Professional Documents
Culture Documents
PDF M13-2viewer
PDF M13-2viewer
2. what are halogen bulbs made of? halogen gas and iodine or
bromine tungsten filament
7. what is the cycle range of the flash of a stobe? 40-100cycles per min
12. what are the colours of the nav lights and port-red-left
there position? starboard-green-right
tail-white
14. what are the visible angles of the nav lights? left right- 0-110 degrees
tail- centre and 70 degrees
each way
1 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
15. why is ac used on nav lights in the air? not to influence flux valves
16. what is the flash rate of stobe lights? 60-70 cycles per min
17. what is the power supply of a strobe light? 28vdc or 115Vac (trans-
formed to 450V)
18. what is the frequency of the rotating beam 40-45rpm which equals
anti collision light? 80-90 flashes per minute
20. why shouldnt landing lights be used on the no cooling from airflow
ground?
21. what is the watt of a landing light and taxi 600w landing
light? 250w taxi
22. why should cockpit lights be dimmed when reduce heat build up and
working in the cockpit? extend life of the lamps
25. where are cockpit warning and indication battery bus or dc bus
light power supplys from?
26. how do type one and type two warning and type 1- power to trigger
indicator lights differ? type 2 -earth to trigger
2 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
27. what are the 3 modes for the emergency off- de energised
lights and what do they do? on- lights on
armed- turned off but will
turn on if power failure
32. what are the load sharing buttons of electrical Airbus galley
power? Boeing utility
34. if the generator control unit is in auto when when the voltage and/or
would it bring up a fault? frequency is incorrect
35. what does galley shed mean on the ecam one generator offline and
display? (power distribution) galley load turned off to
shed the load of a single
generator
3 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
38. what is required if the ac if they have more split source breaker (splits
than one external power source? the bus tie into 2 parts)
40. what is the time for break power transfer? 10th of a second (could
damage sensitive equip-
ment)
41. what is the time for no power transfer? and 1/5 of a second but have to
what need to be done to carry it out? be synced
42. how is the ac essential feed turned on? automatically for ac bus 1
and manually by the pilot
for ac bus 2
44. what other than a battery can be used to pow- air driven generator(driving
er emergency bus bar? a constant speed motor)
46. what does the contactors require to control Current flow (large device)
the device?
47.
4 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
What does the breakers require to control the A current pulse (this is then
device? held by a magnet) small de-
vice
48. what are the advantages of cbs over fuses? reset quickly
used as on off switches
(isolation)
51. what are the markers of cbs (colours)? Green- monitored by ecam
Orange - to identify to pilot
to cancel nuisance warn-
ings
Red - Safety clip to prevent
been closed or reset
Grey- to mark during main-
tenance activities
p pole pairs
n input speed rpm
f frequency
55. what are the main parts of a brushless gener- GCU (voltage regulator)
ator? excitor generator
rotating rectifier
main generator
5 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
56. what are the types of generator cooling? oil cooling more efficient
and smaller
57. what are the line voltage and line neutral volt- line to line-200
age of a generator? line to neutral-115
58. what causes the static solid state inverter to the beat generator
have the correct frequency?
59. what are the operation of the constant speed in idle- overdrive
generator and how long can they be in the between low and high
range? speed- constant speed dri-
ve (short period of time)
63. what is the normal temp of the oil in constant 120 degrees C
speed drive generator ?
64. what is the rise temp of a constant speed difference between in and
drive and what is the difference? out of the oil and difference
between 20 degrees C
65. what is the oil temp for a constant speed drive 185 degrees C
fault?
6 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
68. what are the 4 main parts to a constant speed clutch
drive disconnect system? worm and gear
solenoid
reset mechanism
69. how do you know an idg has been discon- IDG disconnect
nect? Volts and frequency reduc-
tion
70. what is the disconnect push button for the 3 seconds in 60 seconds
constant speed drive restriction?
73. what regulation functions does the GCU pro- Frequency at the generator
vide? from IDG (permanant mag-
nets)
Voltage at the ac bus (115v
at bus but 120V at the gen)
80. what are the gcu protection distribution fail- Over load
ures? Open phase
differential protection
90. what are the wiring of the TRU? One delta and two y wind-
ings
92. what are the voltage range of a TRU? 28Vdc standard (27-30v)
93. what are the max amps from a TRU? 200amp contiuous
1000Amp 1 second
94. what are the two pretections for a TRU? low current (under 2amps)
high temp (caused by over-
load or short circuit)
99. what are the 2 charging methods?and voltage voltage charging- 28v slow
limits? trickle charge
current charging- 28V to
36V quick charge
100. what is the other use for the battery charger? to power the battery bus
(constant voltage charge)
in an emergency
101. what protection is for thermal runaway and bi metallic strip discon-
what temperature is it stopped at for a bat- nects power to battery
tery? charger at 60 degrees C
102.
9 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
what are the two parameters of ground power correct voltage
available light to come on? correct frequency
correct phase
103. when ground power is applied what trips off Power source interlock
it when a generator online automatically?
104. what is the function of the ground service bus to power ground service
and what precautions are required? bus for vaccums and lights
on
no precautions are re-
quired as normal ac power
is not powered
105. what does boeing use for ground services? Battery by battery charger
for AC
110. what are the two types of fusalage construc- truss type
tion? monocoque type
10 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
112. What is a monocoque fuselage? one that uses bulk-
heads, stringers (running
the length of the fuse-
lage), and formers (per-
pendicular to the stringers)
of various shapes/sizes to
support a stretched or
"stressed" skin
114. aircraft are made in sections what are the uk- manufacturers joint
joint numbers? usa-production break
116. what are the body station and what is the from nose to tail
body station of the nose? BS 90
117. what are buttock lines and what is the 0 line? from centre line to left and
right of the body
centre of ac is 0
118. what are body water lines and where is 0 line? from floor to roof of fuse-
lage
0 is below ground
119. what are the normal bonding test not exceed? 0.003ohm
11 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
700- undercarriage
800- doors
122. what are the second number of airbus zones? odd left and even right
123. what are the 2 types of lightening strike dam- direct damage- surface
age? burns (2 or more points)
indirect damage-damage
to electrical systems
127. what is the best flap type for best lift increase Fowler flap
95%?
129. what assist with rudder movement and eleva- rudder- horn balance
tor movement with help from airflow? elevator- insert hinge
balance tab- less mechan-
ical force.
135. what happens at mach crit? (trim) Mach tuck nose down
(trimmed nose up)
136. what helps with mach tuck? elevator lock out (reduces
shock under rear stabiliser)
138. what are the config warnings? flaps not in take off range
stabilisers not in take off
range
spoilers not in take off
range
141. what are the main information required for the attitude
electrical flight control system? airspeed
accelerations
13 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
angle of attack
flight/ground status
143. what are the limits of G for flight controls? 2.5g and -1g
144. what are the limits of roll for flight controls? 67 degrees (33 degrees
with no input)
145. who has priority of the flight control system? who ever press the button
147. what is the warning in direct law? use manual pitch trim on
pfd
151. what is the time delay between fault and fire? 15seconds
152. when will the fire light not be illuminated after if the fire is out
a fire?
153.
14 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
what conditions are the fire detectors in an always dual continuous
engine? loop
154. what does the fire switch do? isolate everything to the
engine
155. what is the difference between apu and en- apu is self contained and
gine fire protection? auto shuts down
own fire bottle
157. other than engines and apu where else are brakes
over heat detectors? hot air ducts
160. what are the max bend and minimum radius? 3.2mm bend
25.4mm minimum radius
15 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
162. what is halon 1301 pressurised with ? nitrogen
163. how much explosive powder in a squib? and 400mg and class C
what class of explosive class?
165. what colour is the disc indicator if the fire amber disc
bottles have been manually discharged?
166. What does the flow limiter do on the fire bot- limit flow for 180mins to
tle? suppress fire
169. when is High Pressure bleed air used? when engine at low speed
170. what is fan air used for? Bleed air cooling (200de-
grees)
173. what are the functions of a bleed air valve? shut off valve
pressure regulation
check valve
over temp control
reverse flow
16 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
174. what is the normal pressure of pneumatic? 45psi
175. what position would the cross feed valve be closed unless only one en-
in? gine available
178. how often does the air recycle? every 3-5 mins
179. what temp does the pack deliver to the the lowest inputted temp
zones? figures
180. what sort of valves are mainly used on air butterfly type
con/pneumatic?
182. what happens if you have a turbine runway turbine over speed, open
and what do you do have to do to the ram air ram air to slow the turbine
? (air con pack down
183. what is a fan in a ram air duct used for? used to suck in air on the
ground
186. what does the jet pump do? take water from the water
separater and put it on to
the heat exchangers to add
cooling
17 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
187. how do you know ice is formed on the water differential pressure
separator of the lp air park?
188. what determines the flow for the pack? the amount of people on
the ac (on the controller)
189. what is the difference between the cockpit air cockpit air isn't recycled
and cargo air?
190. what is the temp demand from the pack deter- the lowest desired temp
mined by?
191. what are the three failure conditions of the pack controller failure- alt
pack? controller
compressor overheat-
pack valves reduce flow
bypass failure- ram air
doors open/anti ice valves
takes over
192. what are the sensors on the air ducts? over heat
over pressure
194. what is the rate of climb of the cabin pres- 500ft per min positive
sure? 300ft per min negative
195. what happens at 10000ft cabin altitude? crew alert and put crew on
oxygen mask
196. what happens at 14000ft cabin altitude? auto release of cabin oxy
masks
197. what happens at 15000ft cabin altitude? auto outflow valves closed
198.
18 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
what is a safety precautions of cabin pres- in ward and outward safety
sure? valves
open at 8.5psi
199. what are the difference between internal and internal follows climb rate
external flight mode (pressurisation)? external goes to 8000ft re-
gardless of altitude for pas-
senger comfort
200. what happens on landing to the pressurisa- they switch between prima-
tion controllers? ry and standby(confirms
serviceability)
203. what are body gear or centre gear used for? distribute the weight
205. what principle does the side strut use to pre- over centre
vent retraction on the ground?
206. what land would you get if you had to much hydraulic hard
nitrogen in a strut and too much hydraulic gas soft
fluid?
207. what takes the main bearing of the undercar- spherical bearing
riage?
208. what does the torsion link damper do? dampers nose wheel shim-
mey
19 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
210. what is the up-lock actuator for? to maintain the up-lock
locked
211. how do the upper and lower bearing work in Upper bearing-inner
the strut? aligned with outer
Upper bearing-outer
aligned with inner
214. what speed does the nose wheel steering be- 60kts
come useless and the rudder used to turn?
216. what prevents main wheel steering tyre castored truck beam
scrubbing? rotating truck beam
single axis
217. what does the safety valve in an undercar- prevents lower of gear at
riage system? high speeds
220. what is the build up of the rubber of a tyre? ply layering- radial
221. what are the types of hydroplaning? viscous (thin film layer)
dynamic (flooded runway)
reverted rubber hydroplan-
20 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
ing (locked tyre causes
steam and melts tyre)
223. What are small chevron cuts on a tyre formed grooved runway
from?
225. how many pistons has a brake pack got? 7 pistons normal
7 pistons alternative
227. what is the general idea of 1mm of wear for 23-30 landings
number of landing?
230. what keeps the parking brake in a mechanical the pawl lock
system engaged?
232. what is touch down protection within the no brakes applied until
brake system? wow is triggered
233. what is the application of the brakes in auto 1 second (2-5seconds for a
braking? pilot)
234. what does a thermo couple do within a brake convert heat to dc voltage
pack?
21 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
235. what is the rate of deceleration of the auto 3 metres per sec squared
brake system?
237. what are the types of fuel and what are the Jet A1 - freeze 47 and flash
flash points and freezing point? 38
Jet A- freeze 40 and flash
38
Jet B- freeze 60 and flash
20
JP 5- freeze 65 and flash
48
238. what colour does the fuel look with water in cloudy/milky
it?
239. what are the ribs in the wings used for (fuel)? fuel movement damping
240. where are fuel boost pumps located and in the collector to prevent
why? having a dry pump
241. what are used for fuel panels to prevents knit aluminium gasket
sparks between panel?
242. what is the gauze for on fuel vent holes? flame arrestor
243. how many days does it take to over wing fill 2 days
a 747?
244. which the only method of refuelling with the automatic mode
cockpit control panel?
245. what are the power supplys for the fuel pan- apu, gpu, batt
el?
252. what are used to jettison the fuel to prevent a anti-corona nozzles
mist?
259. what door is the dolls on and what is it for? it shows flow
left door
23 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
12-15mins (aircraft to get
to breathable altitude with-
in 10mins)
261. what are the 3 modes of the oxygen regula- normal-mix of oxy and cab-
tor? in air
100% oxy
emergency forced air
264. how many anti ice switches?leading edge/en- one for leading edge
gines individual per engine
265. when do drain mast get turned on for anti ice? as soon as power is on
266. how long can the anti ice system be turned 30secs
on, on the ground?
271. what colour are mineral and synthetic hy- red -mineral
draulic fluid? violet-synthetic
272.
24 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
what are the back rings made of in a hydraulic teflon back up ring (normal
system? o rings made of rubber)
273. what are the two types of functions of the o dynamic- on a moving part
rings? static-dont move
274. what is the name of the pumps used in hy- electric pump -demand
draulic systems? pump
engine driven pump
275. how bigger is the size of the reservoir com- 2-2.5 times
pared to the required amount of fluid for the
hydraulic system?
281. what is on an air driven hydraulic pump? reduction speed gear box
282. what is the safety device for the rat made off? wood
25 / 26
M13 part 2
Study online at https://quizlet.com/_5sngh5
what does a high temp in the hydraulic return
lines indicate?
286. where is the heat exchanger of the hydraulic through the fuel tank
pump located?
287. what colour are hydraulic pipes? blue yellow and spots
289. what is the bog pump power supply? high power 3 phase
290. what is the time for the infa red faucet(mixer 3-15seconds
tap)?
26 / 26