Professional Documents
Culture Documents
Module:
Subject: Duration:
Workshop
Basic Mechanical Fitting Practices (Common) Hrs
Technology
Task/Project Title:
Fabricate a Vee Block Location:
Workshop
Marking Out (Practical 1)
Instructor:
Trainee: Matric No.
SIR. NASARUDIN BIN
MITCHELL BRAPUI TIDAN 012022020436
ABDULLAH
SCORE TABLE
MAXIMUM MARK ACTUAL MARKS
ITEM PARAMETERS INSPECTED
POSSIBLE SCORED
2. Cutting Technique 10
4. Care of component 10
5. Reading a drawing 10
Sheet 1 of 6
DEPARTMENT OF ENGINEERING &TECHNOLOGY
The trainee therefore, is considered competent / not competent enough to perform similar tasks when assigned
to do so.
Instructor
Material Required:
Course Outcome
By the end of this task, students will be able to:
CO1. Carried out fabricate Vee Block with correct safety precaution, references and procedures related to the
project.
CO2. Identify Mild Steel Plate Material.
CO3. Enhance knowledge on proper usage of hacksaw, files, scribing block, surface plate, steel rule, scribers,
drills, fitter square, dividers, centre punch and ball pin hammer.
Sheet 2 of 6
DEPARTMENT OF ENGINEERING &TECHNOLOGY
TASK DESCRIPTIONS
B. SAFETY PRECAUTIONS
1. Read and observed all safety instructions on safety posters displayed in the workshop.
2. Choose and select the correct type of tool.
3. Ensure appropriate personal protective equipment (PPEs) are worn.
4. Read the instruction manual and observed all instructions given.
C. JOB DESCRIPTIONS
3. Mark-out and locate the centre point also, mark-out the lines for cutting the "Vee"-piece [Refer Drawing)
D. PRECAUTION
(1) Always use goggle when using electrical bench drilling machine
(2) Switch off power whenever changing drill bit in the chuck or while changing belt and pulley position for
adjusting spindle speed
E. HOUSEKEEPING / LOOSE ARTICLE CHECK
1. Clean the tools and equipment.
2. Return all the tools to the tool store.
3. Tidy up the workshop.
4. Switch off all electrical appliances and lights before leaving
Sheet 3 of 6
DEPARTMENT OF ENGINEERING &TECHNOLOGY
DRAWING
Sheet 4 of 6
DEPARTMENT OF ENGINEERING &TECHNOLOGY
3. Safety precautions
Safety precautions are the most significant key in workshop technology for protecting worker’s well-being and
reducing the likelihood of accidents. The lecturer provided safety measures during Lab 1, and the recommendations
were followed. The safety precautions were as follows:
a) Safety Briefing - The lecturer provided a safety briefing before the lab began, which the students acknowledged
when they were briefed. The briefing covers appropriate tool use, how to use the tools, and safety precautions when
using the drilling machine. To ensure the utmost level of safety, the lecturer meticulously supervised every move.
b) Use of safety goggles - Students were required to wear safety goggles during the drilling technique to prevent
metal chips from entering or harming their eyes. To ensure maximum safety, the lecturer would ensure that the
trainees were wearing goggles before beginning the drilling technique.
Sheet 5 of 6
DEPARTMENT OF ENGINEERING &TECHNOLOGY
Sheet 6 of 6