Professional Documents
Culture Documents
MUMBAI
ON
“INDUSTRIAL TRAINING ”
SUBMITED BY
Avinash M. Sable (TY ME 2110920122 )
Approved By AICTE, New Delhi Recognized By: Govt. Of Maharashtra & DTE, Mumbai
CERTIFICATE
Name of students
HOD Principal
ACKNOWLEDGEMENT
Every orientation work has been the imprint of many people and this work is no
different. This work gives us opportunity to express deep gratitude for the same.
While preparing project Proposal Report, we received endless help from number of
people. This report would be incomplete if we don’t convey our sincer thanks to all those
who involved.
First and Foremost I thanks to my Guide Mr.Sambhaji .S.Sathe for his continuous
help and constant guidance and Mr.Sambhaji. S.Sathe (Project Co-coordinator) for their
encouragement and inspiration... I am also thankful to Mr. H. P. kale (H.O.D. - Department
of Mechanical Engineering SYP, chh. Sambhaji Nagar ) and Principal Mr. S. D. kandagale sir
for hir endless motivation.
Date-
Place- Aurangabad
Submitted By
Avinash M. Sable.
DECLARATION
I hereby declare that the project Proposal report entitled; “ Industrial training Report
”, submitted by me to Shreeyash Polytechnic Aurangabad in partial fulfillment of award of
Diploma in Mechanical Engineering is the record of benefit project work carried out by me
under the Guidance of Mr. S. S. Sathe.
Date-
Submitted By
Avinash M. Sable
INDEX
Acknowledgement……..Page I
Declaration……………. Page II
Abstract………………. Page V
1 Introduction 01
2 Literature Review 02
5 Methodology 07
8 Action Plan 17
11 References 20
LIST OF FIGURES
Pneumatic is a branch of engineering that dealswhich study of air/gas characteristic and also
their use inengineering appliances either in atmospheric or aboveatmospheric pressure. Now
a day number of applicationincreases in pneumatics system due to high carryingcapacity, low
maintenance cost and most important notdangerous. Either compressed air or inert gas are
generallyused, this paper deals with different components ofpunching machine and their
assembly and alsotheir related diagrams.
A pneumatic punching machine is always a better choice than a hydraulic punching machine
to produce similar products if it is suited for the method. It is comparatively more economical
for production of large quantities of products as it uses compressed air rather than some
hydraulic fluid which is rather expensive. A pneumatic punching machine uses compressed
air to generate high pressure to be applied on the piston. A solenoid valve controls the
directional flow of air into and out of the cylinder. Polyurethane tubes are used for pressure
transmission from the pneumatic cylinder to the punch assembly. The high-pressure air fed to
the punch, forces it on the material and as the punch descends upon the sheet, the pressure
exerted by the punch first cause the plastic deformation of the sheet.