Professional Documents
Culture Documents
Installation Procedure
PIP
Table 1
-
202 1085
3 3
Required Tools
01:
Tool Part Number Part Description Qty
/ 0 7 253
5 / 0
KE :08- 3
4
A - Breather Tool 1
N 0
NOTICE
©2 R 608 3:00
023
Keep all parts clean from contaminants.
1
Cat
Contaminants may cause rapid wear and shortened component
life.
erp
illa
rI nc.
https://sis2.cat.com/#/print-preview/service/%257B%2522formattedPublicationDate%2522%253A%25222014%252F07%252F22%2522%252C%… 1/5
02/07/2023, 22:54 SIS 2.0
Illustration 1 g01339595
Breather tool
1. To install the breather body, Tooling (A) must be used. The tool should be fabricated from
3.1 mm (1/8 inch) steel stock. The dimensions for the tool are given in Illustration 1. All
dimensions are shown in millimeters.
https://sis2.cat.com/#/print-preview/service/%257B%2522formattedPublicationDate%2522%253A%25222014%252F07%252F22%2522%252C%… 2/5
02/07/2023, 22:54 SIS 2.0
Illustration 2 g01339597
https://sis2.cat.com/#/print-preview/service/%257B%2522formattedPublicationDate%2522%253A%25222014%252F07%252F22%2522%252C%… 3/5
02/07/2023, 22:54 SIS 2.0
Illustration 3 g03704554
Note: Illustration 3 shows the later type of crankcase breather cover that is installed in the valve
mechanism cover. The later type of crankcase breather cover is not serviceable.
2. Ensure that all components of the crankcase breather are clean and free from damage. Replace
any components that are damaged.
3. Lubricate a new O-ring seal (9) with clean engine oil. Install the O-ring seal to the adapter plate
(8).
5. Install washers (7) and bolts (6) to adapter plate (8). Tighten the bolts to a torque of 4.4 N·m
(38 lb in).
6. Lubricate a new O-ring seal (5) with clean engine oil. Install the O-ring seal to the bottom of
breather body (4).
7. Use Tooling (A) in order to screw breather body (4) into adapter plate (8). Tighten the breather
body to a torque of 8 N·m (71 lb in).
9. Lubricate a new O-ring seal (3) with clean engine oil. Install the O-ring seal to the top of
breather body (4).
Note: Ensure that the outlet of the cover is in the correct position in order to align with hose (12)
for the breather.
Illustration 4 g01339688
11. Install clamps (11) to hose (12).
12. Connect hose (12) to cover (1) and to tube (13). Tighten the clamps.
PIP-10853253
2023/07/03
01:54:02-03:00
i02786799
© 2023 Caterpillar Inc.
https://sis2.cat.com/#/print-preview/service/%257B%2522formattedPublicationDate%2522%253A%25222014%252F07%252F22%2522%252C%… 5/5