Professional Documents
Culture Documents
D2
TP1 BROWN
1N5062
R1 C1
D1 TP1 TP3
1MEG (RN55) 2.2uF MANGANIN TP3 YELLOW TP3 TP23
TP5 1 2 YELLOW
TP15
Q1 1N4960 TP24
TOP
IRFBG30/TO MANGANIN TP12 RED TP37 RED
D2
CMPD400
TP2
YEL TP7
D1 MANGANIN BLACK/SHIEL
1N4744 R*A SHIELDED
YELLOW
TP8
MANGANIN TP4
D7
1N5622
D8
IN5622
TOP MANGANIN
TECHNICAL MANUAL MANGANIN
MANGANIN
TP19
TP20
TP21
U1-PIN6
U13-PIN6
DITHERING CIRCUIT JUMPER
.NOT USED IN 8135
APPLICATION
&
MANGANIN
PRESSURE PCB
TP24 * 8138-PCB-168
MANGANIN
8138-16850P
SCH. 380S27A0
TP25 *
MANGANIN 8135-PCB7-168
8135-16850P
SCH. 350S16A8
Date:
Job #: Sales Order #:
Tool P/N: Tool S/N:
Inspector #: Pass/Fail:
VIBRATION TEST
Source Present:
TEST PROCEDURE
Apply 85 ± 0.5 Vdc to Upper Center Contact with Respect to Mass and Measure with a DMM.
Measurement made at the Bottom contact should be made across a 5 K
DMM or with a Simpson 260 without a Load resistor.
Tool Current: mA (40 - 55)
Voltage at the Bottom Contact: Vdc (0.0 volts, measured across a 5 K ohm resistor
from Bottom contact to mass.)
GR Pulse Height at the Top of the Tool: Vp (-7 - -13)
Pulse Width at the Top of the Tool: µsec (32 - 38)
CCL Signal: Vpp.
5 of 6
Subject: P117 - Baker Atlas 1-11/16” 350F Perforators 735XB and 763XA Rev. F
Note: Sources must be more than 25ft. from the tool to measure the background counting rate.
Apply -200 VDC to the Top Center Contact with Reference to Mass and Measure:
Tool Current: mA
Voltage at the Bottom Contact: Vdc
Apply operating voltage to the top of the tool and increase until the tool switches.
Use a Fluke Model 87 Multimeter, or better, set to the Diode Testing Function. Measure from the
Top Contact to the Bottom Contact.
(+) Lead on the Top Contact and (-) Lead to Mass: Kohms (20 – 150)
(Allow time for capacitor to charge)
(-) Lead on the Top Contact and (+) Lead to Mass: Megohms
(No less than 20Megohms)
Inspector: Date:
6 of 6