Professional Documents
Culture Documents
Miscellaneous Products Used On Helicopters: 312. Use of Dry Lubricating Films
Miscellaneous Products Used On Helicopters: 312. Use of Dry Lubricating Films
Y
These products having high concentration of solid lubricants (molybdenum disulphide)
AR
are used to form thin and high strength films of dry lubricants.
BR
(a) Spray 321r
LI
This varnish is used to form dry lubricant films in a few minutes. Its sliding
inorganic base is suitable for use from -180˚C to +650˚C.
ER
This product can be stored for 5 years.
PT
The Molykote G Rapid Plus Spray has a particularly low friction coefficient and is
suitable for the assembly and running-in of metal components.
O
Its operating temperature range is from - 35˚C to + 450˚C.
C
Characteristics:
- Facilitates disassembly
- Good covering power
- Good performance in the event of insufficient lubrication.
D
(3) Scope
These products are to be used only when required on the documentation and in the
following cases :
20-01-01-312 Page 1
This page is printed under user's responsibility
2010.07.30
and must not be retained for reference
STANDARD PRACTICES MANUAL ALL
(4) Procedure
Y
product.
AR
(b) Application of molykote compound
- For SPRAY 321R, spray while holding the can at 15-20 cm from parts. Apply
BR
a thin film as evenly as possible.
After 10 mn of curing, a slight burnishing is recommended.
- For the Molykote G Rapid Plus Spray
LI
1. Clean the sliding or contact surfaces, then apply the spray
2. Avoid excess product
ER
3. Do not mix with greases or oils.
- Once treated, actuate the components without load for one or two minutes.
PT
Check for any lubricant film breakdown ; touch up if required.
- Renew the first application, while checking for film breakdown.
O
NOTE
C
O
Mix well before use. Spray molykote on the friction surfaces using a suitable spray
gun in a thin uniform coat at a distance of approximately 15 to 20 cm.
M
20-01-01-312 Page 2
This page is printed under user's responsibility
END OF MODULE 2010.07.30
and must not be retained for reference