You are on page 1of 62

■ BODY PANELS LOCATION INDEX

id091000802600

id091000802600

ac5uuw00008886

© 2018 Mazda Motor Corporation.


Shroud upper member
1
(See SHROUD UPPER MEMBER REMOVAL/INSTALLATION.)

Set plate
2
(See SET PLATE REMOVAL/INSTALLATION.)

Shroud panel
3
(See SHROUD PANEL REMOVAL/INSTALLATION.)

Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.)
4
(See FRONT BUMPER DISASSEMBLY/ASSEMBLY.)

Seal board upper


5
(See SEAL BOARD UPPER REMOVAL/INSTALLATION.)

Hood
(See HOOD REMOVAL/INSTALLATION.)
6 (See HOOD DISASSEMBLY/ASSEMBLY.)

(See HOOD ADJUSTMENT.)

Cowl panel
7
(See COWL PANEL REMOVAL/INSTALLATION.)

Fuel-filler lid
(See FUEL-FILLER LID REMOVAL/INSTALLATION.)
8
(See FUEL-FILLER LID ADJUSTMENT.)

Front fender insulator No.1


9
(See FRONT FENDER INSULATOR REMOVAL/INSTALLATION.)

Front over fender


10
(See FRONT OVER FENDER REMOVAL/INSTALLATION.)

© 2018 Mazda Motor Corporation.


Front fender panel
(See FRONT FENDER PANEL REMOVAL/INSTALLATION.)
11
(See FRONT FENDER STAY REMOVAL/INSTALLATION.)

Front fender insulator No.2


12
(See FRONT FENDER INSULATOR REMOVAL/INSTALLATION.)

Front bumper slider


13
(See BUMPER SLIDER REMOVAL/INSTALLATION.)

Front bumper reinforcement


14
(See FRONT BUMPER REINFORCEMENT REMOVAL/INSTALLATION.)

Energy-absorbing form
15
(See ENERGY-ABSORBING FORM REMOVAL/INSTALLATION.)

Seal plate
16
(See SEAL PLATE REMOVAL/INSTALLATION.)

Bumper stiffener lower


17
(See BUMPER STIFFENER LOWER REMOVAL/INSTALLATION.)

Rear over fender


18
(See REAR OVER FENDER REMOVAL/INSTALLATION.)

Rear bumper slider


19
(See BUMPER SLIDER REMOVAL/INSTALLATION.)

Rear bumper
(See REAR BUMPER REMOVAL/INSTALLATION.)
20
(See REAR BUMPER DISASSEMBLY/ASSEMBLY.)

Rear bumper reinforcement


21
(See REAR BUMPER REINFORCEMENT REMOVAL/INSTALLATION.)

© 2018 Mazda Motor Corporation.


■ BUMPER SLIDER REMOVAL/INSTALLATION
id091000822500

id091000822500

Front Bumper Slider

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the seal board upper. (See SEAL BOARD UPPER REMOVAL/INSTALLATION.)

3.Remove the front bumper. (See FRONT BUMPER REMOVAL/INSTALLATION.)

4.Remove the screws.

ac5uuw00008897

5.Disengage the pins and hook, remove the front bumper slider.

6.Install in the reverse order of removal.

Rear Bumper Slider

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

© 2018 Mazda Motor Corporation.


(1)Rear combination light (See REAR COMBINATION LIGHT REMOVAL/INSTALLATION.)
(2)Rear splash shield (See SPLASH SHIELD REMOVAL/INSTALLATION.) (3)Rear bumper (See
REAR BUMPER REMOVAL/INSTALLATION.)

3.Remove the screws.

ac5uuw00008898

4.Remove the nut.

5.Disengage the pins and hook, remove the rear bumper slider.

6.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ BUMPER STIFFENER LOWER REMOVAL/INSTALLATION
id091000888900

id091000888900

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Seal board upper (See SEAL BOARD UPPER REMOVAL/INSTALLATION.) (2)Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.) (3)Front under cover No.1 (See FRONT
UNDER COVER No.1 REMOVAL/INSTALLATION.) (4)Charge air cooler (SKYACTIV-D 2.2) (See
CHARGE AIR COOLER REMOVAL/INSTALLATION [SKYACTIV-D 2.2].) (5)Active air shutter (with
active air shutter) (See ACTIVE AIR SHUTTER REMOVAL/INSTALLATION.)

3.Remove the seal board upper. (See SEAL BOARD UPPER REMOVAL/INSTALLATION.)

4.Remove the front bumper. (See FRONT BUMPER REMOVAL/INSTALLATION.)

5.Remove the bolts.

ac5uuw00008908

6.Move the bumper stiffener lower in the direction of arrows (1), (2) and remove the hooks.

© 2018 Mazda Motor Corporation.


ac5uuw00008909

7.Remove the bumper stiffener lower.

8.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ COWL PANEL REMOVAL/INSTALLATION
id091000802000

id091000802000

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Windshield wiper arm and blade (See WINDSHIELD WIPER ARM AND BLADE
REMOVAL/INSTALLATION.) (2)Cowl grille (See COWL GRILLE REMOVAL/INSTALLATION.)
(3)Windshield wiper motor and link (See WINDSHIELD WIPER MOTOR AND LINK
REMOVAL/INSTALLATION.) (4)Keyless beeper (with advanced keyless entry system) (See
KEYLESS BEEPER REMOVAL/INSTALLATION.)

3.Disconnect the wiper de-icer connector. (with wiper de-icer) (See WINDSHIELD REMOVAL.) (See
WINDSHIELD INSTALLATION.)

ac5uuw00009395

4.Remove the wiring harness clips.

5.Remove the bolts.

© 2018 Mazda Motor Corporation.


ac5uuw00008885

6.Remove the cowl panel.

7.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ ENERGY-ABSORBING FORM REMOVAL/INSTALLATION
id091000888800

id091000888800

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Seal board upper (See SEAL BOARD UPPER REMOVAL/INSTALLATION.) (2)Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.) (3)Set plate (See SET PLATE
REMOVAL/INSTALLATION.)

3.Insert the flathead screwdriver shown in the figure, push the fasteners from back side of front bumper
reinforcement.

ac5uuw00008907

4.Pull the energy-absorbing form in the direction of arrow (2) shown in the figure while detaching guides.

5.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ FRONT BUMPER DISASSEMBLY/ASSEMBLY
id091000800400

id091000800400

1.Remove the front fog lights. (with front fog lights) (See FRONT FOG LIGHT
REMOVAL/INSTALLATION.)

2.Remove the radiator grille. (See RADIATOR GRILLE REMOVAL/INSTALLATION.)

3.Disassemble in the order indicated in the table.

© 2018 Mazda Motor Corporation.


ac5uuw00008867

© 2018 Mazda Motor Corporation.


Front fog light cover (with front fog light)
1
Hole cover (without front fog lights)

Front fog light cover garnish (with front fog lights)


2
Hole cover garnish (without front fog lights)

3 Front bumper bracket

4 Towing hook cover

5 Front bumper face

4.Assemble in the reverse order of disassembly.

© 2018 Mazda Motor Corporation.


■ FRONT BUMPER REINFORCEMENT REMOVAL/INSTALLATION
id091000800600

id091000800600

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Seal board upper (See SEAL BOARD UPPER REMOVAL/INSTALLATION.) (2)Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.) (3)Set plate (See SET PLATE
REMOVAL/INSTALLATION.) (4)Energy-absorbing form (See ENERGY-ABSORBING FORM
REMOVAL/INSTALLATION.) (5)Front under cover No.1 (See FRONT UNDER COVER No.1
REMOVAL/INSTALLATION.) (6)Bumper stiffener lower (See BUMPER STIFFENER LOWER
REMOVAL/INSTALLATION.) (7)Charge air cooler (SKYACTIV-D 2.2) (See CHARGE AIR COOLER
REMOVAL/INSTALLATION [SKYACTIV-D 2.2].) (8)Active air shutter (with active air shutter) (See
ACTIVE AIR SHUTTER REMOVAL/INSTALLATION.)

Caution

• Because the shroud panel is installed to the bumper reinforcement, support the shroud panel using
a jack before removing the bumper reinforcement so as not to apply excessive force to the shroud
panel.

3.Support the shroud panel using a jack.

© 2018 Mazda Motor Corporation.


ac5uuw00006854

Warning

• Removing the front bumper reinforcement without supporting it could cause the front bumper
reinforcement to fall and cause serious injury. Always perform the procedure with at least another
person to prevent the front bumper reinforcement from falling.

4.Remove bolts A and B.

© 2018 Mazda Motor Corporation.


ac5uuw00008868

5.Remove the front bumper reinforcement.

6.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ FRONT BUMPER REMOVAL/INSTALLATION
id091000800300

id091000800300

1.Affix the protective tape to the position shown in the figure to prevent scratches and damage.

ac5uuw00005157

2.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

3.Remove the seal board upper. (See SEAL BOARD UPPER REMOVAL/INSTALLATION.)

4.Remove the fasteners.

ac5uuw00008866

© 2018 Mazda Motor Corporation.


5.Pull the front over fender in the direction of the arrow shown in the figure and disengage the clips.

ac5uuw00009577

6.Remove the bolt and fasteners.

ac5uuw00005160

7.Remove the screws and fasteners.

© 2018 Mazda Motor Corporation.


ac5uuw00005161

8.Slightly bend back the front under cover No.1 and remove the fasteners.

ac5uuw00005162

9.Remove the screws and fasteners.

© 2018 Mazda Motor Corporation.


ac5uuw00005163

10.Pull the rear end of the front bumper in the direction of the arrow shown in the figure and detach the
front bumper from the front bumper slider while removing the tabs.

Caution

• Carefully remove the front bumper from the front bumper slider. If the front bumper is removed from
the front bumper slider with excessive force, the front bumper hooks may be damaged because the
front bumper and the front bumper slider are engaged firmly.

• Detach the front bumper hooks from the front bumper slider using two people, one person supports
the front bumper. If the front bumper hooks are detached from the front bumper without supporting
the front bumper, it may fall off and be damaged.

© 2018 Mazda Motor Corporation.


ac5uuw00005164

11.Pull the front bumper in the direction of the arrows shown in the figure and pull out the locator pin.

ac5uuw00005165

12.Disconnect the connectors.

Warning

• After removing the front bumper, secure the front over fender and front mudguard with tape to
prevent the front over fender from being damaged and to prevent injury.

© 2018 Mazda Motor Corporation.


ac5uuw00005166

13.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ FRONT FENDER INSULATOR REMOVAL/INSTALLATION
id091000804000

id091000804000

Front Fender Insulator No.1

1.Remove the front over fender. (See FRONT OVER FENDER REMOVAL/INSTALLATION.)

2.Remove the front mudguard. (See MUDGUARD REMOVAL/INSTALLATION.)

3.Remove the front fender insulator No.1.

ac5uuw00008895

4.Install in the reverse order of removal.

Front Fender Insulator No.2

1.Remove the front over fender. (See FRONT OVER FENDER REMOVAL/INSTALLATION.)

2.Remove the front mudguard. (See MUDGUARD REMOVAL/INSTALLATION.)

3.Move the front fender insulator No.2 in the direction of the arrows and remove it.

© 2018 Mazda Motor Corporation.


ac5uuw00008896

4.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ FRONT FENDER PANEL REMOVAL/INSTALLATION
id091000801000

id091000801000

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Seal board upper (See SEAL BOARD UPPER REMOVAL/INSTALLATION.) (2)Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.) (3)Front combination light (See FRONT
COMBINATION LIGHT REMOVAL/INSTALLATION.) (4)Front bumper slider (See BUMPER
SLIDER REMOVAL/INSTALLATION.) (5)Front over fender (See FRONT OVER FENDER
REMOVAL/INSTALLATION.) (6)Edge rubber

3.Remove the fastener.

ac5uuw00008876

4.Open the front door.

5.Remove the fastener.

© 2018 Mazda Motor Corporation.


ac5uuw00008877

6.Remove the A-pillar garnish.

7.Remove the fastener.

ac5uuw00006858

8.Remove the tabs.

9.Remove the front fender cover in the direction of the arrow shown in the figure.

© 2018 Mazda Motor Corporation.


ac5uuw00007379

10.Remove the bolts.

© 2018 Mazda Motor Corporation.


ac5uuw00008878

11.Remove the front fender panel.

12.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ FRONT FENDER STAY REMOVAL/INSTALLATION
id091000803900

id091000803900

Front Fender Stay (LH)

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Seal board upper (See SEAL BOARD UPPER REMOVAL/INSTALLATION.) (2)Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.) (3)Front combination light (See FRONT
COMBINATION LIGHT REMOVAL/INSTALLATION.)

3.Remove the fastener.

ac5uuw00008887

4.Remove the nut.

© 2018 Mazda Motor Corporation.


ac5uuw00008888

5.Remove the relay box.

6.Remove the wiring harness clips.

ac5uuw00008889

7.Remove the bolts.

© 2018 Mazda Motor Corporation.


ac5uuw00008890

8.Remove the front fender stay (LH).

9.Install in the reverse order of removal. (See Front Fender Stay Paint Note.)

Front Fender Stay (RH)

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Seal board upper (See SEAL BOARD UPPER REMOVAL/INSTALLATION.) (2)Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.) (3)Front combination light (See FRONT
COMBINATION LIGHT REMOVAL/INSTALLATION.)

3.Remove the fastener.

© 2018 Mazda Motor Corporation.


ac5uuw00008891

4.Remove the ground bolts.

ac5uuw00008892

5.Remove the grounds.

6.Remove the bolts.

© 2018 Mazda Motor Corporation.


ac5uuw00008893

7.Remove the front fender stay (LH).

8.Install in the reverse order of removal. (See Front Fender Stay Paint Note.)

Front Fender Stay Paint Note

Caution

• If the bolt contact area is painted when the front fender stay is newly replaced, it could cause a
malfunction in the PCM. Before painting a newly replaced part, protect the bolt contact areas with
masking tape.

Note

• After installing the bolt, apply touch-up paint to the exposed base material area of the front fender
stay.

© 2018 Mazda Motor Corporation.


ac5uuw00008894

© 2018 Mazda Motor Corporation.


■ FRONT OVER FENDER REMOVAL/INSTALLATION
id091000878700

id091000878700

1.Remove the fastener.

ac5uuw00008899

2.Pull the lower front over fender in the direction of the arrow shown in the figure and disengage the tabs.

3.Remove the lower front over fender.

4.Remove the fasteners.

ac5uuw00008900

© 2018 Mazda Motor Corporation.


5.Pull the upper front over fender in the direction of the arrow shown in the figure and detach the clips
starting from the vehicle front.

ac5uuw00005174

6.Remove the upper front over fender.

7.Install in the reverse order of removal.

Warning

• When installing the front over fender, verify that clips are not damaged, if they are damaged,
replace them with new ones. Otherwise, the front over fender may fall off while the vehicle is being
driven, leading to a serious accident.

© 2018 Mazda Motor Corporation.


■ FUEL-FILLER LID REMOVAL/INSTALLATION
id091000800100

id091000800100

1.Remove the bolts.

ac5uuw00008864

2.Remove the fastener.

3.Remove the fuel-filler lid.

4.Install in the reverse order of removal.

5.Adjust the fuel-filler lid. (See FUEL-FILLER LID ADJUSTMENT.)

© 2018 Mazda Motor Corporation.


■ HOOD DISASSEMBLY/ASSEMBLY
id091000965300

id091000965300

1.Disassemble in the order indicated in the table.

ac5uuw00009381

© 2018 Mazda Motor Corporation.


1 Fastener

2 Hood insulator

3 Parting seal weatherstrip

4 Shroud seal weatherstrip

5 Stop rubber

6 Hood

2.Assemble in the reverse order of disassembly.

© 2018 Mazda Motor Corporation.


■ HOOD REMOVAL/INSTALLATION
id091000801200

id091000801200

Warning

• Always perform the procedure with at least another person to prevent the hood from falling.
Otherwise, the hood may fall and cause injury.

1.Remove the bolts.

ac5uuw00006798

2.Remove the hood.

• When removing the hood hinge, perform the following procedure:

1. Remove the bolts.

© 2018 Mazda Motor Corporation.


ac5uuw00006797

2. Remove the hood hinge.

3. Install in the reverse order of removal.

4. Perform the hood adjustment. (SeeHOOD ADJUSTMENT.)

© 2018 Mazda Motor Corporation.


■ REAR BUMPER DISASSEMBLY/ASSEMBLY
id091000800800

id091000800800

1.Disassemble in the order indicated in the table.

ac5uuw00008875

1 Rear reflector

2 Rear towing hook cover

3 Rear bumper face

2.Assemble in the reverse order of disassembly.

© 2018 Mazda Motor Corporation.


■ REAR BUMPER REINFORCEMENT REMOVAL/INSTALLATION
id091000800900

id091000800900

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Rear splash shield (See SPLASH SHIELD REMOVAL/INSTALLATION.) (2)Rear combination


light (See REAR COMBINATION LIGHT REMOVAL/INSTALLATION.) (3)Rear bumper (See
REAR BUMPER REMOVAL/INSTALLATION.)

3.Remove the hanger rubber in the direction of the arrow shown in the figure.

ac5uuw00007993

4.Remove nuts.

Warning

• Removing the rear bumper reinforcement without supporting it could cause the rear bumper
reinforcement to fall and cause serious injury. Always perform the procedure with at least another
person to prevent the rear bumper reinforcement from falling.

© 2018 Mazda Motor Corporation.


ac5uuw00007994

5.Remove the rear bumper reinforcement in the direction of the arrow shown in the figure.

6.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ REAR BUMPER REMOVAL/INSTALLATION
id091000800700

id091000800700

1.Affix the protective tape to the position shown in the figure to prevent scratches and damage.

ac5uuw00008869

2.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

3.Remove the rear combination right. (See REAR COMBINATION LIGHT REMOVAL/INSTALLATION.)

4.Remove the rear splash shield. (See SPLASH SHIELD REMOVAL/INSTALLATION.)

5.Remove the caps.

ac5uuw00008870

© 2018 Mazda Motor Corporation.


6.Remove screws A and B.

ac5uuw00008871

7.Remove the screws.

ac5uuw00008872

8.Remove the fasteners.

© 2018 Mazda Motor Corporation.


ac5uuw00005108

9.Press the tab of rear under cover and remove it. (with rear under cover)

10.Remove the fasteners.

ac5uuw00005110

11.Detach the rear bumper from the rear bumper slider while holding the rear end of the rear bumper,
moving it in the direction of the arrows shown in the figure, and detaching the hooks.

© 2018 Mazda Motor Corporation.


ac5uuw00008873

12.Move the rear bumper in the direction of the arrow shown in the figure and detach it from rear bumper
bracket.

ac5uuw00008874

Warning

• After removing rear bumper, it may hit the rear over fender and cause a damage and/or injury.
Perform the following procedure to prevent the rear over fender from being damaged.

― Fix the rear over fender and rear fender panel with protective tape.

© 2018 Mazda Motor Corporation.


ac5uuw00005112

13.Remove the rear bumper.

14.Install in the reverse order of removal.

15.If the rear bumper is replaced, perform the blind spot monitoring (BSM) radar test. (with blind spot
monitoring (BSM) system) (See BLIND SPOT MONITORING (BSM) RADAR TEST.)

Caution

• If the rear bumper installation position is changed or individual differences (coating film/thickness)
occur, the blind spot monitoring (BSM) control module radar angle will deviate which could result in
the module not detecting a vehicle approaching from the rear correctly. If the rear bumper is replaced,
perform the blind spot monitoring (BSM) radar test.

© 2018 Mazda Motor Corporation.


■ REAR OVER FENDER REMOVAL/INSTALLATION
id091000878800

id091000878800

1.Remove the fastener.

ac5uuw00008901

2.Remove the fastener.

ac5uuw00008902

© 2018 Mazda Motor Corporation.


3.Remove the tab.

ac5uuw00008903

4.Pull the rear over fender in the direction of the arrow shown in the figure and remove it.

© 2018 Mazda Motor Corporation.


ac5uuw00008928

5.Install in the reverse order of removal.

Warning

• When installing the front over fender, verify that clips are not damaged, if they are damaged,
replace them with new ones. Otherwise, the front over fender may fall off while the vehicle is being
driven, leading to a serious accident.

© 2018 Mazda Motor Corporation.


■ SEAL BOARD UPPER REMOVAL/INSTALLATION
id091000466600

id091000466600

1.Remove the fasteners.

ac5uuw00008863

2.Remove the seal board upper in the direction of the arrow shown in the figure.

3.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ SEAL PLATE REMOVAL/INSTALLATION
id091000889000

id091000889000

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the seal board upper. (See SEAL BOARD UPPER REMOVAL/INSTALLATION.)

3.Remove the front bumper. (See FRONT BUMPER REMOVAL/INSTALLATION.)

4.Remove the fasteners.

ac5uuw00008910

5.Remove the seal plate in the direction of the arrow shown in the figure while detaching the tab.

6.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ SET PLATE REMOVAL/INSTALLATION
id091000878900

id091000878900

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the seal board upper. (See SEAL BOARD UPPER REMOVAL/INSTALLATION.)

3.Remove the front bumper. (See FRONT BUMPER REMOVAL/INSTALLATION.)

4.Remove the cap.

ac5uuw00008905

5.Remove the bolt.

6.Remove the fasteners.

© 2018 Mazda Motor Corporation.


ac5uuw00008929

7.Remove the tabs.

8.Remove the set plate in the direction of the arrow shown in the figure.

9.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.


■ SHROUD PANEL REMOVAL/INSTALLATION
id091000801900

id091000801900

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Seal board upper (See SEAL BOARD UPPER REMOVAL/INSTALLATION.) (2)Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.) (3)Front combination light (See FRONT
COMBINATION LIGHT REMOVAL/INSTALLATION.) (4)Set plate (See SET PLATE
REMOVAL/INSTALLATION.) (5)Energy-absorbing form (See ENERGY-ABSORBING FORM
REMOVAL/INSTALLATION.) (6)Front under cover No.1 (See FRONT UNDER COVER No.1
REMOVAL/INSTALLATION.) (7)Active air shutter (with active air shutter) (See ACTIVE AIR
SHUTTER REMOVAL/INSTALLATION.) (8)Charge air cooler (SKYACTIV-D 2.2) (See CHARGE
AIR COOLER REMOVAL/INSTALLATION [SKYACTIV-D 2.2].) (9)Bumper stiffener lower (See
BUMPER STIFFENER LOWER REMOVAL/INSTALLATION.) (10)Seal plate (See SEAL PLATE
REMOVAL/INSTALLATION.) (11)Front bumper reinforcement (See FRONT BUMPER
REINFORCEMENT REMOVAL/INSTALLATION.) (12)Horn (See HORN
REMOVAL/INSTALLATION.) (13)Shroud upper member (See SHROUD UPPER MEMBER
REMOVAL/INSTALLATION.) (14)Radar unit (with Mazda radar cruise control (MRCC) system) (See
RADAR UNIT REMOVAL/INSTALLATION.) (15)Hood latch (See HOOD LATCH
REMOVAL/INSTALLATION.) (16)Crash zone sensor (See CRASH ZONE SENSOR
REMOVAL/INSTALLATION [STANDARD DEPLOYMENT CONTROL SYSTEM - MEXICO SPEC.].)
(See CRASH ZONE SENSOR REMOVAL/INSTALLATION [TWO-STEP DEPLOYMENT CONTROL
SYSTEM - US/CANADA SPEC.].) (17)Ambient temperature sensor (See AMBIENT
TEMPERATURE SENSOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER].)
(18)Fresh air duct installation bolt (See INTAKE-AIR SYSTEM REMOVAL/INSTALLATION
[SKYACTIV-G 2.5 (WITH CYLINDER DEACTIVATION)].) (See INTAKE-AIR SYSTEM
REMOVAL/INSTALLATION [SKYACTIV-G 2.0, SKYACTIV-G 2.5 (WITHOUT CYLINDER
DEACTIVATION)].) (See INTAKE-AIR SYSTEM REMOVAL/INSTALLATION [SKYACTIV-D 2.2].)

3.While pressing the tabs of wiring harness clips A and B in the directions of the arrows, remove wiring
harness clips A and B secured to the shroud panel.

© 2018 Mazda Motor Corporation.


ac5uuw00008882

4.Relocate the hood stay to the position shown in the figure.

ac5uuw00006859

© 2018 Mazda Motor Corporation.


5.Press down the tabs shown in the figure in the direction of the arrow, pull out the upper mount rubber
bracket toward the vehicle rear, and remove it.

ac5uuw00008883

6.Pull up the radiator in the direction of arrow (1) shown in the figure.

Warning

• Removing the shroud panel without supporting it could cause the shroud panel to fall and cause
serious injury. Always perform the procedure with at least another person to prevent the shroud panel
from falling.

© 2018 Mazda Motor Corporation.


ac5uuw00008884

7.Pull down the shroud panel in the direction of arrow (2) shown in the figure, then remove it from the
radiator mount guide.

8.Remove the shroud panel.

Caution

• Support the lower surface of the radiator with a jack to prevent the radiator from falling off after the
shroud panel is removed.

© 2018 Mazda Motor Corporation.


ac5uuw00006862

9.Install in the reverse order of removal.

10.Adjust the headlight aiming. (See HEADLIGHT AIMING.)

11.Adjust the radar unit aiming. (with MRCC system) (See RADAR UNIT AIMING.)

© 2018 Mazda Motor Corporation.


■ SHROUD UPPER MEMBER REMOVAL/INSTALLATION
id091000889800

id091000889800

1.Disconnect the negative battery terminal. (See NEGATIVE BATTERY TERMINAL


DISCONNECTION/CONNECTION.)

2.Remove the following parts:

(1)Seal board upper (See SEAL BOARD UPPER REMOVAL/INSTALLATION.) (2)Front bumper
(See FRONT BUMPER REMOVAL/INSTALLATION.) (3)Front combination light (See FRONT
COMBINATION LIGHT REMOVAL/INSTALLATION.) (4)Horn (See HORN
REMOVAL/INSTALLATION.)

3.Remove the bolts.

ac5uuw00006844

4.Remove the shroud upper member.

5.Install in the reverse order of removal.

© 2018 Mazda Motor Corporation.

You might also like