controller located inside Hydraulic Cabinet

Hydraulic
Cabinet
You have it already mounted so we will not be going into it. Consider removing the hose support if hose doesn’t reach the deck
dust duct
Locations on rig - Drain line Hyd Motor
Drain manifold Side A
Connect the A port
side of the Hyd
Motor to the drain View from the
manifold. The route middle of the rig
of the hose is looking to the rear
highlighted in yellow side of the rig

Drain Hose from

motor side A to
drain manifold
Locations on Schematics - Drain line To drain selector
manifold

Refer to schematics and

notice that D13 from A
port side of Hyd. Motor
goes to the selector
manifold drain through
D10 line.

BI00044493-D SH2 D7

BI00044493-D SH1 Q9
Locations on rig - Pressure line Hyd Motor
Side V
Connect the port 4
from the dust
collector valve to the View from the
V port side of the middle of the rig
hyd. Motor. looking to the rear
side of the rig

Dust collector
valve
Locations on Schematics - Pressure line
D13 line should be
connect to drain line
now. You need to
disconnect it form drain
manifold and plug it
into the V hyd motor
port side

BI00044493-D SH1 L10

Electrical
connections The one that turns on/off the
dust collector system is the
DCS signal.
Consider that all connections
related to the dust collector The other (DCF1 ~ 6 or DCF1 ~
option are linked to the RC 9, depending on what type of
module. This RC module is in the dust collector you’ve
Hydraulic cabinet near the mounted) pointed are for the
Hydraulic tank (right/cabin side auto cleaning process when
of the rig). each filter is energized
separately. For these you can
use the electric timer if
available on the dust collector
you’ve mounted.

BG01496487-F SH4 D9