Professional Documents
Culture Documents
Figure P6-1
Figure P6-2
Tolerancing
2. Given the method of calculation, basic size, fit (i.e. clearance, interference, or transition),
tolerances, and the allowance, determine the limits on the hole and shaft.
a. b. c. d. e.
Method of
Shaft Hole Hole Shaft Hole
Calculation
Tolerance on
0.200 0.0015 0.0010 0.016 0.025
Hole
Tolerance on
0.100 0.0014 0.0007 0.014 0.024
Shaft
Method of Calculation Basic Hole Basic Shaft Basic Hole Basic Hole
e. f. g. h.
Method of Calculation Basic Hole Basic Hole Basic Shaft Basic Hole
Preferred
Preferred Preferred Shaft
Method of Calculation Hole Preferred Hole Basis
Hole Basis Basis
Basis
e. f. g. h.
Locational Locational
Sliding Force
Class of Fit Transition Interference
H7/g6 U7/h6
N7/h6 H7/p6
A B
C D
Construct all extension lines, dimension lines, leaders, and arrowheads that are necessary
to fully dimension the objects.
A B
C D