Professional Documents
Culture Documents
Faculty of Engineering & the Buit Environment Question Paper Cover Page
DEPARTMENT: & GEOMATICS
CIVIL ENGINEERING
QUALIFICATION: DIPLOMAIN GEOMATICS
Sem1
ASSESSMENT TYPE: Year 2022 Sem2 X
E.G. MID-TERM TEST
or FIRST TEST
MID-TERM TEST
KHBABALOLA
EXAMINER:
MODERATOR UM OKON
(INTERNAL):
INSTRUCTIONSTO CANDIDATES
DO NOT TURN THE PAGE before the startingtime
Answer ALL the questions
Answer questions in sequence
open-book assessment.
Indicate if the assessment is a closed or
used
questions. Pencils may be
Only pens with permanent ink may be used when answering
in instances where diagrams and or sketches are required
cover)
QUESTION 1Multiple Choice and Short Answer Question 20 Marks
a. Coordinate display
b. Control Bar
. Control Centre
Answer:
a. Prompt Area
b. Control Bar
c. Control Centre
d. Drawing Area
e. Personal
Answer:
at tu
display function in AllyCAD ead
iv. Explain the coordinate disply honth
neu t e (dancf-e 1h peu
n t daav inj dha my
wru,
t Scra ta nyeLend l T
Answer:
bttm urdinuAr m XYZ
dipls tta
drawing settings
V. Briefly explain how to
set up your
emd cic en dh u t utt
bur 9u v suttyr
tom u M s u c ua4u pep
Juwniy S u h r
n
Sialy ox i disploy Cewiaids Sysu
Answer:
Sut t e
Scau. on h Sume d'aliy thux 3Jaenul Lalp
Oi , available md rlul hn
a. True
b. False
Answer:
The following are the categories displayed while using the options available in the Angular
Vi
dimensian, except
a. Drawing
b.Running
. Free
d.Chained
Answer
vili How many options are available in linear dimension?
a Three
Six
Two
d. Four
Answer
function in AllyCAD.
Six options are available to execute a hatch
True
b. False
Answer: A
Name the two Toolkit functions in AllyCAD applicable to a surveyor
Answer:
a. Six
b. Three
c. Four
d. Two
Answer
A
the AllyCAD Survey Toolkit
Name the categorisation oftools
in Gnl v
shue hunul,
heitacwnnd, e ckesnica4, Suv,
Answer:
Mhax 2markr
SuHionnd plon
QUESTION2 10MARKS
a) Using the given file named exercise file 1, insert the CsV data into AllyCAD
b) Use the Add Point function in AllyCAD to add the following coordinates into the working area of
AllyCAD
c)Using the coordinates in question 2, perform the join coordinates function operation.
QUESTION 3 20 MARKS
a Given a set of coordinates, plot the traverse line using the Traverse function in AllyCAD. See the
c)Using a Tache Shots function in AllyCAD, plot the spot height points at an interval of 10m along
PBLA S51 to PBLA 552 usinga Horizontal angle of 225.48.40. Also, plot at an interval of 10m
along PBLA 551 to PBLS 558 using 338.10,.20 as the horizontal distance. See attached fle named