Professional Documents
Culture Documents
H00360200 F3 Week3
H00360200 F3 Week3
I have been given guidance on the basic of PLC. I have done some wiring connection to Delta
PLC and make sure that the output is correct. I have successfully connected PC to PLC using
ethernet cable and use node-red to communicate with PLC through Modbus TCP. I understand
the flow that implemented by my supervisor. I explore on Proxmox Virtual Environment and
found that there has network connection issue.
Page 1 of 5
HWUM/IT/F3
Supervisor evaluation
Name : Ng Wai Chong Designation : Control System Engineer
Student score (Check the appropriate box)
Poor Satisfactory Average Good Excellent
1☐ 2☐ 3☐ 4☐ 5☐ 6☐ 7☐ 8☐ 9 ☒ 10☐
Comments:
Signature: Stamp:
Note: Daily log sheet/s should be filled and submitted along with this form.
Form 3 must be produced and evaluated for every week on industrial training.
Page 2 of 5
HWUM/IT/F3
Training
Wiring Configuration for Delta PLC (DVP-12SE)
Connect Delta PLC (DVP-12SE) with PC
Explore on Proxmox Virtual Environment
Details of activities
Tasks/Activities:
I do wire connection that connects two normally on buttons with Delta PLC.
I test and make sure that the output for that PLC must be same as the table below.
Tasks/Activities:
Page 3 of 5
HWUM/IT/F3
Tasks/Activities:
Tasks/Activities:
Page 4 of 5
HWUM/IT/F3
Tasks/Activities:
Knowledge gained
Ubuntu VM in Proxmox VE cannot connect to any network. By inserting a TP-Link adapter into the
PC can solve that problem.
Proxmox VE cannot recognize TP-Link.
Page 5 of 5