Professional Documents
Culture Documents
Service
Repair Instructions
Replacement of the locking lever for "flying wing"
English
Print No.: SPB7-230.091.10.01.02 Doc. Gen. Date: 02.00
Replaces: RXB7-230.091.03.02.02 65 58 717
0-2 Revision
Page
1 _______General _______________________________________________________ 1 - 1
Purpose . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1- 1
Tools required . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 - 1
Time required . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 - 1
Contents of update kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1- 1
2 _______Procedure_____________________________________________________ 2 - 1
Dismounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 1
Kit mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 4
Final procedures. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 4
Purpose 1
This document describes how to change a broken or worn locking lever for the "flying
wing".
Tools required 1
Time required 1
The update kit (Part No. 64 21 528) contains the following parts:
Dismounting 2
3
MAM00224
Screw 1
Screw 3
MAM00225
Screw 2
9. Loosen the rotation stop screw (2/Fig. 4). Then turn the object table arm further
clockwise to make the two screws accessible.
MAM00661
Kit mounting 2
1. Coat the outside of the locking pawl with general purpose grease. Attach the lever
assembly to the holder with the new spring, the new locking pin and the new
locking rings (Fig. 5).
locking ring/D
locking pin/C
spring/B
lever assembly/A
(locking pawl)
MAM00662
holder/E
2. Check the surface of the large ring, on which the pawl slides during rotation of the
"flying wing". If rough spots are found, use a fine abrasive cloth to smoothen the
surface.
3. Coat lightly with general grease the contact area between the locking pawl and the
large ring on which the pawl slides during rotation of the "flying wing".
Final procedures 2