Professional Documents
Culture Documents
Cummins G12 Engine Coolant For Use in Aggreko Engines
Cummins G12 Engine Coolant For Use in Aggreko Engines
G32300023
Engine Coolant for use in Aggreko Rev. C
Engines
Created by R. Davies
Page 1 of 2
During the manufacturing process high purity water is blended with concentrated coolant at a 50/50 ratio to
produce a ready to use “Pre-Mix” coolant, this concentration provides corrosion and freeze protection down to
o
a level of -37 C. For Winterisation applications a 60/40 ratio (60% Coolant 40% water) should be used which
o
provide additional freeze protection down to -60 C:
Note: All Aggreko Manufacturing production built units from October 2014 are pre-filled with Cummins ES
Compleat OAT.
*Note: In some areas of the World, Cummins ES Compleat is only available in Propylene Glycol premix
formulation due to local legislation.
WARNING: IT IS NOT RECOMMENDED TO MIX COOLANT TYPES, ONLY PREMIX COOLANT MUST BE
USED TO FILL AND TOP UP COOLANT SYSTEM’S, WATER MUST NEVER BE USED AS THIS MAY
CAUSE PREMATURE COMPONENT FAILURES.
For further information relating to the use of OAT coolant please refer to M05000313 REVA